IllustrationBOUGHT THE CAR IN LATE OCTOBER AND THE LEFT FRONT HEADLIGHT HAS GONE OUT TWICE.
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Exterior Lighting complaints
579 reportsTL* THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STATED THAT THE PASSENGER SIDE HEADLIGHT FAILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT MOISTURE ENTERED THE HEADLIGHT AND AFFECTED THE HEADLIGHT CONCEALMENT DEVICES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STATED THAT THE PASSENGER SIDE HEADLIGHT FAILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT MOISTURE ENTERED THE HEADLIGHT AND AFFECTED THE HEADLIGHT CONCEALMENT DEVICES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
LEFT HEADLIGHT GOES OUT WHILE SETTING STILL AND WHILE DRIVING. ON A TEN MILE TRIP THE LIGHT WILL GO OUT 6 - 10 TIMES. TURNING THE LIGHT OFF AND BACK ON MAKES THE LIGHT TO BURN AGAIN. I HAVE BEEN STOPPED BY THE POLICE FOR THIS. WHEN I STOP I ,TURN THE HEADLAMPS OFF, WHEN THEY TELL ME WHY I WAS PULLED OVER FOR I PLAY DUMB AND THE…
Read full complaint
LEFT HEADLIGHT GOES OUT WHILE SETTING STILL AND WHILE DRIVING. ON A TEN MILE TRIP THE LIGHT WILL GO OUT 6 - 10 TIMES. TURNING THE LIGHT OFF AND BACK ON MAKES THE LIGHT TO BURN AGAIN. I HAVE BEEN STOPPED BY THE POLICE FOR THIS. WHEN I STOP I ,TURN THE HEADLAMPS OFF, WHEN THEY TELL ME WHY I WAS PULLED OVER FOR I PLAY DUMB AND THEY INSTRUCT ME TO TURN ON MY LIGHTS AND DIM THEM OR PUT ON HIGH BEAM. THEY ARE LEFT SCRATCHING THERE HEAD AND I'M ON MY WAY. THIS HAPPENS EVERY TIME THE VEHICLE IS DRIVEN AT NIGHT. ALSO HAPPENS SETTING STILL.
MY LIGHTS HAVE BEEN GOING OFF INTERMITTENTLY FOR A FEW MONTHS NOW. I WENT TO THE DEALERSHIP FOR A 12 V BATTERY ISSUE AND A COUPLE OF RECALL ITEMS, INCLUDING THE HYBRID COOLING RECALL ISSUE AND THE DEALER THOUGHT THIS MIGHT FIX THE ISSUE BUT IT HAS NOT. WHAT HAPPENS IS THAT AT ANY GIVEN MOMENT, EACH AND EVERY DAY/NIGHT, WHEN I …
Read full complaint
MY LIGHTS HAVE BEEN GOING OFF INTERMITTENTLY FOR A FEW MONTHS NOW. I WENT TO THE DEALERSHIP FOR A 12 V BATTERY ISSUE AND A COUPLE OF RECALL ITEMS, INCLUDING THE HYBRID COOLING RECALL ISSUE AND THE DEALER THOUGHT THIS MIGHT FIX THE ISSUE BUT IT HAS NOT. WHAT HAPPENS IS THAT AT ANY GIVEN MOMENT, EACH AND EVERY DAY/NIGHT, WHEN I AM DRIVING ONE OR THE OTHER HEADLIGHT WILL GO OUT. OCCASIONALLY BOTH WILL GO OUT. THE ONLY WAY THIS IS REMEDIED IS WHEN I TOGGLE THE LIGHT SWITCH OFF AND ON. SOMETIMES IT TAKES 2-3 TOGGLES TO GET THE PROBLEM TO RESOLVE, THE SUDDENLY AND AGAIN, AND AGAIN THE ONE OR THE OTHER LIGHTS GO OUT. APPARENTLY THIS IS AN ISSUE WITH TOYOTA PRIUS'S OF MY YEAR. THIS HAPPENS EVERY TIME I DRIVE AND THERE IS NO RHYME OR REASON. I HAPPENS WHEN I AM DRIVING. I HAVE TESTED IT TO SEE IF HAPPEN OVER BUMPS AND IT DOES NOT SPECIFICALLY--IT JUST HAPPENS WHEN I AM DRIVING AND SEVERAL TIMES OVER. I AM NOT A MECHANIC THOUGH YOU DON'T HAVE TO BE ONE TO SEE THAT THIS KIND OF ISSUE IS NOT THE BULB, BECAUSE WHEN THE BULBS ARE WORKING THEY SHINE BRIGHTLY. IT HAS TO BE SOME OTHER ISSUE WITH THE FUNCTIONING OF THE LIGHTING SYSTEM. THIS HAPPENS ON CITY STREETS, ON HIGHWAYS AND WHEN STATIONARY. IT HAPPENS WHEN I AM GOING STRAIGHT AND TURNING. IT HAPPENS AND ANY AND ALL SPEEDS.
