IllustrationHEADLIGHTS BLINK OUT SINGLY OR AT THE SAME TIME FOR OVER A YEAR NOW. INCREASINGLY BOTH LIGHTS GO OUT OVER LAST YEAR. CAR AT 74000 MILES NOW. CAN BE ONE OR BOTH SO I DOUBT THIS IS A BULB ISSUE. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
What owners actually said
1,497 reportsHID HEADLAMP INTERMITTENT, REPLACED UNDER WARRANTY BUT HAS FAILED AGAIN @ 76,000 MI. *TR
DRIVERS HEADLIGHTS GOES ON AND OFF RANDOMLY. BULBS WILL NOT FIX IT AND THERE IS NO FACTORY FIX FOR THIS PROBLEM. IF THEY BOTH GO OUT AT THE SAME TIME VERY UNSAFE. FOR A FAIRLY NEW CAR. *TR
2008 PRIUS HEADLAMPS INTERMITTENT HID PROBLEM. THIS IS A KNOWN AND COMMON PROBLEM WITH TOYOTA PRIUS 2004-2009. NO RECALL FOR IT THAT I AM AWARE OF, HOWEVER THEY LIGHT WILL GO OUT RANDOMLY. THE COST OF REPAIR CAN BEEN EXTREME. TOYOTA WAS SUED FOR THIS, BUT DID NOT MAKE AN OFFICIAL RECALL (HTTP://WWW.GIRARDGIBBS.COM/TOYOTA-PRIUS…
Read full complaint
2008 PRIUS HEADLAMPS INTERMITTENT HID PROBLEM. THIS IS A KNOWN AND COMMON PROBLEM WITH TOYOTA PRIUS 2004-2009. NO RECALL FOR IT THAT I AM AWARE OF, HOWEVER THEY LIGHT WILL GO OUT RANDOMLY. THE COST OF REPAIR CAN BEEN EXTREME. TOYOTA WAS SUED FOR THIS, BUT DID NOT MAKE AN OFFICIAL RECALL (HTTP://WWW.GIRARDGIBBS.COM/TOYOTA-PRIUS/). WHEN DRIVING MY LIGHTS WILL GO OUT FOR NO REASON. TURN THE SWITCH OFF AND BACK ON WILL SOMETIMES CORRECT THE ISSUE, BUT OTHERS TIMES I HAVE TO WAIT A BIT AND RETRY. THIS IS A DANGER AND SAFETY ISSUE. I HAVE READ WHERE REPAIRS CAN RUN FROM 300 - 1100 PER SIDE TO REPAIR. IN ADDITION, THE REAR LIFT GATE LATCH RUBBER IS BECOMING VERY STICKY. I HAVE AGAIN READ NUMEROUS COMPLAINTS THAT IT EVENTUALLY MELTS AND AGAIN TOYOTA HAS NOT PUT A RECALL IN PLACE FOR THIS. LASTLY THE MPG IS HORRIBLE. IN THE CITY I GET 27 TO 36 RANDOMLY CHANGES, THERE IS NO STABILITY IN THE MPG. IT IS ALL OVER THE BOARD. I AM THE ONLY DRIVER. THIS VEHICLE WAS PURCHASED AT TUSTIN TOYOTA IN TUSTIN CALIFORNIA. THEY HAVE REFUSED ALL CALLS FROM ME. THEY HAVE NOT CALLED BACK AFTER 4 MESSAGES AND TWO INTERNET CHAT MESSAGES. *TR
ONE, THE OTHER, OR BOTH HEADLIGHT TURN OFF UNEXPECTEDLY WHILE DRIVING. ROTATING THE HEADLIGHT CONTROL STALK TO OFF POSITION AND THEN BACK TO ON POSITION WILL RELIGHT THE HEADLIGHTS. THE PROBLEM IS GETTING PROGRESSIVELY WORSE. THERE ARE NOW MULTIPLE INCIDENTS EVEN DURING SHORT TRIPS. *TR
FOLLOWING THE PURCHASE OF MY 2008 TOYOTA PRIUS, WE VISITED A FRIEND WHO TOLD US OUR PASSENGER SIDE HEADLIGHT WAS OUT. WHEN WE TURNED OFF THE LIGHTS AND TURNED THEM BACK ON IT CAME ON. WE HAVE HAD THE DEALER WE PURCHASED THE CAR FROM AND OUR MECHANIC TRY TO FIND THE PROBLEM BUT THE LIGHTS STILL GO OUT, SOMETIMES PASSENGER SIDE, …
Read full complaint
