IllustrationTHE HEADLIGHTS WILL SUDDENLY FAIL, EITHER ONE AT A TIME, OR MORE RECENTLY BOTH AT THE SAME TIME WHEN NIGHT DRIVING. I AM ABLE TO FLIP THE SWITCH TO TURN ONE BACK ON BUT NOW THE PASSENGER LIGHT WILL NOT COME BACK ON AT ALL. I AM DRIVING AT NIGHT WHEN I NOTICE THIS HAPPENING BUT IT PROBABLY ALSO HAPPENS IN DAY LIGHT.
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
What owners actually said
1,497 reportsWHILE DRIVING ON THE HIGHWAY THE ABS, VSC, AND (!) LIGHTS CAME ON. THE BRAKE PEDAL BECAME HARD, AND I HAD TO PUSH INCREDIBLY HARD TO SLOW THE VEHICLE. AFTER HAVING THE CODES READ AND RESETTING THE ABS, VSC, (!) LIGHTS, THE BRAKES WORKED AGAIN UNTIL THE LIGHTS CAME ON AGAIN AFTER ABOUT 50 MILES. THE CODES HAVE READ "ACCUMU…
Read full complaint
WHILE DRIVING ON THE HIGHWAY THE ABS, VSC, AND (!) LIGHTS CAME ON. THE BRAKE PEDAL BECAME HARD, AND I HAD TO PUSH INCREDIBLY HARD TO SLOW THE VEHICLE. AFTER HAVING THE CODES READ AND RESETTING THE ABS, VSC, (!) LIGHTS, THE BRAKES WORKED AGAIN UNTIL THE LIGHTS CAME ON AGAIN AFTER ABOUT 50 MILES. THE CODES HAVE READ "ACCUMULATOR PRESSURE FAULT".
THERE WAS BRAKE ACTUATOR FAILURE IN MY CAR WHICH DUE TO PART FAILURE. TOYOTA DID NOT ISSUE A RECALL BUT INSTEAD A WARRANTY ENHANCEMENT. TO ME, THIS SEEMS RIDICULOUS SINCE TOYOTA DID NOT NOTIFY OWNERS AND I WAS NOT AWARE OF THE PROBLEM UNTIL I EXPERIENCED THE PROBLEM AND LUCKILY WAS NOT IN AN ACCIDENT. WE MISSES THE CUT OFF FOR …
Read full complaint
THERE WAS BRAKE ACTUATOR FAILURE IN MY CAR WHICH DUE TO PART FAILURE. TOYOTA DID NOT ISSUE A RECALL BUT INSTEAD A WARRANTY ENHANCEMENT. TO ME, THIS SEEMS RIDICULOUS SINCE TOYOTA DID NOT NOTIFY OWNERS AND I WAS NOT AWARE OF THE PROBLEM UNTIL I EXPERIENCED THE PROBLEM AND LUCKILY WAS NOT IN AN ACCIDENT. WE MISSES THE CUT OFF FOR THE WARRANTY BY A FEW MONTHS. THIS UNEXPECTED EXPENSE SEEMS IS A HUGE FINANCIAL BURDEN TO MY FAMILY FOR A SAFETY ISSUE I FEEL TOYOTA SHOULD MORALLY COVER. ARE THEY WAITING FOR SOMEONE TO BE INJURED DUE TO THIS PROBLEM?
THERE WAS A POPPING NOISE IN MY STEERING WHEEL AND THEN I HAD NO MOVEMENT IN MY TIRES. MY STEERING WHEEL JUST SPINS ROUND AND ROUND BUT MY TIRES WILL NOT MOVE I WAS DRIVING DOWN THE STREET AND I HAD NO CONTROL OF MY CAR. SO I BELIEVE IT HAS SOMETHING TO DO WITH THE STEERING SHAFT OR SUSPENSION.*DT*JB
HEADLIGHTS SHUT OFF WHILE DRIVING AT NIGHT. I RECEIVED TWO WARNING TICKETS FROM HIGHWAY PATROL AS I WAS DRIVING BACK FROM FT. WORTH TO NACOGDOCHES, BUT WHEN I STOPPED, BOTH HEADLIGHTS WERE WORKING. THEN AS I WAS DRIVING, BOTH HEADLIGHTS (WITH BRIGHT LIGHTS ON) TURNED OFF. HAD TO PULL OVER AND THEN THEY STARTED WORKING AGAIN.
