IllustrationREAR HATCH SWITCH MELTED AND HAD TO BE REPLACED FOR $290.62. THIS IS A TOYOTA PROBLEM WHICH THEY REFUSE TO ACKNOWLEDGE. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Structure complaints
68 reportsBLACK HANDLE ON HATCH MELTING. AFTER ONLY ABOUT 5 YEARS USE, THE RUBBER COVER ON THE HATCH RELEASE HANDLE (THE EXTERIOR HANDLE OF THE REAR HATCH) OF MY 2008 TOYOTA PRIUS, MELTED INTO A STICKY TARRY BLACK RUBBERY GOOEY MESS. I CAN BEST DESCRIBE IT AS BEING A VISCOUS BLACK GLOB LIKE ROOFING TAR. TO OPEN THE HATCH, YOU HAVE TO TOU…
Read full complaint
BLACK HANDLE ON HATCH MELTING. AFTER ONLY ABOUT 5 YEARS USE, THE RUBBER COVER ON THE HATCH RELEASE HANDLE (THE EXTERIOR HANDLE OF THE REAR HATCH) OF MY 2008 TOYOTA PRIUS, MELTED INTO A STICKY TARRY BLACK RUBBERY GOOEY MESS. I CAN BEST DESCRIBE IT AS BEING A VISCOUS BLACK GLOB LIKE ROOFING TAR. TO OPEN THE HATCH, YOU HAVE TO TOUCH THIS BLACK GOO EACH TIME, WHICH MAKES IT DIFFICULT TO OPERATE THE HATCH RELEASE. I WENT TO TOYOTA ARDMORE, PA TO COMPLAIN ABOUT IT BUT DID NOT GET ANY ANSWERS AND CHOOSE TO IGNORE IT. I AM ASKING FOR YOUR AGENCY TO TAKE A LOOK AT THESE INSTANCES AND ALSO TO ASK TOYOTA WHY THEY ARE NOT RECALLING THESE HANDLES. THANKS FOR YOUR HELP.
THE REAR HATCH LATCH RUBBER COVER HAS MELTED, MAKING IT DIFFICULT TO OPEN THE DOOR.
LIFT GATE LATCH RUBBER COVER IS MELTED. *TR
REAR LIFTGATE RUBBER GUARD HAS BECOME MELTED AND GOOEY CAUSING INTERMITTENT BACK LIFTGATE DOOR LOOK ISSUES. I NEED TO REPLACE JUST THE RUBBER PIECE. *TR
WHEN I TRY TO OPEN THE TRUNK, THE RUBBER PIECE THAT YOU TOUCH IN ORDER TO OPEN THE TRUNK SEEM TO HAVE MELTED. MY FINGERS TURN BLACK EVERY TIME I TRY TO OPEN THE TRUNK. DOES ANYONE KNOW WHAT THAT RUBBER PIECE IS CALLED OR THE PART NUMBER SO THAT I CAN REPLACE IT? IT MAKES THE REAR HATCH VERY HARD TO OPEN IN HOT AND COLD WEATHER…
Read full complaint
WHEN I TRY TO OPEN THE TRUNK, THE RUBBER PIECE THAT YOU TOUCH IN ORDER TO OPEN THE TRUNK SEEM TO HAVE MELTED. MY FINGERS TURN BLACK EVERY TIME I TRY TO OPEN THE TRUNK. DOES ANYONE KNOW WHAT THAT RUBBER PIECE IS CALLED OR THE PART NUMBER SO THAT I CAN REPLACE IT? IT MAKES THE REAR HATCH VERY HARD TO OPEN IN HOT AND COLD WEATHER. *TR
REAR HATCH RELEASE COVER MELTS OFF SWITCH. MY PRIUS REAR HATCH RELEASE RUBBER COVER BECAME STICKY A YEAR OR SO AGO. THEN STARTED MELTING OFF THE SWITCH THIS YEAR. I LEFT THE CAR SIT FOR A WEEK IN HIGH 90 TEMPS AND THE RUBBER COVER WAS NEARLY MELTED TO MY LICENSE PLATE. IT WAS NO LONGER ATTACHED TO THE ELECTRIC SWITCH. I RESEARCH…
Read full complaint
REAR HATCH RELEASE COVER MELTS OFF SWITCH. MY PRIUS REAR HATCH RELEASE RUBBER COVER BECAME STICKY A YEAR OR SO AGO. THEN STARTED MELTING OFF THE SWITCH THIS YEAR. I LEFT THE CAR SIT FOR A WEEK IN HIGH 90 TEMPS AND THE RUBBER COVER WAS NEARLY MELTED TO MY LICENSE PLATE. IT WAS NO LONGER ATTACHED TO THE ELECTRIC SWITCH. I RESEARCHED ON LINE AND FOUND SEVERAL PEOPLE COMPLAINING ABOUT THIS ISSUE. TOYOTA WANTS $200 PLUS FOR THE SWITCH. THIS SHOULD NOT BREAKDOWN LIKE THIS. WOULD LIKE TO HAVE TOYOTA FIX THE PROBLEM SINCE IT HAS A HARD TIME KEEPING THIS PART IN STOCK. THAT SHOWS IT'S A PROBLEM. *TR
