IllustrationWHEN I AM SLOWING DOWN AND APPLYING THE BRAKE ON MY TOYOTA PRIUS AND THERE IS A BUMP OR DEFECT IN THE ROAD I GET A FEELING OF BEING ON ICE. A FEELING OF A LACK OF CONTROL. I WAS ALWAYS AWARE OF THIS BUT I NEVER MENTIONED IT WHEN HAVING MY VEHICLE SERVICED. *CN
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Service Brakes, Electric complaints
77 reportsMY 2008 PRIUS EXPERIENCES THE BRAKING PROBLEM BEING INVESTIGATED WITH THE 2010 PRIUS. *CN
THE ISSUE THAT HAS BEEN REPORTED ON TOYOTA PRIUS BRAKES FAILING TO WORK ON BUMPY ROADS EXTENDS BEYOND THE 2010 MODEL YEAR. I OWN A 2008 PRIUS AND KNOW ANOTHER PERSON AS WELL WHO HAVE EXPERIENCED THE EXACT SAME PROBLEM WITH OUR CARS WHEN BRAKING ON BUMPY ROADS. THE TOYOTA COMPLAINT LINE DOES NOT ANSWER ANYMORE DUE TO THE VOLUME…
Read full complaint
THE ISSUE THAT HAS BEEN REPORTED ON TOYOTA PRIUS BRAKES FAILING TO WORK ON BUMPY ROADS EXTENDS BEYOND THE 2010 MODEL YEAR. I OWN A 2008 PRIUS AND KNOW ANOTHER PERSON AS WELL WHO HAVE EXPERIENCED THE EXACT SAME PROBLEM WITH OUR CARS WHEN BRAKING ON BUMPY ROADS. THE TOYOTA COMPLAINT LINE DOES NOT ANSWER ANYMORE DUE TO THE VOLUME OF CALLS (SAYS THE MESSAGE), SO I AM REPORTING IT HERE.
I PURCHASED 2008 TOYOTA PRIUS FROM ANAPOLIS TOYOTA. THE BRAKES FAILED ON THREE OCCASIONS SINCE PURCHASING CAR ON JANUARY 18, 2010. CAR WAS TAKEN IN DURING THE FIRST 7 DAYS AFTER PURCHASING IT. SERVICE DEPARTMDNT AND USED CAR SALES MANAGEMENT CLAIMED NOTHING WAS WRONG. PROBLEM OCCURS WHEN I HIT A BUMP IN THE ROAD. BRAKES COM…
Read full complaint
I PURCHASED 2008 TOYOTA PRIUS FROM ANAPOLIS TOYOTA. THE BRAKES FAILED ON THREE OCCASIONS SINCE PURCHASING CAR ON JANUARY 18, 2010. CAR WAS TAKEN IN DURING THE FIRST 7 DAYS AFTER PURCHASING IT. SERVICE DEPARTMDNT AND USED CAR SALES MANAGEMENT CLAIMED NOTHING WAS WRONG. PROBLEM OCCURS WHEN I HIT A BUMP IN THE ROAD. BRAKES COMPETELY FAIL. VERY DANGEROUS. IT IS NOT JUST THE 2010 MODEL THAT SHOULD BE QUESTIONED. ALL PRIUS' SHOULD BE RECALLED UNTIL THIS IS SOLVED.
2008 TOYTOA PRIUS BRAKES DISENGAGING WHEN GOING OVER BUMPS, POTHOLES, RAILWAY TRACKS. NO INJURIES YET BUT SOME CLOSE CALLS.
1) THE EVEN HAPPENS DURING NORMAL BRAKING FROM 40 MPH OVER A ROAD WITH POTHOLES. THE LOCATION IS HERE: HTTP://MAPS.GOOGLE.COM/?IE=UTF8&HQ=&HNEAR=CLEVELAND,+CASS,+MISSOURI&LL=38.67887,-94.675729&SPN=0.00139,0.00284&Z=19 2) THE CAR LOSES ALL BRAKING FOR 1-2 SECONDS AFTER RUNNING OVER THE POTHOLE. IF SOMEBODY WAS IN FRONT OF M…
Read full complaint
1) THE EVEN HAPPENS DURING NORMAL BRAKING FROM 40 MPH OVER A ROAD WITH POTHOLES. THE LOCATION IS HERE: HTTP://MAPS.GOOGLE.COM/?IE=UTF8&HQ=&HNEAR=CLEVELAND,+CASS,+MISSOURI&LL=38.67887,-94.675729&SPN=0.00139,0.00284&Z=19 2) THE CAR LOSES ALL BRAKING FOR 1-2 SECONDS AFTER RUNNING OVER THE POTHOLE. IF SOMEBODY WAS IN FRONT OF ME, IT WOULD RESULT IN A ACCIDENT. IT HAPPENS 5 DAYS A WEEK AS PART OF MY DAILY COMMUTE. 3) TOYOTA SAYS IT IS NORMAL FOR THE PRIUS TO DO THIS.
