IllustrationBOUGHT 2007 PRIUS USED AND EVERYTHING WORKED. NOW THE DRIVER SIDE HEADLIGHT WONT WORK AFTER SEVERAL NEW LIGHTBULBS AND A BALLAST HAVE BEEN CHANGED. IT HAS NEVER BEEN IN AN ACCIDENT TO MY KNOWLEDGE, I WOULD LIKE TO KNOW IF TOYOTA WILL FIX THEIR PROBLEMATIC VEHICLE.
2007 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2007 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2310–25K
57625–50K
39350–75K
20475–100K
210100–150K
107150K+
1,721 reports with mileage · 282 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 1,060 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 248 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
124 crash reports9 fire reports53 injury reports
Exterior Lighting complaints
1,060 reportsONE OR BOTH HEADLIGHTS WILL RANDOMLY TURN OFF WHILE DRIVING. MECHANIC WAS UNABLE TO FIND A PROBLEM TO FIX. THIS IS VERY DANGEROUS WHEN TRAVELING ON THE HIGHWAY AT HIGH SPEEDS. TOYOTA NEEDS TO RECALL THIS VEHICLE AND FIX THE PROBLEM!
THE RIGHT HEADLAMP LOW BEAM WORKS INTERMITTENTLY, I TURN IT ON AND OFF AND IT USUALLY WORKS AGAIN, MY ONLINE RESEARCH INDICATES THIS HAPPENS TO MANY OTHER PRIUS OWNERS AND NO RECALL HAS BEEN ISSUED AS OF YET
THE HEADLIGHTS TURN OFF DURING DRIVING, SO I EXIT THE FREEWAY AND TURN THEM ON AND OFF AND THEY START AGAIN AND SO ON, I ALREADY CHANGED THE BULB DID NOT HELP, I TOOK IT TWO TIMES TO THE LONGO TOYOTA IN EL MONTE CALIFORNIA AND THEY REFUSED TO REPAIR IT STATING THAT THEY COULD NOT DUPLICATE IT, I I COMPLAINED ABOUT THE NOISE…
Read full complaint
THE HEADLIGHTS TURN OFF DURING DRIVING, SO I EXIT THE FREEWAY AND TURN THEM ON AND OFF AND THEY START AGAIN AND SO ON, I ALREADY CHANGED THE BULB DID NOT HELP, I TOOK IT TWO TIMES TO THE LONGO TOYOTA IN EL MONTE CALIFORNIA AND THEY REFUSED TO REPAIR IT STATING THAT THEY COULD NOT DUPLICATE IT, I I COMPLAINED ABOUT THE NOISE OF THE ABS SYSTEM AND THEY REFUSED TO REPAIR IT THERE IS RECALL ON BOTH
I AM THE ORIGINAL OWNER OF A 2007 PRIUS. WHILE DRIVING, THE CAR HEADLIGHTS SHUT OFF RANDOMLY. SOMETIMES IT IS THE LEFT, SOMETIMES THE RIGHT, AND SOMETIMES BOTH. ONE WAY OF FIXING THE PROBLEM IS TO TURN LIGHTS OFF AND IMMEDIATELY ON AGAIN BUT THE PROBLEM WOULD REOCCUR AGAIN RANDOMLY. I KEEP CHECKING TO MAKE SURE THE LIGHTS ARE ON…
Read full complaint
I AM THE ORIGINAL OWNER OF A 2007 PRIUS. WHILE DRIVING, THE CAR HEADLIGHTS SHUT OFF RANDOMLY. SOMETIMES IT IS THE LEFT, SOMETIMES THE RIGHT, AND SOMETIMES BOTH. ONE WAY OF FIXING THE PROBLEM IS TO TURN LIGHTS OFF AND IMMEDIATELY ON AGAIN BUT THE PROBLEM WOULD REOCCUR AGAIN RANDOMLY. I KEEP CHECKING TO MAKE SURE THE LIGHTS ARE ON AND HAVE HAD MANY DRIVERS FLASH AT US SINCE THE LIGHTS ARE OFF WHEN I DON'T EVEN KNOW IT. I AM NOW AFRAID TO DRIVE THE CAR FOR SAFETY REASON. BOTH HID LIGHTS HAVE BEEN REPLACED LESS THAN 2 YEARS AGO. THE PROBLEM IS UNLIKELY RELATED TO THE BULBS SINCE TURNING THE LIGHTS OFF AND ON WOULD TEMPORARILY FIX THE PROBLEM. AFTER RESEARCHING THE WEB, IT APPEARS THAT THIS IS A COMMON PROBLEM FOR THIS GENERATION OF PRIUS. I KNOW THERE WAS A CLASS ACTION FILED SEVERAL YEARS AGO BUT THERE IS NO RECALL FOR THIS ISSUE. I WANT TO RAISE THE AWARENESS OF THIS ISSUE AGAIN AND I'D OBVIOUSLY LIKE TOYOTA TO DO SOMETHING TO FIX THE ISSUE SINCE DRIVING AT 65MPH LAST NIGHT AND HAVING BOTH LIGHTS SIMPLY TURN OFF WAS A TERRIFYING EXPERIENCE.
