IllustrationI WAS DRIVING MY TOYOTA 2008 PRIUS IN THE PITCH BLACK AT 70-75 MPH IN THE BADLANDS STATE PARK. THE HEADLIGHTS TURNED OFF SPONTANEOUSLY. I HAD TO MAKE AN EMERGENCY STOP. NO HEADLIGHTS!! THEY EVENTUALLY TURNED BACK ON.
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
What owners actually said
1,497 reportsTHE LEFT HEADLIGHT GOES ON AND OFF. THIS IS A RECURRING PROBLEM WITH 2008 PRIUS ACCORDING TO OTHER INTERNET SITES I HAVE VISITED. THERE SHOULD HAVE BEEN A RECALL.
TL* THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STARTED THE VEHICLE AND NOTICED THAT THE BRAKES FAILED TO WORK. THE DEALER STATED THAT THE ABS PUMP FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 127,000.
WHEN I TRIED TO SHIFT MY CAR INTO GEAR, IT AUTOMATICALLY WENT TO NEUTRAL . THIS HAS HAPPENED SEVERAL TIMES IN WARM WEATHER. I HAVE HAD TO DRIVE HOLDING THE LEVER IN THE APPROPRIATE POSITION. THIS IS BOTH CUMBERSOME AS WELL AS EXTREMELY DANGEROUS. I DID CALL MY LOCAL TOYOTA DEALER TO REPORT THE PROBLEM, BUT WAS NEVER CALLED B…
Read full complaint
WHEN I TRIED TO SHIFT MY CAR INTO GEAR, IT AUTOMATICALLY WENT TO NEUTRAL . THIS HAS HAPPENED SEVERAL TIMES IN WARM WEATHER. I HAVE HAD TO DRIVE HOLDING THE LEVER IN THE APPROPRIATE POSITION. THIS IS BOTH CUMBERSOME AS WELL AS EXTREMELY DANGEROUS. I DID CALL MY LOCAL TOYOTA DEALER TO REPORT THE PROBLEM, BUT WAS NEVER CALLED BACK. SINCE THIS OCCURS SPORADICALLY , I JUST LET IT GO. IT HAPPENED AGAIN YESTERDAY, MAY 6, 2015, WHEN I TRIED TO PUT IT IN REVERSE. IT JUMPED TO NEUTRAL & GOT CLOSE TO ROLLING OFF A DROP OFF IN A PARKING LOT. I HELD THE LEVER IN REVERSE, & LUCKILY PREVENTED MY CAR FROM GOING OFF A CLIFF. FRIGHTENING! *TR
I BOUGHT A USED TOYOTA PRIUS 2008 .RIGHT SIDE HEADLIGHT KEEPS TURNING OFF AT NIGHT. *TR
I WAS DRIVING 50MPH WHEN THE CAR LOST POWER.THE CAR SUDDENLY HAD NO POWER BRAKES, NO ABILITY TO EASILY STEER, NO ENGINE POWER AND MANY WARNING LIGHTS CAME ON INCLUDING AN WARNING THAT THE MAIN HYBRID BATTERY WAS NOT CHARGING. THE CAR WOULD NOT RESPOND TO ACCELERATION. THE CAR CAME TO A STOP. I HELD THE START BUTTON THE CAR SHUT …
Read full complaint
I WAS DRIVING 50MPH WHEN THE CAR LOST POWER.THE CAR SUDDENLY HAD NO POWER BRAKES, NO ABILITY TO EASILY STEER, NO ENGINE POWER AND MANY WARNING LIGHTS CAME ON INCLUDING AN WARNING THAT THE MAIN HYBRID BATTERY WAS NOT CHARGING. THE CAR WOULD NOT RESPOND TO ACCELERATION. THE CAR CAME TO A STOP. I HELD THE START BUTTON THE CAR SHUT OFF. THE CAR RESTARTED WITH NO PROBLEMS. ALL THE WARNING LIGHTS WERE OFF. I PUT THE CAR IN DRIVE AND STARTED TO ACCELERATE. ALL THE WARNING LIGHTS COME ON JUST AS BEFORE AND THE CAR SUFFERS THE SAME ISSUES AGAIN. I WENT THROUGH THE SAME PROCESS OF TURNING THE CAR OFF AND TURNING IT BACK ON. THE CAR STARTED UP AGAIN WITH NO PROBLEMS AGAIN, ALL THE LIGHTS WERE OFF. IT FAILED ON MORE TIME ON THE TRIP HOME. I WAS ABLE TO RESTART THE CAR AND PUT MY EMERGENCY LIGHTS ON. I NEVER DROVE OVER 25MPH ON THE TRIP BACK TO THE HOUSE. MY FAMILY TOOK THE CAR TO WILSON TOYOTA IN BELLINGHAM WA. THEY EXAMINED THE CAR AND SAID THE 12V BATTERY HAD FAILED. THEY TOLD MY FAMILY THAT THE MAIN 12V BATTERY RUNS ALL THE ELECTRICAL TO GET THE CAR STARTED AND RUNNING. WE TOLD THE DEALER THE CAR STILL HAD ELECTRICAL POWER. THEY STILL REPLACED THE 12V BATTERY. THE FOLLOWING