NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
50 reportsClear category filterMileage unknown · Jul 7, 2020
Unknown Or Other
THE BACK LATCH OF MY 2008 TOYOTA PRIUS HAS DEGRADED AND NO LONGER FUNCTIONS. I AM UNABLE TO OPEN THE BACK HATCH DOOR. I AM CONCERNED THAT IN CASE OF AN EMERGENCY I WILL NOT BE ABLE TO OPEN MY TRUNK AND HAVE ACCESS TO MY SPARE TIRE, TOOLS, FLARES , ETC. BECAUSE OF THIS MFG. QUALITY DEFECT, I WOULD LIKE TO HAVE TOYOTA PAY FOR THE…
Read full complaint
THE BACK LATCH OF MY 2008 TOYOTA PRIUS HAS DEGRADED AND NO LONGER FUNCTIONS. I AM UNABLE TO OPEN THE BACK HATCH DOOR. I AM CONCERNED THAT IN CASE OF AN EMERGENCY I WILL NOT BE ABLE TO OPEN MY TRUNK AND HAVE ACCESS TO MY SPARE TIRE, TOOLS, FLARES , ETC. BECAUSE OF THIS MFG. QUALITY DEFECT, I WOULD LIKE TO HAVE TOYOTA PAY FOR THE EXPENSE OF THIS REPAIR. MY CAR IS UNSAFE AS IS.
NHTSA ODI #11337974
135,000 miles · Nov 22, 2019
Service BrakesUnknown Or Other
DRIVING THROUGH THE ROCKY MOUNTAINS, MY BRAKE ACTUATOR FAILED CAUSING THE FRONT CALIPER TO SEIZE. I WAS UNABLE TO BRAKE SAFELY. THE VEHICLE SWERVED DURING BRAKING AND FAILED TO RESPOND IN TIME TO PREVENT COLLISIONS. HAD I BEEN IN A HIGH-TRAFFIC AREA, INJURY OR FATALITY WOULD HAVE BEEN LIKELY. THIS IS A KNOWN ISSUE AND TOYOTA EXT…
Read full complaint
DRIVING THROUGH THE ROCKY MOUNTAINS, MY BRAKE ACTUATOR FAILED CAUSING THE FRONT CALIPER TO SEIZE. I WAS UNABLE TO BRAKE SAFELY. THE VEHICLE SWERVED DURING BRAKING AND FAILED TO RESPOND IN TIME TO PREVENT COLLISIONS. HAD I BEEN IN A HIGH-TRAFFIC AREA, INJURY OR FATALITY WOULD HAVE BEEN LIKELY. THIS IS A KNOWN ISSUE AND TOYOTA EXTENDED THE WARRANTY ON THIS PART. UNFORTUNATELY, THOUGH I AM STILL WITHIN THE MILEAGE LIMIT, THE WARRANTY PERIOD EXPIRED WEEKS BEFORE THE PROBLEM WAS DIAGNOSED. I STRESS THAT THIS IS A KNOWN ISSUE WHICH PRESENTS AN IMMINENT DANGER TO DRIVERS, PASSENGERS, AND THE PUBLIC AT LARGE.
NHTSA ODI #11281900
Mileage unknown · Nov 4, 2019
Electrical SystemUnknown Or OtherVisibility/wiper
THE DASHBOARD LIGHTS GO OUT, MEANING YOU CAN NO LONGER SEE THE MPH, THE FUEL, AND EVERYTHING IMPORTANT TO DRIVE WITH GAUGES. THIS CAN HAPPEN AT ANYTIME, DRIVING OR PARKED, ON ANY STREET IN ANY WEATHER. ALSO NOTE, YOU CAN NO LONGER SHUT THE CAR OFF, UNLESS YOU HOLD THE START BUTTON FOR 20 SECONDS. SOMETIMES THE CAR WILL STILL NO…
Read full complaint
THE DASHBOARD LIGHTS GO OUT, MEANING YOU CAN NO LONGER SEE THE MPH, THE FUEL, AND EVERYTHING IMPORTANT TO DRIVE WITH GAUGES. THIS CAN HAPPEN AT ANYTIME, DRIVING OR PARKED, ON ANY STREET IN ANY WEATHER. ALSO NOTE, YOU CAN NO LONGER SHUT THE CAR OFF, UNLESS YOU HOLD THE START BUTTON FOR 20 SECONDS. SOMETIMES THE CAR WILL STILL NOT SHUT OFF, IT'S ALSO SOMETIMES HARD TO TELL IF THE CAR IS OFF, BECAUSE THERE IS NO MORE DASH. THE ONLY WELL TO TELL IS TO SEE IF THE RADIO GOES ON. THERE ARE A FEW WAYS TO RESET THIS MAJOR MALFUNCTION, TO TRY AND GET THINGS WORKING AGAIN BY DISCONNECTING BATTERIES, BUT THIS IS A DANGEROUS PROBLEM, THAT COULD KILL SOMEONE WHILE DRIVING AND NEEDS ATTENTION AND RECALLED SOON AS POSSIBLE!