FOLLOWING THE PURCHASE OF MY 2008 TOYOTA PRIUS, WE VISITED A FRIEND WHO TOLD US OUR PASSENGER SIDE HEADLIGHT WAS OUT. WHEN WE TURNED OFF THE LIGHTS AND TURNED THEM BACK ON IT CAME ON. WE HAVE HAD THE DEALER WE PURCHASED THE CAR FROM AND OUR MECHANIC TRY TO FIND THE PROBLEM BUT THE LIGHTS STILL GO OUT, SOMETIMES PASSENGER SIDE, SOMETIMES DRIVER SIDE, AND A FEW TIMES THEY HAVE BOTH GONE OUT. WHEN THE SWITCH IS SHUT OFF AND ON THEY COME BACK ON. I'M AFRAID MY LIGHTS MAY FAIL AND BE THE CAUSE OF AN ACCIDENT. WE, MY HUSBAND AND I, TOOK THE CAR TO A TOYOTA DEALER TO FIX THE SAFETY RECALLS ON THE VEHICLE AND SPECIFICALLY ASKED THEM TO CHECK THE HEADLIGHTS AND DESCRIBED OUR PROBLEMS TO THEM. THEY FAILED TO CHECK OUR LIGHTS BUT GAVE US A CHECKLIST OF OTHER MAINTENANCE SUGGESTIONS. *TR
SOME MONTHS AGO THE DRIVER'S DOOR LOCK STOPPED WORKING. I ENDED UP USING THE KEY TO OPEN THE DOOR FOR A COUPLE OF MONTHS, SINCE TOYOTA DEALER QUOTED ME $500 TO CORRECT THE PROBLEM. AFTER A COUPLE OF MONTHS, I DECIDED TO PAY AND THE ISSUE WAS FIXED. TO MY SURPRISE, THE FRONT PASSENGER DOOR LOCK IS GOING BAD NOW. WHEN I TRY TO UNL…
Read full complaint
SOME MONTHS AGO THE DRIVER'S DOOR LOCK STOPPED WORKING. I ENDED UP USING THE KEY TO OPEN THE DOOR FOR A COUPLE OF MONTHS, SINCE TOYOTA DEALER QUOTED ME $500 TO CORRECT THE PROBLEM. AFTER A COUPLE OF MONTHS, I DECIDED TO PAY AND THE ISSUE WAS FIXED. TO MY SURPRISE, THE FRONT PASSENGER DOOR LOCK IS GOING BAD NOW. WHEN I TRY TO UNLOCK IT FROM WITHIN THE CAR, USING THE "UNLOCK DOORS" BUTTON, IT WILL WORK EVERY 3RD TIME OR SO. CLEARLY A BIGGER ISSUE, NOT ISOLATED TO MY INDIVIDUAL VEHICLE. I ONLY HAVE 70000 MILES AND ALWAYS SERVICED MY VEHICLE AT THE TOYOTA DEALERS. I WOULD LIKE TOYOTA TO PAY TO FIX MY LOCK AND REIMBURSE ME FOR THE ACTUATOR I ALREADY PAID TO REPLACE. *JS
PASSENGER SIDE HEADLIGHT TURNED OFF. WHEN LIGHT SWITCH WAS TOGGLED HEADLIGHT TURNED ON AGAIN. OVER THE COURSE OF A YEAR THE DRIVER SIDE HEADLIGHT EXHIBITED THE SAME PROBLEM, SOMETIMES BOTH HEADLIGHTS HAVE GONE OUT (INCLUDING ON A SECLUDED ROAD AT NIGHT) WITHOUT WARNING. THERE IS NO WARNING LIGHT TO INDICATE EITHER BULB IS MALFUN…
Read full complaint
PASSENGER SIDE HEADLIGHT TURNED OFF. WHEN LIGHT SWITCH WAS TOGGLED HEADLIGHT TURNED ON AGAIN. OVER THE COURSE OF A YEAR THE DRIVER SIDE HEADLIGHT EXHIBITED THE SAME PROBLEM, SOMETIMES BOTH HEADLIGHTS HAVE GONE OUT (INCLUDING ON A SECLUDED ROAD AT NIGHT) WITHOUT WARNING. THERE IS NO WARNING LIGHT TO INDICATE EITHER BULB IS MALFUNCTIONING. CURRENTLY PASSENGER SIDE LIGHT DOES NOT FUNCTION AT ALL, AND NOW THE DRIVER SIDE LIGHT DOES NOT STAY ON MORE THAN 30 SECONDS AT A TIME. *JS
WHILE DRIVING MY 2008 PRIUS AT NIGHT, I HAD MY HEADLIGHTS ON. DRIVING AT APPROX 50 - 60 MPH MY HID FRONT LIGHTS WENT OUT. I WAS IN COMPLETE DARKNESS. I CAN NOT UNDERSTAND WHY THIS NOT A SAFETY RECALL BY NOW BECAUSE I UNDERSTAND THAT THIS IS HAPPENING WITH REGULARITY.
MY HEADLIGHT KEEPS GOING OUT. I KNOW ITS A KNOWN PROBLEM BUT THERE HAS NOT BEEN RECALL AND IT DID NOT OCCUR UNTIL RECENTLY, SO IT DOES NOT FIT IN WITH THE TOYOTA 50,000 MILES AND UNDER RULE. HOWEVER, I HAVE BEEN STOPPED A COUPLE TIMES AND ITS HAPPENING MORE AND MORE EVERY DAY. THIS SHOULD BE RECALLED! *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606