DAY MY FAMILY WENT TO LOOK AT THE CAR AND A SERVICE PERSON AT THE DEALER, WHO SAID HE WAS NEW TO THIS LOCATION, SAID HE HAD NOTICED THAT THE 12V BATTERY HAD SEEMED TO BE REPLACED RECENTLY. THEY SAID THEY WOULD KEEP THE CAR TO KEEP LOOKING OVER ITS SYSTEMS. ON 4/16/2015 MY FAMILY CALLED TOYOTA TO DISCUSS OUR SAFETY CONCERNS WITH REGARD TO HOW THE CAR FAILED. WE EXPLAINED WE ALSO HAVE A 2007 PRIUS THAT HAD THE MAIN HYBRID BATTERY FAIL AND THAT ALL THE WARNING LIGHTS THAT CAME ON WERE SIMILAR IN BOTH CARS. THE DEALER HAS SAID THERE ARE NO CODES THAT SAID THE MAIN HYBRID BATTERY IS FAILING. I AM WORRIED THAT I OR MY FAMILY COULD BE SERIOUSLY INJURED IF THE CAR FAILED IN THIS MANNER AGAIN WHILE ON A BUSY HIGHWAY OR INTERSECTION. *TR
ENGINE COMPRESSION CATASTROPHICALLY FAILS APPROXIMATELY EVERY 2000 MILES. *TR
I WAS TRAVELING ON A MAJOR HIGHWAY AND ALL MY LIGHTS WENT OUT. PITCH BLACK. LUCKILY, THERE WERE VERY FEW CARS ON THE ROAD. I WAS ABLE TO PULL TO THE SIDE AND PUT MY FLASHERS ON AND USE THEIR INTERMITTENT FLASHING TO SLOWLY FIND MY WAY HOME (ABOUT 8 MORE MILES). THIS COULD HAVE CAUSED FATALITIES - MY OWN AND OTHERS WHO MAY HAVE…
Read full complaint
I WAS TRAVELING ON A MAJOR HIGHWAY AND ALL MY LIGHTS WENT OUT. PITCH BLACK. LUCKILY, THERE WERE VERY FEW CARS ON THE ROAD. I WAS ABLE TO PULL TO THE SIDE AND PUT MY FLASHERS ON AND USE THEIR INTERMITTENT FLASHING TO SLOWLY FIND MY WAY HOME (ABOUT 8 MORE MILES). THIS COULD HAVE CAUSED FATALITIES - MY OWN AND OTHERS WHO MAY HAVE CRASHED INTO ME. THIS WAS A TERRIBLE SITUATION AND FROM WHAT I HAVE JUST RESEARCHED, IT HAPPENS WITH THE PRIUS. NOW I HAVE THE INCONVENIENCE (AND EXPENSE?) OD FIGURING OUT HOW TO GET THIS FIXED SO IT WILL NEVER HAPPEN AGAIN!!!! *TR
THE LEFT HEADLIGHT KEEPS TURNING ITSELF OFF WHEN DRIVING OR NOT. WHEN BUMPED NEXT TO THE HEADLIGHT COVER IT COMES BACK ON. THE BULB AND CONNECTOR ARE FINE. THIS IS A SAFETY HAZARD, THAT IF THE RIGHT ONE STARTS DOING THE SAME THIN AT NIGHT, IT WOULD PUT ME INTO A DANGEROUS AND LIFE THREATENING SITUATION. I THINK TOYOTA SHOULD…
Read full complaint
THE LEFT HEADLIGHT KEEPS TURNING ITSELF OFF WHEN DRIVING OR NOT. WHEN BUMPED NEXT TO THE HEADLIGHT COVER IT COMES BACK ON. THE BULB AND CONNECTOR ARE FINE. THIS IS A SAFETY HAZARD, THAT IF THE RIGHT ONE STARTS DOING THE SAME THIN AT NIGHT, IT WOULD PUT ME INTO A DANGEROUS AND LIFE THREATENING SITUATION. I THINK TOYOTA SHOULD HAVE A RECALL ON THIS PROBLEM. *TR
THE RUBBER COVER ON THE REAR HATCH DOOR LATCH / SWITCH HAS DEGRADED AND MELTED. IT IS IMPOSSIBLE TO OPEN THE REAR HATCH AND TO ACCESS MY SPARE TIRE, MAKING THIS A SAFETY HAZARD. THERE IS NO MANUAL WAY TO RELEASE THE HATCH. THERE HAVE BEEN DOZENS OF COMPLAINTS ON THE NHTSA SITE ABOUT THIS ISSUE, SEE HTTP://WWW.MEYERSONSTRATEGY.C…
Read full complaint
THE RUBBER COVER ON THE REAR HATCH DOOR LATCH / SWITCH HAS DEGRADED AND MELTED. IT IS IMPOSSIBLE TO OPEN THE REAR HATCH AND TO ACCESS MY SPARE TIRE, MAKING THIS A SAFETY HAZARD. THERE IS NO MANUAL WAY TO RELEASE THE HATCH. THERE HAVE BEEN DOZENS OF COMPLAINTS ON THE NHTSA SITE ABOUT THIS ISSUE, SEE HTTP://WWW.MEYERSONSTRATEGY.COM/2013/09/TOYOTAS-STICKY-2007-PRIUS-HATCH-PROBLEM.HTML FOR MORE. THIS SHOULD BE FIXED BY TOYOTA--IT IS A VERY EXPENSIVE ($200-400) REPAIR. *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606