NHTSA ODI #11277937
175,000 miles · Oct 23, 2019
Electrical SystemExterior LightingUnknown Or Other
MY WIFE AND I OWN 2 PRIUS 2ND GENERATION MODELS SINCE 2014. THE ISSUE IS WITH THE INSTRUMENT CLUSTER RANDOMLY MALFUNCTIONING AND NOT DISPLAYING WHEN THE VEHICLE IS ON AND SOMETIMES NOT BEING ABLE TO TURN THE VEHICLE OFF. IT HAPPENS WHILE DRIVING, STATIONARY, RAINING, JUST RANDOMLY. THIS HAS HAPPENED MORE THAN 10 TIMES ON MY CAR …
Read full complaint
MY WIFE AND I OWN 2 PRIUS 2ND GENERATION MODELS SINCE 2014. THE ISSUE IS WITH THE INSTRUMENT CLUSTER RANDOMLY MALFUNCTIONING AND NOT DISPLAYING WHEN THE VEHICLE IS ON AND SOMETIMES NOT BEING ABLE TO TURN THE VEHICLE OFF. IT HAPPENS WHILE DRIVING, STATIONARY, RAINING, JUST RANDOMLY. THIS HAS HAPPENED MORE THAN 10 TIMES ON MY CAR ALONE, AND MY WIFE CAN CONTESTS TO HERS AS WELL. WHAT WE BOTH ARE EXPERIENCING IS ONE OF MANY SITUATIONS. WHILE DRIVING THE DASH LIGHTS AND INTERIOR LIGHTS WILL JUST NOT WORK: I'M UNABLE TO SEE DRIVING SPEED, IF MY HEADLIGHTS ARE ON. EVEN WHILE STATIONARY WE EXPERIENCE THE SAME THING. THE MAIN REASONS FOR REPORTING THIS IS BECAUSE COINCIDENTALLY IT HAPPENS TO BOTH OF US AT RANDOM TIMES IN 2 DIFFERENT VEHICLES SAME MODEL AND YEAR. FROM MY OWN RESEARCH THIS HAS BEEN GOING ON FOR A WHILE WITH OTHER OWNERS WITH THE SAME MODELS. I DON'T KNOW WHAT CONSTITUTES AS A SAFETY CONCERN FOR RECALLS, BUT I FEEL THIS IS ONE. I'M FORTUNATE TO NOT HAVE ANY ACCIDENTS SO FAR. BUT FOR OTHERS WHO ARE EXPERIENCING THIS CAN ACCIDENTALLY START SPEEDING, OR BECOME STARTLED BECAUSE OF THE SUDDEN LOSS OF DASH VISUALS, AND RESULT IN HARM OF OTHER'S OR PROPERTY. THIS JUST HAPPENED AGAIN TODAY AND I JUST HAD TO SAY SOMETHING SINCE THIS HAS BEEN A PERSISTENT ISSUE FOR MY WIFE AND I. THANKS FOR TAKING THE TIME TO READ THIS AND PLEASE LOOK INTO THIS.
