IllustrationBOTH HEADLIGHT BULBS WILL GO OUT WHEN THE VEHICLE IS HOT. IT CAN BE ONE AT A TIME OR SIMULTANEOUSLY. ADDITIONALLY BOTH TAIL LIGHT BULBS STOPPED WORKING APPROXIMATELY 1 WEEK PRIOR. WHEN THE REAR BULBS WERE REPLACED THE HEADLIGHT PROBLEM SEEMED TO WORSEN. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Exterior Lighting complaints
579 reports2008 TOYOTA PRIUS HEADLIGHT FAILURE--HEADLIGHTS WILL GO OUT AT ANYTIME. DRIVER SWITCHES LIGHTS OFF THEN BACK ON TO REGAIN HEADLIGHT. DEALER SAID IT IS A FAILURE OF THE HIGH DENSITY LAMP ASSEMBLY. ENTIRE ASSEMBLY REPLACEMENT IS THE ONLY REPAIR. COST OF ASSEMBLY IS 250 DOLLARS AND 50 DOLLARS TO REMOVE & INSTALL. *TR
2008 TOYOTA PRIUS - HID HEADLIGHTS. LIGHTS TURN OFF INDEPENDENTLY AND INTERMITTENTLY. SOMETIMES ONE, SOMETIMES BOTH. RESTARTING VEHICLE WILL RESOLVE PROBLEM TEMPORARILY, BUT THEY USUALLY FAIL AGAIN. I CONTACTED TOYOTA EXPERIENCE HOTLINE. A CASE MANAGER STATED THAT THIS IS NORMAL BEHAVIOR FOR THESE HEADLIGHTS WHEN THEY ARE …
Read full complaint
2008 TOYOTA PRIUS - HID HEADLIGHTS. LIGHTS TURN OFF INDEPENDENTLY AND INTERMITTENTLY. SOMETIMES ONE, SOMETIMES BOTH. RESTARTING VEHICLE WILL RESOLVE PROBLEM TEMPORARILY, BUT THEY USUALLY FAIL AGAIN. I CONTACTED TOYOTA EXPERIENCE HOTLINE. A CASE MANAGER STATED THAT THIS IS NORMAL BEHAVIOR FOR THESE HEADLIGHTS WHEN THEY ARE STARTING TO NEED REPLACEMENT. THIS VEHICLE HAD 38000 MILES WHEN PROBLEM STARTED. IF THE BEHAVIOR WERE NORMAL, WOULDN'T IT BE IN THE OWNERS MANUAL? A NORMAL BEHAVIOR WOULDN'T CREATE SUCH A SAFETY HAZARD WITHOUT SOME KIND OF WARNING LIGHT. FOR INSTANCE, WHEN MY TIRE PRESSURE IS LOW, A WARNING LIGHT COMES ON. WE WERE ONLY TOLD TO BRING IT TO THE DEALER FOR INSPECTION. *TR
THE RIGHT HID HEADLAMP ON MY 2008 TOYOTA PRIUS HAS FAILED. THE HEADLAMP NOW GOES ON AND OFF INTERMITTENTLY. I LOOKED INTO REPLACING THE BULB, BUT UPON BEING TOLD THE COST WOULD BE UP TO SEVERAL HUNDRED DOLLARS AND NOT COVERED UNDER WARRANTY, I DECIDED TO FIND A BULB AND REPLACE ON MY OWN. *TR
TL*THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STATED THAT AS HE WAS DRIVING 40 MPH HIS HEADLIGHTS SHUT OFF AND HE COULD NOT SEE WHICH RESULTED IN HIM HITTING A DOG. THE MANUFACTURER WAS NOTIFIED AND A REPRESENTATIVE STATED THAT SOMEONE WOULD RETURN HIS CALL. THE VEHICLE HAS NOT BEE DIAGNOSED BY THE DEALER. THE FAILURE MIL…
Read full complaint
TL*THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STATED THAT AS HE WAS DRIVING 40 MPH HIS HEADLIGHTS SHUT OFF AND HE COULD NOT SEE WHICH RESULTED IN HIM HITTING A DOG. THE MANUFACTURER WAS NOTIFIED AND A REPRESENTATIVE STATED THAT SOMEONE WOULD RETURN HIS CALL. THE VEHICLE HAS NOT BEE DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS 60,160.
