IllustrationI WAS IN A CAR ACCIDENT WITH A 2008 TOYOTA PRIUS. I WAS TRAVELING APPROX 30 MILES PER HOUR AND HIT A PARKED CAR WITH MY FRONT PASSENGER TIRE. THE CAR IS POTENTIALLY TOTALED. MY AIRBAGS DID NOT DEPLOY AND I HIT THE STEERING WHEEL AND SUSTAINED A CONCUSSION. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
What owners actually said
1,497 reports2008 TOYOTA PRIUS PASSENGER SIDE HID XENON HEADLAMP GOING ON AN OFF RANDOMLY. WENT TO TOYOTA DEALER THEY SAID IT WAS THE BULB AND WHEN REPLACING THE BULB THE MECHANIC FOUND OUT THE HEADLAMP CONNECTOR WAS CORRODED. I PAID FOR A NEW BULB AND CONNECTOR. MY PROBLEM IS HOW A VEHICLE WITH ONLY 40,000 MILES COULD HAVE CORRODED WIRE …
Read full complaint
2008 TOYOTA PRIUS PASSENGER SIDE HID XENON HEADLAMP GOING ON AN OFF RANDOMLY. WENT TO TOYOTA DEALER THEY SAID IT WAS THE BULB AND WHEN REPLACING THE BULB THE MECHANIC FOUND OUT THE HEADLAMP CONNECTOR WAS CORRODED. I PAID FOR A NEW BULB AND CONNECTOR. MY PROBLEM IS HOW A VEHICLE WITH ONLY 40,000 MILES COULD HAVE CORRODED WIRE CONNECTORS ALREADY. THE BILL WAS $353. *TR
IN 2008, I BOUGHT THE NEW PRIUS 2008. ON JANUARY 11, 2008 I AM DRIVING WITH SPEED 35 MPH AND HEAD-ON CRASH IT BY A CAR FROM OPPOSITE DIRECTION WITH SPEED 40MPH HEAD ON COLLISION ON 2/3 OF THE CAR FROM A DRIVER SIDE WERE DAMAGE, THE ENGINE SPLIT AND AN HALF. THE CAR WERE TOTAL LOSS..BUT THE AIRBAG DID NOT DEPLOY. CALL TOYOTA EXPE…
Read full complaint
IN 2008, I BOUGHT THE NEW PRIUS 2008. ON JANUARY 11, 2008 I AM DRIVING WITH SPEED 35 MPH AND HEAD-ON CRASH IT BY A CAR FROM OPPOSITE DIRECTION WITH SPEED 40MPH HEAD ON COLLISION ON 2/3 OF THE CAR FROM A DRIVER SIDE WERE DAMAGE, THE ENGINE SPLIT AND AN HALF. THE CAR WERE TOTAL LOSS..BUT THE AIRBAG DID NOT DEPLOY. CALL TOYOTA EXPERIENCE (1-800-331-4331) BUT THEY DO NOT WANT TO TAKE ANY ACTIONS. I HIT THE STEERING WHEEL HARD CHIP 2 OF MY TEETH, LOOSING 4 AND SUFFERED NECK,BACK, SHOULDER,AND KNEE, CUT AND BRUISES. *TR
RIGHT HEADLIGHT GOES OUT AND YOU HAVE TO TURN LIGHT SWITCH OFF AND BACK ON FOR IT TO COME BACK ON. THE TIME RANGE ON THE LIGHT GOING OFF VARIES FROM TIME TO TIME. IT CAN HAPPEN AS FAST AS EVERY 2-3 MINUTES. THE BALLAST AND BULB HAS BEEN REPLACED AND THIS DID NOT CORRECT THE PROBLEM. *TR
ON 3 SEPARATE DAYS, 2 DURING THE SUMMER OF 2009 AND 1 DURING THE SUMMER OF 2010, OUR PRIUS TRANSMISSION HAS AUTOMATICALLY AND REPEATEDLY SHIFTED FROM D (DRIVE) TO N (NEUTRAL) WITHOUT WARNING WHILE THE CAR WAS MOVING. ALL INCIDENTS HAPPENED ON EXTREMELY HOT DAYS (TEMPERATURES NEAR 100) IN THE AFTERNOON AFTER THE CAR HAD BEEN PAR…
Read full complaint
ON 3 SEPARATE DAYS, 2 DURING THE SUMMER OF 2009 AND 1 DURING THE SUMMER OF 2010, OUR PRIUS TRANSMISSION HAS AUTOMATICALLY AND REPEATEDLY SHIFTED FROM D (DRIVE) TO N (NEUTRAL) WITHOUT WARNING WHILE THE CAR WAS MOVING. ALL INCIDENTS HAPPENED ON EXTREMELY HOT DAYS (TEMPERATURES NEAR 100) IN THE AFTERNOON AFTER THE CAR HAD BEEN PARKED OUT IN THE SUN AND WITHOUT US HAVING MADE ANY ACCIDENTAL CONTACT WITH THE SHIFTER / DRIVE SELECTOR WHILE DRIVING. THIS CREATED DANGEROUS SITUATIONS SEVERAL TIMES AS THE CAR ERRATICALLY SLOWED AS WE ENTERED INTERSECTIONS OR PULLED OUT ONTO BUSY STREETS. OUR INITIAL RESPONSE WAS TO DEPRESS THE ACCELERATOR, BUT WHEN THIS HAD NO EFFECT, WE DISCOVERED THE TRANSMISSION LIGHT HAD MOVED