NHTSA ODI #11270351
98,000 miles · Oct 23, 2019
Electrical SystemExterior LightingUnknown Or Other
MY WIFE AND I OWN 2 PRIUS 2ND GENERATION MODELS SINCE 2014. THE ISSUE IS WITH THE INSTRUMENT CLUSTER RANDOMLY MALFUNCTIONING AND NOT DISPLAYING WHEN THE VEHICLE IS ON AND SOMETIMES NOT BEING ABLE TO TURN THE VEHICLE OFF. IT HAPPENS WHILE DRIVING, STATIONARY, RAINING, JUST RANDOMLY. THIS HAS HAPPENED MORE THAN 10 TIMES ON MY CAR …
Read full complaint
MY WIFE AND I OWN 2 PRIUS 2ND GENERATION MODELS SINCE 2014. THE ISSUE IS WITH THE INSTRUMENT CLUSTER RANDOMLY MALFUNCTIONING AND NOT DISPLAYING WHEN THE VEHICLE IS ON AND SOMETIMES NOT BEING ABLE TO TURN THE VEHICLE OFF. IT HAPPENS WHILE DRIVING, STATIONARY, RAINING, JUST RANDOMLY. THIS HAS HAPPENED MORE THAN 10 TIMES ON MY CAR ALONE, AND MY WIFE CAN CONTESTS TO HERS AS WELL. WHAT WE BOTH ARE EXPERIENCING IS ONE OF MANY SITUATIONS. WHILE DRIVING THE DASH LIGHTS AND INTERIOR LIGHTS WILL JUST NOT WORK: I'M UNABLE TO SEE DRIVING SPEED, IF MY HEADLIGHTS ARE ON. EVEN WHILE STATIONARY WE EXPERIENCE THE SAME THING. THE MAIN REASONS FOR REPORTING THIS IS BECAUSE COINCIDENTALLY IT HAPPENS TO BOTH OF US AT RANDOM TIMES IN 2 DIFFERENT VEHICLES SAME MODEL AND YEAR. FROM MY OWN RESEARCH THIS HAS BEEN GOING ON FOR A WHILE WITH OTHER OWNERS WITH THE SAME MODELS. I DON'T KNOW WHAT CONSTITUTES AS A SAFETY CONCERN FOR RECALLS, BUT I FEEL THIS IS ONE. I'M FORTUNATE TO NOT HAVE ANY ACCIDENTS SO FAR. BUT FOR OTHERS WHO ARE EXPERIENCING THIS CAN ACCIDENTALLY START SPEEDING, OR BECOME STARTLED BECAUSE OF THE SUDDEN LOSS OF DASH VISUALS, AND RESULT IN HARM OF OTHER'S OR PROPERTY. THIS JUST HAPPENED AGAIN TODAY AND I JUST HAD TO SAY SOMETHING SINCE THIS HAS BEEN A PERSISTENT ISSUE FOR MY WIFE AND I. THANKS FOR TAKING THE TIME TO READ THIS AND PLEASE LOOK INTO THIS.
NHTSA ODI #11270350
196,050 miles · Oct 3, 2019
Electrical SystemExterior LightingUnknown Or Other
THE 2008 PRIUS HAS A DIGITAL DISPLAY. SOMETIMES WHEN THE VEHICLE STARTS UP THERE IS NO INFORMATION DISPLAYED ON THE SCREEN. NOTHING SHOWS WHAT GEAR (REVERSE, NEUTRAL, FORWARD) IT IS IN. THERE IS NO SPEEDOMETER DISPLAY. NO ODOMETER DISPLAY. NO FUEL LEVEL DISPLAY. AT THE SAME TIME THAT THE DASH DOES NOT LIGHT UP, I HAVE NOTI…
Read full complaint
THE 2008 PRIUS HAS A DIGITAL DISPLAY. SOMETIMES WHEN THE VEHICLE STARTS UP THERE IS NO INFORMATION DISPLAYED ON THE SCREEN. NOTHING SHOWS WHAT GEAR (REVERSE, NEUTRAL, FORWARD) IT IS IN. THERE IS NO SPEEDOMETER DISPLAY. NO ODOMETER DISPLAY. NO FUEL LEVEL DISPLAY. AT THE SAME TIME THAT THE DASH DOES NOT LIGHT UP, I HAVE NOTICED THERE IS NO BACKUP CAMERA OR BACKUP LIGHTS WHEN THE VEHICLE IS IN REVERSE. IN ADDITION TO THE ABOVE, THE START BUTTON WILL NOT FULLY SHUT DOWN THE CAR. IT WILL CYCLE BETWEEN ACCESSORY MODE AND FULL START WHEN THE BUTTON IS PRESSED. I HAVE NOTICED THAT WHEN THE PROBLEM IS HAPPENING THE VEHICLE IS ALSO NOT KEEPING TRACK OF THE MILES DRIVEN WHILE THE DASH IS NOT DISPLAYING - SO WHEN THE DASH DOES START WORKING AGAIN, THE ODOMETER IS NOT SHOWING TRUE MILEAGE. AFTER GETTING THE VEHICLE TO FINALLY SHUT DOWN, I HAVE SOMETIMES HAD THE ISSUE NOT PRESENT THE NEXT DAY AT STARTUP. OTHER TIMES IT WILL LAST THROUGH SEVERAL STARTS AND STOPS. I HAVE READ ONLINE THAT THIS PROBLEM IS CONSISTENT WITH A FAULTY COMBINATION METER. AND I FEEL IT IS A SAFETY ISSUE.