TOYOTA PRIUS 2008: WHEN DRIVING AT SLOW SPEED AND BRAKING, IF I HIT A SMALL BUMP (LIKE MANHOLE COVER), MY VEHICLE SKID WARNING LIGHT COMES ON AND IT FEELS LIKE THE CAR TEMPORARILY STOPS BRAKING FOR ABOUT A SECOND AND THEN BRAKE RE-ENGAGES. THIS HAS HAPPENED OFF AND ON FOR OVER A YEAR. I REPORTED IT TO THE DEALER WHEN I FIRST …
Read full complaint
TOYOTA PRIUS 2008: WHEN DRIVING AT SLOW SPEED AND BRAKING, IF I HIT A SMALL BUMP (LIKE MANHOLE COVER), MY VEHICLE SKID WARNING LIGHT COMES ON AND IT FEELS LIKE THE CAR TEMPORARILY STOPS BRAKING FOR ABOUT A SECOND AND THEN BRAKE RE-ENGAGES. THIS HAS HAPPENED OFF AND ON FOR OVER A YEAR. I REPORTED IT TO THE DEALER WHEN I FIRST EXPERIENCED IT AND THEY CHECKED COMPUTER AND COULD FIND NO EVIDENCE OF A PROBLEM.
2005 AND 2009 TOYOTA PRIUS BRAKING PROBLEMS. I HAVE A 2005 AND A 2009 TOYOTA PRIUS. ON BOTH OF THESE VEHICLES, I HAVE EXPERIENCED THE SAME PROBLEMS WHICH ARE BEING DESCRIBED IN THE NEWS ABOUT THE 2010 PRIUS MODEL. I HAVE NEVER HAD AN ACCIDENT RELATING TO THIS PROBLEM, BUT THE POTENTIAL IS CERTAINLY THERE. THE PROBLEM OCCURS …
Read full complaint
2005 AND 2009 TOYOTA PRIUS BRAKING PROBLEMS. I HAVE A 2005 AND A 2009 TOYOTA PRIUS. ON BOTH OF THESE VEHICLES, I HAVE EXPERIENCED THE SAME PROBLEMS WHICH ARE BEING DESCRIBED IN THE NEWS ABOUT THE 2010 PRIUS MODEL. I HAVE NEVER HAD AN ACCIDENT RELATING TO THIS PROBLEM, BUT THE POTENTIAL IS CERTAINLY THERE. THE PROBLEM OCCURS WHEN I AM MOVING FORWARD, HAVE THE BRAKE SLIGHTLY DEPRESSED, AND I HIT A POT HOLE OR SPEED BUMP. THE WHEELS MOMENTARILY SPEED UP, SO I REACT BY PRESSING HARDER ON THE BRAKES AND THE WHEELS SLOW DOWN. *TW
MY CAR IS A 2008 PRIUS. THE INCIDENT IS THAT MY CAR DIDN'T STOP AND SKIDDED INTO A CONCRETE CURB, DAMAGING THE RIGHT FRONT POWER STEERING RACK. IT WAS SNOWING, ABOUT 1-2" ACCUMULATED. DRIVING INTO MY OFFICE PARKING LOT, THERE IS A STREET WITH A STEEP BUT SHORT HILL - MAYBE 50FEET OR LESS - (IT WAS NOT PLOWED OR SANDED). AT THE…
Read full complaint
MY CAR IS A 2008 PRIUS. THE INCIDENT IS THAT MY CAR DIDN'T STOP AND SKIDDED INTO A CONCRETE CURB, DAMAGING THE RIGHT FRONT POWER STEERING RACK. IT WAS SNOWING, ABOUT 1-2" ACCUMULATED. DRIVING INTO MY OFFICE PARKING LOT, THERE IS A STREET WITH A STEEP BUT SHORT HILL - MAYBE 50FEET OR LESS - (IT WAS NOT PLOWED OR SANDED). AT THE FOOT OF THE HILL, THERE IS A LEFT TURN INTO A LEVEL PARKING LOT OR A RIGHT TURN UNDER A HIGHWAY OVERPASS, OR STRAIGHT AHEAD INTO SHRUBS AND THE RIVER. I SLOWED DOWN BEFORE GOING