THE TRUNK LATCH ON THIS MODEL IS FAULTY AND DANGEROUS. THE MATERIAL USED FOR THE LATCH IS TOO SUSCEPTIBLE TO TEMPERATURE AND EITHER BECOME ROCK HARD IN THE WINTER COLD OR MELTY AND GOOEY IN THE SUMMER HEAT. IT IS ALMOST IMPOSSIBLE TO GET INTO MY TRUNK THROUGH THE BACK LATCH IN THE WINTERTIME. I TRY AND MAYBE IF THE WEATHER IS…
Read full complaint
THE TRUNK LATCH ON THIS MODEL IS FAULTY AND DANGEROUS. THE MATERIAL USED FOR THE LATCH IS TOO SUSCEPTIBLE TO TEMPERATURE AND EITHER BECOME ROCK HARD IN THE WINTER COLD OR MELTY AND GOOEY IN THE SUMMER HEAT. IT IS ALMOST IMPOSSIBLE TO GET INTO MY TRUNK THROUGH THE BACK LATCH IN THE WINTERTIME. I TRY AND MAYBE IF THE WEATHER IS WARM ENOUGH AND IT'S JUST RIGHT, I CAN GET INTO MY TRUNK ABOUT 10 PERCENT OF THE TIME, IF THAT. RECENTLY, I TRIED TO OPEN MY TRUNK UNSUCCESSFULLY. IT OPENED ENOUGH TO NOT BE SECURELY SHUT, BUT NOT ENOUGH TO POP OPEN. I WAS THEN ALSO UNABLE TO SHUT THE TRUNK. WHAT ENDED UP TRANSPIRING WAS A TRUNK THAT WOULD REGISTER AS OPENING AND SHUTTING, WITHOUT THE ACTUAL ABILITY TO FULLY OPEN IT OR SHUT IT. SO THE CAR DOOR LIGHT MUST HAVE COME ON AT SOME POINT AND DRAINED MY BATTERY WHICH THEN LEFT ME STRANDED ON A WINTER DAY IN A COLD PARKING LOT AWAY FROM HOME. ALL BECAUSE TOYOTA EFFED UP AND USED A VERY POOR CHOICE IN MATERIALS FOR THEIR TRUNK LATCHES. THIS IS SOMETHING THAT THEY SHOULD CORRECT SO OTHER PEOPLE DON'T HAVE TRUNK ISSUES THAT END UP CAUSING PROBLEMS. IF SOMEONE NEEDS TO OPEN THEIR TRUNK IN THE WINTER TIME TO RETRIEVE MEDICINE, LIKE AN EPI-PEN, THEN THEY ARE SCREWED. IF SOMEONE NEEDS TO OPEN THE LATCH TO HELP REMOVE AN ANIMAL OR CHILD OUT OF A CAR FOR WHATEVER REASON, THEY ARE SCREWED. IF THEY JUST SIMPLY WANT TO HAVE TRUNK FUNCTIONALITY FOR HAULING GROCERIES, THEY ARE SCREWED. AND IF THEY ARE LIKE ME AND MANAGE TO UNFORTUNATELY FIND THAT SWEET SPOT WHERE THE TRUNK ONLY PARTIALLY OPENS, BUT NOT FULLY, AND THEIR BATTERY ENDS UP BECOMING DRAINED AND THEY ARE STRANDED IN THE MIDDLE OF NOWHERE, THEY ARE ALSO SCREWED. TOYOTA MADE A MISTAKE, AND THEY SHOULD DO SOMETHING TO FIX IT. I LOVE MY PRIUS, BUT THIS ONE TRUNK LATCH ISSUE IS ENOUGH TO MAKE ME RECONSIDER OTHER CARS WITH FUNCTIONAL DOOR LATCHES.
WENT OFF THE ROAD INTO A DITCH TO AVOID A DEER. DITCH WAS IM GUESSING ABOUT 4 FOOT DEEP . AIR BAGS DID NOT WORK. HIT MY HEAD AND HAVE A LARGE BRUISE ON MY CHEST .
WE HAVE A 2008 PRIUS HYBRID. **BRAKE ACENTUATOR HAS FAILED** WHEN THE BRAKE PEDAL IS APPLIED, THE VEHICLE CONTINUES TO MOVE AND THEN THE VEHICLE SUDDENLY STOPS (WITHOUT NOTICE). I TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED OF THE RECALL. APPRECIATE YOUR SUPPORT. DUE TO A CLASS ACTION SUIT AGAINST TOYOTA FOR …
Read full complaint
WE HAVE A 2008 PRIUS HYBRID. **BRAKE ACENTUATOR HAS FAILED** WHEN THE BRAKE PEDAL IS APPLIED, THE VEHICLE CONTINUES TO MOVE AND THEN THE VEHICLE SUDDENLY STOPS (WITHOUT NOTICE). I TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED OF THE RECALL. APPRECIATE YOUR SUPPORT. DUE TO A CLASS ACTION SUIT AGAINST TOYOTA FOR THIS PROBLEM, THEY EXTENTED THE WARRANTY. APPARANTLY I FALL OUT OF THE DATE SPECIFIED. THIS IS A PROBLEM WHERE THOUSANDS OF VEHICLES ARE ON THE ROAD WITH AN IDENTIFIED ISSUE. TOYOTA DOES NOT WANT TO ASSIST ME IN ANY WAY. AS A VETERAN WITH 100% DISABILITY, I AM REQUESTING FOR THIS ISSUE TO BE REOPENED IMMEDIATELY, AND ASSIST OWNERS CORRECT A EXTREMELY DANGEROUS SAFETY PROBLEM. THIS PROBLEM IS COSTING CLOSE TO $3000.00 FOR REPAIR. MY CONTACT INFORMATION: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
DURING THE ACCIDENT, THE BACK SEAT FELL DOWN. I AM ASSUMING IT HAPPENED DUE TO THE FORCE OF THE IMPACT BUT IT WAS TERRIFYING BECAUSE SOMETIMES WE HAVE OUR CHILDREN REAR FACING IN THAT VEHICLE. THE VEHICLE WAS REAR-ENDED ON THE FREEWAY AND THE GLASS WAS BROKEN IN THE BACK FROM THE IMPACT.
WHEN PRESSING THE BRAKE DURING STATIONARY OR IN WHILE IN MOTION THE ABS ACTUATOR STARTS TO MAKE NOISE.
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606