NHTSA ODI #11265944
223,583 miles · Aug 17, 2019
Electrical SystemUnknown Or OtherInjury
VENTILATION CIRCUIT TO SELECT INSIDE TO OUTSIDE AIR HAS BEEN CYBER-TERRORISED SEVERAL TIMES. THE SYSTEM IS VITAL TO OPERATE SECURELY, AS A DISABLED CONSTITUENT, IN A GREAT METROPOLIS, THAT HAS SEWAGE AND GARBAGE VAPORS EVERYWHERE. THEY ACCESS THE FUNTION TO OPEN THE DAMPER TO LET OUTSIDE AIR IN SUDDENLY, EXPOSING MY RESPIRATORY …
Read full complaint
VENTILATION CIRCUIT TO SELECT INSIDE TO OUTSIDE AIR HAS BEEN CYBER-TERRORISED SEVERAL TIMES. THE SYSTEM IS VITAL TO OPERATE SECURELY, AS A DISABLED CONSTITUENT, IN A GREAT METROPOLIS, THAT HAS SEWAGE AND GARBAGE VAPORS EVERYWHERE. THEY ACCESS THE FUNTION TO OPEN THE DAMPER TO LET OUTSIDE AIR IN SUDDENLY, EXPOSING MY RESPIRATORY SYSTEM TO INHALE WASTE. I HAVE RESPIIRATED. GARBAGE AIR POLLUTION, HERE IN NEW YORK SO MUCH, IT HAS ACTIVATED MY CHILDHOOD ASTHMA. PLEASE FIND A WAY TO SEAL THE ECU'S.
NHTSA ODI #11244710
215,608 miles · May 15, 2019
Electrical SystemUnknown Or Other
THE INSIDE TO OUTSIDE AIR VENT ACTUATORS ARE MOVING IN DIFFERENT DIRECTIONS, VENTING INTAKE MANIFOLD GASES INTO THE CABIN. SYNTHETIC OIL SMELL IN THE CABIN, VIA THE TWO FRONT VENTS.