DOWN THE HILL AND AS I WENT DOWN THE HILL I LIGHTLY PUMPED BRAKES. TRIED TO COME TO A COMPLETE STOP AT FOOT OF THE HILL BUT CAR DIDN'T STOP COMPLETELY, BUT WAS GOING SLOW. SO, I MADE THE LEFT TURN INTO THE PARKING LOT. THE BODY OF THE CAR TURNED INTO THE LOT, BUT WAS NOT IN CONTROL. WITH THE BRAKES ON, AND THE WHEEL TURNED TO THE LEFT, THE CAR WENT INTO A SLIDE SIDEWAYS TO THE RIGHT. THE RIGHT FRONT WHEEL SLAMMED INTO A CONCRETE CURB AND THE CAR STOPPED. IT FELT AS IF I HAD NO BRAKES - COMING DOWN THE HILL THEY COULDN'T STOP ME AND THERE WAS NO SKID CONTROL COMING ON AT ANY TIME. THE FAILURE: GIVEN THE WEATHER CONDITIONS I DON'T KNOW HOW TO PROVE A FAILURE BUT I SUSPECT SOMETHING WITH THE BRAKES. I HAVE OWNED THIS CAR FOR ONE YEAR (PURCHASED IT USED) AND DURING THAT TIME THE ONE THING THAT BUGS ME IN THE CAR IS THE BRAKES AND THE SKID CONTROL. THEY JUST FEEL STRANGE, I GO OVER A DEPRESSED MANHOLE IN THE ROAD AND THE DSC COMES ON AND IT FEELS LIKE I SKID - IT SHOULD JUST FEEL LIKE A BUMP. REPAIRS: THIS IS THE LIST -ENTIRE POWER STEERING RACK ON RIGHT FRONT TO BE REPLACED- TIE ROD, LOWER CONTROL ARM, WHEEL, RIM-ALL BENT. FRONT COVER AND LOWER BALL JOINT DAMAGED-TO BE REPLACED. OVER $3000 IN REPAIRS; THEY WILL BE DONE THIS WEEK (8 FEB). IF YOU WANT THE OLD PARTS I CAN ASK FOR DEALER TO SAVE THEM. CAR IS @ TOYOTA DEALER. MILEAGE & SPEED ARE MY BEST GUESS; COMPONENTS I GUESSED - YOUR TERMS WERE NOT FAMILIAR TO ME. *TW
I OWN A 2008 TOYOTA PRIUS. I'VE NOTICED THAT WHEN I RUN OVER A BUMP OR A POTHOLE ON THE ROAD, THE CAR SEEMS TO ACCELERATE OR JOLT FORWARD. IT HAPPENS WHILE I BRAKE TO A STOP SIGN AND RUN OVER A BUMP OR POTHOLE. IT HAS ALSO HAPPENED WHILE LETTING GO OF THE GAS PEDAL BUT NOT STEPPING ON THE BRAKE. USUALLY WHEN THIS OCCURS THE LIGH…
Read full complaint
I OWN A 2008 TOYOTA PRIUS. I'VE NOTICED THAT WHEN I RUN OVER A BUMP OR A POTHOLE ON THE ROAD, THE CAR SEEMS TO ACCELERATE OR JOLT FORWARD. IT HAPPENS WHILE I BRAKE TO A STOP SIGN AND RUN OVER A BUMP OR POTHOLE. IT HAS ALSO HAPPENED WHILE LETTING GO OF THE GAS PEDAL BUT NOT STEPPING ON THE BRAKE. USUALLY WHEN THIS OCCURS THE LIGHT FOR THE TRACTION CONTROL ENGAGES AS IF IT DETECTS A SKID, EVEN THOUGH THERE IS NO SKID. I HAVE TO PRESS THE BRAKE VERY HARD IN ORDER TO STOP OR SLOW DOWN THE CAR. I TEND TO LEAVE EXTRA ROOM IN FRONT OF ME JUST IN CASE THE CAR ACCELERATES UNEXPECTEDLY, BUT THERE IS DEFINITELY A PROBLEM WITH UNEXPLAINED ACCELERATION. *CN
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606