HEADLIGHTS ON CAR GO OFF WHILE DRIVING. I HAVE TO KEEP TURNING THE SWITCH OFF AND ON TO GET THEM BACK ON. THIS IS HAPPENING MORE AND MORE. I WILL BE DRIVING ON A DARK ROAD WITH NO STREETLAMPS AND MY HEADLIGHTS WILL GO COMPLETELY OUT. ALL OF A SUDDEN I FIND THAT I'M DRIVING BLIND. . I HAVE FOUND THAT OTHER PRIUS CARS ARE HAV…
Read full complaint
HEADLIGHTS ON CAR GO OFF WHILE DRIVING. I HAVE TO KEEP TURNING THE SWITCH OFF AND ON TO GET THEM BACK ON. THIS IS HAPPENING MORE AND MORE. I WILL BE DRIVING ON A DARK ROAD WITH NO STREETLAMPS AND MY HEADLIGHTS WILL GO COMPLETELY OUT. ALL OF A SUDDEN I FIND THAT I'M DRIVING BLIND. . I HAVE FOUND THAT OTHER PRIUS CARS ARE HAVING THIS SAME PROBLEM. I HAVE A 2008 PRIUS WITH 41,000 MILES ON IT. IT'S SCARY AND VERY DANGEROUS: HTTP://WWW.HYBRIDCARS.COM/FORUMS/REPLACING-HEADLIGHT-BULB-T910.HTML#COMM... *TR
HID HEAD LIGHT GOES OFF WHILE DRIVING IN TOYOTA PRIUS 08. *TR
MY 2008 PRIUS FREQUENTLY HAD FAILURE OF ONE AND BOTH HEADLAMPS AT THE SAME TIME. I WAS UNABLE TO BRING THEM BACK ON BY TURNING THEM ON AND OFF. THEY WOULD RESET AFTER VEHICLE SAT FOR A TIME. *TR
2008 TOYOTA PRIUS PKG 6...LOST POWER AT 65MPH...ENGINE SHUT DOWN AND I LOST CONTROL OF CAR...PULLED OVER...LIGHTS SAID THERE WAS NO FUEL BUT I HAD REFUELED EARLIER THAT MORNING. TOOK TO DEALER...COULD NOT FIND A PROBLEM. ALSO, HID HEADLIGHTS INTERMITTENTLY DON'T WORK...VERY UNSAFE...HAS CAUSED TROUBLE WITH POLICE...I AM BEYO…
Read full complaint
2008 TOYOTA PRIUS PKG 6...LOST POWER AT 65MPH...ENGINE SHUT DOWN AND I LOST CONTROL OF CAR...PULLED OVER...LIGHTS SAID THERE WAS NO FUEL BUT I HAD REFUELED EARLIER THAT MORNING. TOOK TO DEALER...COULD NOT FIND A PROBLEM. ALSO, HID HEADLIGHTS INTERMITTENTLY DON'T WORK...VERY UNSAFE...HAS CAUSED TROUBLE WITH POLICE...I AM BEYOND IRRITATED WITH TOYOTA. *TR
WE HAVE 2008 PRIUS THAT FIRST BEGAN HAVING LEFT HEADLAMP GO OUT WHEN DRIVING, WE WOULD HAVE TO PULL OVER SAFE PLACE ALONG ROAD TURN MESS WITH TURNING HEADLIGHTS ON AND OFF... CREATED UNSAFE DRIVING REMAINDER OF TRIP, APROX 200 MILES NIGHT DRIVE TO GET HOME WITH ONE HEADLIGHT... NOT GOOD ON MONTANA ROADS WITH WILDLIFE PREVALENT O…
Read full complaint
WE HAVE 2008 PRIUS THAT FIRST BEGAN HAVING LEFT HEADLAMP GO OUT WHEN DRIVING, WE WOULD HAVE TO PULL OVER SAFE PLACE ALONG ROAD TURN MESS WITH TURNING HEADLIGHTS ON AND OFF... CREATED UNSAFE DRIVING REMAINDER OF TRIP, APROX 200 MILES NIGHT DRIVE TO GET HOME WITH ONE HEADLIGHT... NOT GOOD ON MONTANA ROADS WITH WILDLIFE PREVALENT ON ROADWAY... DEALER REPLACED UNDER WARRANTY... TWO WEEKS LATER SAME TROUBLE WITH RIGHT HEADLIGHT WHILE DRIVING HOME AT NIGHT FROM SPOKANE WA. TO BIGFORK, MT AGAIN DANGEROUS 5 HR DRIVE AT NIGHT ON FREEWAY WITH POOR VISIBILITY... THIS TIME DEALER SAID THEY NEEDED TO REPLACE BOTH THE RIGHT HEADLIGHT AND A COMPUTER SUB ASSY... HELP.. BOTH INSTANCES CAUSED UNSAFE DRIVING CONDITIONS, NIGHT WITH ONLY ONE HEADLIGHT WITH LOTS OF WILDLIFE CROSSING THE HWY... AND IT IS IMPORTANT TO KNOW WE CAN NOT SIMPLY PULL INTO SERVICE STATION AND REPLACE THE HEADLIGHT, IT IS A DEALER ONLY ITEM THAT WE ARE TOLD INVOLVES REMOVING THE FRONT BUMPER TO REPLACE... *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606