AS INDICATED BY NUMEROUS OTHER OWNERS OF THIS CAR THE HEADLIGHTS GO OUT, THEN YOU TURN THE LIGHTS OFF AND ON, AND THEY COME BACK ON FOR AN UNDETERMINED AMOUNT OF TIME AGAIN. IT HAPPENS WHEN DRIVING,SITTING AT A LIGHT, OR ANY TIME WHEN THE CAR IS RUNNING. IT DOESNT MATTER WHAT SPEED YOU ARE AT OR THE TEMPERATURE OUTSIDE. I'M …
Read full complaint
AS INDICATED BY NUMEROUS OTHER OWNERS OF THIS CAR THE HEADLIGHTS GO OUT, THEN YOU TURN THE LIGHTS OFF AND ON, AND THEY COME BACK ON FOR AN UNDETERMINED AMOUNT OF TIME AGAIN. IT HAPPENS WHEN DRIVING,SITTING AT A LIGHT, OR ANY TIME WHEN THE CAR IS RUNNING. IT DOESNT MATTER WHAT SPEED YOU ARE AT OR THE TEMPERATURE OUTSIDE. I'M NOT SURE OF EXACT DATE WHEN IT STARTED BUT IT WAS AROUND 45,000 MILES AND IT WAS OUT OF WARRANTY BECAUSE WE OWNED IT SINCE NEW AND TOOK IT TO OUR DEALER WHO COULD DO NOTHING FOR US. WE CHANGED THE BULB OURSELF...NUMEROUS TIMES NOW. I LOVE THE CAR OTHER THAN THE HEADLIGHTS. THERE ARE THOUSANDS OF OTHERS OF PEOPLE OUT THERE WITH THE SAME PROBLEM. ITS A SAFETY ISSUE.
THIS IS THE WELL KNOWN HID PROBLEM ON MY 2007 PRIUS. MY CAR DIDN'T REACH THE 90K MILES YET AND SOME CASES THE DRIVER SIDE HID BULD SOMETIMES DOES NOT COME ON AFTER I TURN ON LIGHTS OR SOMETIMES IT GOES OUT WHILE I AM DRIVING. ONE RANDOM WAY OF FIXING IS TO TURN LIGHTS OFF AND IMMEDIATELY ON AGAIN. I AM JUST ABOUT TO REPLACE THE …
Read full complaint
THIS IS THE WELL KNOWN HID PROBLEM ON MY 2007 PRIUS. MY CAR DIDN'T REACH THE 90K MILES YET AND SOME CASES THE DRIVER SIDE HID BULD SOMETIMES DOES NOT COME ON AFTER I TURN ON LIGHTS OR SOMETIMES IT GOES OUT WHILE I AM DRIVING. ONE RANDOM WAY OF FIXING IS TO TURN LIGHTS OFF AND IMMEDIATELY ON AGAIN. I AM JUST ABOUT TO REPLACE THE HID BULBS IN PAIR FIRST TO SEE IF THIS SOLVES THE PROBLEM, THEN MAYBE THE BALLAST IS THE NEXT ON LIST AS I FIGURED OUT FROM THE INFO AVAILABLE ON THE WEB.