FROM D TO N. IT WAS ESPECIALLY DANGEROUS WHEN MAKING LEFT HAND TURNS ON BUSY STREETS WITH ONCOMING TRAFFIC. WE DISCOVERED THAT WE COULD KEEP THE CAR MOVING BY CONSTANTLY HOLDING THE SHIFTER / DRIVE SELECTOR LEVER IN THE D POSITION. TURNING OFF THE AIR CONDITIONER DID NOT HELP THE PROBLEM. AFTER THE FIRST TIME THIS HAPPENED, WE TOOK THE CAR TO THE DEALERSHIP TO INVESTIGATE THE PROBLEM, BUT THE SERVICE TECHNICIANS THERE WERE UNABLE TO REPRODUCE IT. THIS GLITCH REMAINS A CONCERN TO US BECAUSE THE LOSS OF POWER AND ACCELERATION IS UNPREDICTABLE AND THEREFORE DANGEROUS, BUT AT LEAST WE KNOW WE CAN KEEP THE CAR MOVING BY HOLDING THE SHIFTER IN THE D POSITION. BECAUSE THE CAR IS SO COMPUTERIZED, I SUSPECT AN ELECTRONIC COMPONENT OF THE DRIVE SYSTEM MAY MALFUNCTION AT HIGH TEMPERATURES. THE MILEAGE NUMBER I GAVE IS AN APPROXIMATION SINCE I DIDN'T RECORD THE ACTUAL MILEAGE WHEN THIS FIRST HAPPENED, BUT THE DEALER WHO SERVICED THE CAR SHORTLY THEREAFTER SHOULD HAVE THAT INFORMATION.
TL* THE CONTACT OWNS 2008 TOYOTA PRIUS. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED OVER A ROAD BUMP, THE BRAKES WOULD FAIL MOMENTARILY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE CONTACT WAS ADVISED THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED BY AN AUTHORIZED DEALER. THE MANUFACTURER ADVISED THAT THE VEHICLE WOU…
Read full complaint
TL* THE CONTACT OWNS 2008 TOYOTA PRIUS. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED OVER A ROAD BUMP, THE BRAKES WOULD FAIL MOMENTARILY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE CONTACT WAS ADVISED THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED BY AN AUTHORIZED DEALER. THE MANUFACTURER ADVISED THAT THE VEHICLE WOULD BE INSPECTED WITHIN SIXTY DAYS. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 40,000.
2008 TOYOTA PRIUS DRIVER SIDE HID HEADLIGHT WENT OUT PREMATURELY. *TR
THERE WERE NO DISTINGUISHING EVENTS THAT LED UP TO THE TOTAL FAILURE OF MY 2008 TOYOTA PRIUS DRIVER SIDE HEADLIGHT AND DOOR LOCK ASSEMBLY (FRONT). THEY BOTH NO LONGER WORKED WITHIN A 1 DAY PERIOD AND REQUIRED REPLACEMENT. NOTICING 2 OR MORE OTHER VEHICLES OF THE SAME MAKE AND MODEL THERE FOR LIGHT REPLACEMENT CAUSED ME TO INQU…
Read full complaint
THERE WERE NO DISTINGUISHING EVENTS THAT LED UP TO THE TOTAL FAILURE OF MY 2008 TOYOTA PRIUS DRIVER SIDE HEADLIGHT AND DOOR LOCK ASSEMBLY (FRONT). THEY BOTH NO LONGER WORKED WITHIN A 1 DAY PERIOD AND REQUIRED REPLACEMENT. NOTICING 2 OR MORE OTHER VEHICLES OF THE SAME MAKE AND MODEL THERE FOR LIGHT REPLACEMENT CAUSED ME TO INQUIRE WHAT CAUSED THEIR LIGHT MALFUNCTIONS. IN THE MATTER OF MINUTES OF MY CALLING IN, ROUGHLY AN HOUR INTO THE DEALERSHIPS OPENING, I WAS TOLD THE LIGHTS WERE AVAILABLE, BY THE TIME ARRIVED, WITHIN 5 MINUTES, ENOUGH AUTOS HAD ARRIVED ALSO WITH THE "HID" HEADLAMPS OUT THAT THE DEALERSHIPS ENTIRE STOCK OF LIGHTS HAD BEEN USED UP, AND REQUIRED MY HAVING TO RETURN AFTER ANOTHER SHIPMENT OF LIGHTS WERE RECEIVED, AS WELL. I DID NOT REQUEST THE OLD PART. *TR
HID HEADLIGHTS ON 2008 PRIUS FAILING WITHOUT A KNOWN FIX FROM TOYOTA. EACH BULB COSTS OVER $150.00. *TR
THE HID HEADLIGHTS ON MY 2008 PRIUS HAVE BEGUN TO FAIL. EITHER ONE MAY NOT TURN ON, OR THEY MAY TURN OFF INDIVIDUALLY BY THEMSELVES. *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606