2018 Toyota Highlander

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The issue involves the Dynamic Radar Cruise Control system (vehicle-to-vehicle distance control mode) in my 2018 Toyota Highlander. This system automatically cancels when the vehicle’s speed drops to approximately 25 mph (40 km/h) or below. The system disengages without driver input during normal driving conditions such as heavy traffic or congestion. The component remains functional but poses a safety concern due to its operational design. The vehicle and system are available for inspection upon request. 2. How was your safety or the safety of others put at risk? This malfunction creates a significant safety risk when driving in stop-and-go or congested traffic. The sudden loss of adaptive speed control forces the driver to quickly resume manual braking and acceleration, which can cause delayed reactions and potential rear-end collisions. The unexpected disengagement may also confuse drivers, especially those relying on the system to maintain safe following distances. This behavior increases cognitive load and the chance of driver error, particularly for elderly or less experienced drivers. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been observed and replicated multiple times during normal driving conditions, such as during city traffic or highway slowdowns. It is also acknowledged in the vehicle owner’s manual, which specifies that the system automatically cancels below approximately 25 mph. However, this design flaw has not been formally addressed or corrected by Toyota dealerships or service centers as a safety concern. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has not been inspected specifically for this concern by Toyota or other third parties. However, the condition is consistent across the same model and year,

August 14, 2025 while coming home from work, truck started to lose power. It slowed down on the main street and then coasted to a complete stop in the middle of the road. There were no signals or alerts until it went dead. The vehicle will start, but it will not advance when put in drive. I have had the vehicle towed to my dealership to expedite diagnosing the issue.

I just found out that there was an initial recall #20V012000 and an expanded recall #20V682000 on my 2018 Toyota Highlander that I was unaware of regarding the low-pressure fuel pump inside the fuel tank could fail risking engine stalling and potential crash. I found this out after paying 1100.00 to Sheehy Toyota in Fredericksburg to replace the fuel pump. I reported it to Toyota Brand Services for reimbursment and was told that it was NOT a recall it was a CSP (which to them is different they said) and that the fuel pump that I had replaced was a low pressure fuel pump and the CSP was for a high pressure fuel pump. I need help getting my money back after being charged for a recall.

At 11:15 AM, June 13, 2025 when I turn right at intersection, my steering wheel suddenly became hard (could not turn). My car nearly hit median in my left hand when the steering wheel back to normal. So I could steer my car avoid accident. This is first time I encountered problem like this. Everything is normal right now. No warning or everything popped up on display.

While driving my 2018 Toyota Highlander (UA80F transmission), I began noticing a faint high-pitched whining noise between 25–45 mph around 63,000 miles. Over time, it progressively worsened, eventually including intermittent jerking and hard low-speed shifts, particularly during acceleration or uphill climbs. In wet conditions, the drivetrain lurches slightly under throttle, increasing risk of loss of control. I had a transmission fluid drain and fill service performed by a Toyota dealership at ~58,000 miles, along with full 4WD maintenance (differentials and transfer case). Despite this, symptoms developed shortly afterward. Toyota was notified and a corporate case was opened. I provided clear sound recordings, videos, and a full inspection history, and cited their Customer Support Program ZJC (POL19-04) for known defects related to UA80F whine and washer tab failures. Although my build date falls within the general failure range, Toyota refused coverage and claimed it was “operating to spec.” Tier 1 support initially confirmed ZJC eligibility, but Tier 2 reversed course with no follow-up. Dealership service also failed to elevate the case properly to my Zurich warranty provider, who required dealer confirmation to proceed. Multiple other owners have reported similar failures around 60K–100K miles, and I believe this is a dangerous latent defect that Toyota is attempting to narrowly contain. Whining precedes jerking, and jerking precedes full failure. Many complainants, like me, are met with stall tactics, deflection, or no follow-through. There were no warning lights or diagnostic codes, but the safety risk is growing. I believe this transmission issue deserves expanded CSP eligibility and potential recall investigation.