WHILE DRIVING, AT NIGHT, BOTH HEADLIGHTS WENT OUT (WENT DARK). SINCE I WAS NEAR HOME, WITHIN MY SUBDIVISION, I STOPPED THE CAR IMMEDIATELY AND SWITCHED THE LIGHTS OFF AND THEN BACK ON AGAIN. THE LIGHTS CAME BACK ON, SO I DROVE HOME AND HAVE NOT DRIVEN THE CAR AFTER DARK, AGAIN.
56K ON MY 2007 PRIUS. DRIVING LAST NIGHT ON A DARK COUNTRY ROAD AND THE LIGHTS FLICKERED THEN WENT OUT. TURNED THEM OFF AND ON AND THEY CAME BACK ON BUT IT REPEATED ALL THE WAY HOME. NOW I CANT DRIVE AT NIGHT TILL I GET THIS FIXED. COME TO FIND OUT ITS AN ISSUE WITH THESE CARS. DOES SOMEONE HAVE TO DIE TO GET THIS TAKEN CARE OF?
THE TRUNK RELEASE LATCH ON MY 2007 PRIUS HAS DETERIORATED ALMOST TO THE POINT OF NOT BEING ABLE TO OPEN THE TRUNK. THE SAME PART WAS REPLACED ABOUT 4 YEARS AFTER I PURCHASED THE VEHICLE. AND NOW, IT'S HAPPENING AGAIN. IT'S LIKE THE PLASTIC STUFF IS MELTING AND FALLING APART. WE ARE HAVING TO PURCHASE THIS SAME PART, FOR THE SECO…
Read full complaint
THE TRUNK RELEASE LATCH ON MY 2007 PRIUS HAS DETERIORATED ALMOST TO THE POINT OF NOT BEING ABLE TO OPEN THE TRUNK. THE SAME PART WAS REPLACED ABOUT 4 YEARS AFTER I PURCHASED THE VEHICLE. AND NOW, IT'S HAPPENING AGAIN. IT'S LIKE THE PLASTIC STUFF IS MELTING AND FALLING APART. WE ARE HAVING TO PURCHASE THIS SAME PART, FOR THE SECOND TIME NOW. LOVE MY PRIUS, BUT HATE HAVING TO MAKE REPAIRS ON THE SAME ISSUE 2 TIMES. ALSO, I HAD THE HEADLIGHTS REPAIRED (FROM A RECALL) ABOUT 2 YEARS AFTER I PURCHASED THE CAR. THE FRONT HEADLIGHTS ARE STILL DOING THE SAME THING. THE PROBLEM WAS NEVER REALLY FIXED. WHILE DRIVING AT NIGHT AND IN DAY TIME, THE HEADLIGHTS GO OUT. USUALLY THEY GO OUT ONE AT A TIME. LIKE THE RIGHT SIDE WILL GO OUT. THEN YOU CAN FLIP THE SWITCH TO TURN THEM ON AND OFF, AND IT'LL WORK AGAIN FOR ABOUT 5 MINUTES. THEN THE LEFT SIDE WILL GO OUT. THIS USUALLY HAPPENS EVERY NIGHT WHILE DRIVING AND I HAVE TO FLIP THE SWITCH ON AND OFF ABOUT 9 TIMES WHILE DRIVING SHORT AND LONG DISTANCES. I JUST USUALLY FLIP THE SWITCH AND THEY COME BACK ON AGAIN. SOMETIMES WHILE DRIVING AT NIGHT, THEY BOTH GO OUT AT THE SAME TIME. REALLY A SAFETY HAZARD WHEN DRIVING AROUND WITH MY 2 SMALL KIDS!! BROUGHT IT BACK TO TOYOTA DEALERSHIP IN LAKE CHARLES TO BE REPAIRED. BUT THEY SAID THEY COULDN'T RE-CREATE THE PROBLEM, SO THEY COULDN'T FIX IT. HOW LONG DO YOU THINK I CAN KEEP DRIVING AROUND IN THE DARK WITH MALFUNCTIONING LIGHTS AND KIDS IN THE CAR????????????????? THIS HAPPENS DAILY!!!!!!!!!!!!!!!!!!!!!!!
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE09019 · Headlight Failure
Opened Apr 17, 2009 · Closed Aug 27, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.