RIGHT HEADLIGHT GOES OUT AFTER A FEW MINUTES. HAVE CHANGED BALLAST AND BULB TWICE, THE PROBLEM RECURRED ALMOST IMMEDIATELY BOTH TIMES.
HEADLIGHTS INTERMITTENTLY FLASH OFF WITH NO WARNING. CAN NOT BE REPAIRED. SOMETIMES BOTH FLIP OFF AT SAME TIME. ONE GOES OUT (OR BOTH) APPR. EVERY 5-10 MINUTES OF DRIVING, OR WHILE CAR IS STATIONARY WITH LIGHTS ON.
ABOUT TWO YEARS AGO, ONE OF MY HEADLIGHTS BEGAN TO CUT OUT WITHOUT WARNING. NOW, STARTING 2 MONTHS AGO, BOTH OF MY HEADLIGHTS STOP WORKING AT THE SAME TIME WITHOUT WARNING, I HAVE HAD 2 NEAR-MISSES BECAUSE OF THIS ISSUE, TOYOTA, MY CAR MANUFACTURER, REFUSES TO DO ANYTHING TO FIX THIS HIGHLY DANGEROUS ISSUE, EVEN THOUGH OVER 200…
Read full complaint
ABOUT TWO YEARS AGO, ONE OF MY HEADLIGHTS BEGAN TO CUT OUT WITHOUT WARNING. NOW, STARTING 2 MONTHS AGO, BOTH OF MY HEADLIGHTS STOP WORKING AT THE SAME TIME WITHOUT WARNING, I HAVE HAD 2 NEAR-MISSES BECAUSE OF THIS ISSUE, TOYOTA, MY CAR MANUFACTURER, REFUSES TO DO ANYTHING TO FIX THIS HIGHLY DANGEROUS ISSUE, EVEN THOUGH OVER 200,000 PRIUS OWNERS HAVE REPORTED THE PROBLEM. WHO KNOWS HOW MANY OTHER OWNERS OUT THERE WHO HAVE NOT REPORTED ANYTHING?!
KNOWN FORMALLY AS HIGH-INTENSITY DISCHARGE (HID) LIGHTS, THEY EITHER WORK INTERMITTENTLY ' MAKING NIGHTTIME DRIVING A LOT MORE EXCITING ' OR FAIL ENTIRELY......UPDATED 12/03/15 *BF UPDATED 11/17/17*JS
HEADLIGHTS SHORT OUT INTERMITTENTLY. BOTH HEADLIGHTS HAVE GONE OUT, THE LEFT HAS GONE OUT, THE RIGHT HAS GONE OUT. IF I TURN OFF THE LIGHTS AND FLIP THEM BACK ON, THEY OCCASSIONALLY BOTH COME BACK ON, OR ONE COMES BACK ON OR NEITHER COME BACK ON. THIS IS EXTREMELY DANGEROUS AT NIGHT. IT HAS TO BE ELECTRICAL. THERE'S…
Read full complaint
HEADLIGHTS SHORT OUT INTERMITTENTLY. BOTH HEADLIGHTS HAVE GONE OUT, THE LEFT HAS GONE OUT, THE RIGHT HAS GONE OUT. IF I TURN OFF THE LIGHTS AND FLIP THEM BACK ON, THEY OCCASSIONALLY BOTH COME BACK ON, OR ONE COMES BACK ON OR NEITHER COME BACK ON. THIS IS EXTREMELY DANGEROUS AT NIGHT. IT HAS TO BE ELECTRICAL. THERE'S NO WAY IT'S THE BULBS, I'VE OWNED THE CAR FOR A YEAR AND HAVE BLOWN THROUGH MANY BULBS ALREADY. THIS IS GETTING EXPENSIVE BESIDES DANGEROUS. THIS HAPPENS ON BUMPY ROADS, SMOOTH ROADS, TURNING, GOING STRAIGHT. I HAVEN'T FOUND A CERTAIN THING THAT MAKES THEM TURN OFF. THIS HAS BEEN HAPPENING FOR A LONG TIME, BUT I CAN ONLY CHOOSE ONE DATE BELOW.
WHILE DRIVING IN THE EARLY MORNING BEFORE SUNRISE, SEVERAL TIMES, THE HEADLIGHTS TURNED OFF SUDDENLY. FRIGHTENING WHILE ON THE HIGHWAY. LUCKILY THE LIGHTS TURNED BACK ON. THIS HAPPENED AT LEAST 5 DIFFERENT TIMES.
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606