NHTSA ODI #11207885
97,000 miles · Mar 26, 2019
Unknown Or Other
THE TRUNK LATCH ON THIS MODEL IS FAULTY AND DANGEROUS. THE MATERIAL USED FOR THE LATCH IS TOO SUSCEPTIBLE TO TEMPERATURE AND EITHER BECOME ROCK HARD IN THE WINTER COLD OR MELTY AND GOOEY IN THE SUMMER HEAT. IT IS ALMOST IMPOSSIBLE TO GET INTO MY TRUNK THROUGH THE BACK LATCH IN THE WINTERTIME. I TRY AND MAYBE IF THE WEATHER IS…
Read full complaint
THE TRUNK LATCH ON THIS MODEL IS FAULTY AND DANGEROUS. THE MATERIAL USED FOR THE LATCH IS TOO SUSCEPTIBLE TO TEMPERATURE AND EITHER BECOME ROCK HARD IN THE WINTER COLD OR MELTY AND GOOEY IN THE SUMMER HEAT. IT IS ALMOST IMPOSSIBLE TO GET INTO MY TRUNK THROUGH THE BACK LATCH IN THE WINTERTIME. I TRY AND MAYBE IF THE WEATHER IS WARM ENOUGH AND IT'S JUST RIGHT, I CAN GET INTO MY TRUNK ABOUT 10 PERCENT OF THE TIME, IF THAT. RECENTLY, I TRIED TO OPEN MY TRUNK UNSUCCESSFULLY. IT OPENED ENOUGH TO NOT BE SECURELY SHUT, BUT NOT ENOUGH TO POP OPEN. I WAS THEN ALSO UNABLE TO SHUT THE TRUNK. WHAT ENDED UP TRANSPIRING WAS A TRUNK THAT WOULD REGISTER AS OPENING AND SHUTTING, WITHOUT THE ACTUAL ABILITY TO FULLY OPEN IT OR SHUT IT. SO THE CAR DOOR LIGHT MUST HAVE COME ON AT SOME POINT AND DRAINED MY BATTERY WHICH THEN LEFT ME STRANDED ON A WINTER DAY IN A COLD PARKING LOT AWAY FROM HOME. ALL BECAUSE TOYOTA EFFED UP AND USED A VERY POOR CHOICE IN MATERIALS FOR THEIR TRUNK LATCHES. THIS IS SOMETHING THAT THEY SHOULD CORRECT SO OTHER PEOPLE DON'T HAVE TRUNK ISSUES THAT END UP CAUSING PROBLEMS. IF SOMEONE NEEDS TO OPEN THEIR TRUNK IN THE WINTER TIME TO RETRIEVE MEDICINE, LIKE AN EPI-PEN, THEN THEY ARE SCREWED. IF SOMEONE NEEDS TO OPEN THE LATCH TO HELP REMOVE AN ANIMAL OR CHILD OUT OF A CAR FOR WHATEVER REASON, THEY ARE SCREWED. IF THEY JUST SIMPLY WANT TO HAVE TRUNK FUNCTIONALITY FOR HAULING GROCERIES, THEY ARE SCREWED. AND IF THEY ARE LIKE ME AND MANAGE TO UNFORTUNATELY FIND THAT SWEET SPOT WHERE THE TRUNK ONLY PARTIALLY OPENS, BUT NOT FULLY, AND THEIR BATTERY ENDS UP BECOMING DRAINED AND THEY ARE STRANDED IN THE MIDDLE OF NOWHERE, THEY ARE ALSO SCREWED. TOYOTA MADE A MISTAKE, AND THEY SHOULD DO SOMETHING TO FIX IT. I LOVE MY PRIUS, BUT THIS ONE TRUNK LATCH ISSUE IS ENOUGH TO MAKE ME RECONSIDER OTHER CARS WITH FUNCTIONAL DOOR LATCHES.
NHTSA ODI #11191764
105,000 miles · Oct 16, 2018
Unknown Or Other
I CALLED TOYOTA ABOUT THE STALLING SOFTWARE RECALL AND MY CAR IS NOT ON THE LIST AND NEEDS TO BE ADDED TO IT. MY CAR DOES THE SAME THING AS THE OTHERS REPORTED. WHEN I HIT A BUMP ON ANY STREET OR FREEWAY THE ENGINE FLUTTERS AND THE SLIPPERY WHEN WET LIGHT COMES ON AND IT HARD EXCELLORATES FORWARD EVEN WHEN MY FOOT IS ON THE BRAK…
Read full complaint
I CALLED TOYOTA ABOUT THE STALLING SOFTWARE RECALL AND MY CAR IS NOT ON THE LIST AND NEEDS TO BE ADDED TO IT. MY CAR DOES THE SAME THING AS THE OTHERS REPORTED. WHEN I HIT A BUMP ON ANY STREET OR FREEWAY THE ENGINE FLUTTERS AND THE SLIPPERY WHEN WET LIGHT COMES ON AND IT HARD EXCELLORATES FORWARD EVEN WHEN MY FOOT IS ON THE BRAKE AND THERE'S REALLY NO STOPPING IT.
NHTSA ODI #11140742
Official recalls
4Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Illustration