I LIVE IN TEXAS WHERE THE WEATHER GETS HOT DURING THE SUMMER. I NOTICED LAST YEAR THAT THE RUBBER TRUNK LATCH ON MY TOYOTA PRIUS WAS NOTICEABLY DIFFERENT IN TEXTURE AFTER I HAD TRIED TO USE IT AFTER IT HAD BEEN PARKED IN THE SUN. IT DIDN'T CAUSE MUCH OF A PROBLEM THEN, BUT NOW IT HAS MELTED SO MUCH THAT IT DROOPS DOWN OVER AN IN…
Read full complaint
I LIVE IN TEXAS WHERE THE WEATHER GETS HOT DURING THE SUMMER. I NOTICED LAST YEAR THAT THE RUBBER TRUNK LATCH ON MY TOYOTA PRIUS WAS NOTICEABLY DIFFERENT IN TEXTURE AFTER I HAD TRIED TO USE IT AFTER IT HAD BEEN PARKED IN THE SUN. IT DIDN'T CAUSE MUCH OF A PROBLEM THEN, BUT NOW IT HAS MELTED SO MUCH THAT IT DROOPS DOWN OVER AN INCH AND IS ABOUT TO FALL OFF FROM THE SIDES. THE HANDLE HAS TURNED INTO A TAR LIKE SUBSTANCE, AND WILL NOT REATTACHED TO THE ORIGINAL PART. I SPOKE WITH MY DEALERSHIP, AND THEY HAVE TOLD ME THAT THIS IS A CONSISTENT PROBLEM, BUT WILL NOT REPLACE IT FOR UNDER $400. I NORMALLY PARK MY VEHICLE IN A GARAGE, SO THIS IS OBVIOUSLY A MANUFACTURER DEFECT THAT THEY WANT ME TO PAY FOR TO REPLACE. THIS CONCERNS ME AS I WILL NOT BE ABLE TO USE MY TRUNK WITH THE RUBBER PIECE GONE, SINCE IT PROTECTS IT FROM THE WATER, DUST AND DEBRIS. THE ELECTRICAL CONNECTIONS ALSO ALLOW ME TO USE THE TRUNK, LOCK AND UNLOCK THE CAR, AND IS PART OF THE ENTIRE ENGINE AND BRAKING SYSTEM. WITH THE KNOWN PROBLEMS THAT ALREADY ARE ASSOCIATED WITH THE PRIUS, I AM SCARED TO DRIVE THE CAR WITH POTENTIAL ISSUES THAT COULD ARISE FROM THE ELECTRICAL ISSUES AND LOSING ACCESS TO THE SAFETY EQUIPMENT (EMERGENCY SUPPLIES, SPARE TIRE, JACK) THAT ARE ALL LOCATED IN THE TRUNK. IF THERE WAS EVER A NEED TO EXIT FROM THE TRUNK, IT WOULD NOT BE POSSIBLE ONCE THE LATCH HAS BEEN COMPROMISED. PLEASE LOOK INTO THIS ISSUE AS IT HAS OCCURRED TO COUNTLESS PEOPLE WHO ALL OWN 07-08 PRIUSES, AS WE WOULD ALL LIKE TO BE ABLE TO USE OUR TRUNK HANDLES WITHOUT BEING COVERED IN BLACK GOO. *TR
THE HATCHBACK RELEASE IS MELTING. IT IS ALL GOOEY WHEN YOU OPEN THE DOOR. ONE OF MY CONCERNS IS WHAT TYPE OF CHEMICAL IS GETTING ON MY HANDS? IS IT TOXIC? THE SECOND IS SAFETY. I HAVE READ OVER TIME YOU WILL NOT BE ABLE TO OPEN THE HATCHBACK. THIS WOULD NOT BE APPROPRIATE IF YOU HAD A FLAT TIRE. I CONTACTED TOYOTA AND THEY SAID …
Read full complaint
THE HATCHBACK RELEASE IS MELTING. IT IS ALL GOOEY WHEN YOU OPEN THE DOOR. ONE OF MY CONCERNS IS WHAT TYPE OF CHEMICAL IS GETTING ON MY HANDS? IS IT TOXIC? THE SECOND IS SAFETY. I HAVE READ OVER TIME YOU WILL NOT BE ABLE TO OPEN THE HATCHBACK. THIS WOULD NOT BE APPROPRIATE IF YOU HAD A FLAT TIRE. I CONTACTED TOYOTA AND THEY SAID THEY HAVE NO RECORD OF THIS PROBLEM,BUT AFTER RESEARCHING THE INTERNET I SEE A SIGNIFICANT AMOUNT OF COMPLAINTS. I ALSO SEE A LOT OF COMPLAINTS ABOUT THIS PROBLEM ON THIS SITE. PLEASE HAVE A RECALL FOR A DEFECTIVE PART. I WAS TOLD BY THE DEALER THAT IT WOULD COST 210.00 PLUS TAX FOR A REPLACEMENT. *TR
MELT DOWN OF HATCHBACK RELEASE HANDLE. VERY HARD TO OPEN HATCHBACK. *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606