2014 Toyota Highlander

I noticed the smell of wires burning, a billow of smoke started emitting from the two levers used to heat the seats near the gear shift area. I was on the freeway and immediately pulled to the side of the road, turned off the car and called 911 before any flames were seen. There were no warning signs, lamps or other symptoms until the smell of burning wires and the smoke.

The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure; however, the vehicle manufacturer was not made aware of the failure. The approximate failure mileage was 190,000.

The power rear hatch will not properly open or close. The safety of others are at risk due to several factors. For example, the door will not open properly causing hands, fingers, and other object to get jammed in the doorway when trying to close it manually or when the door closes automatically without warning. It also does not close properly when the hatch is not working properly which could potentially be an issue while traveling where objects could fall out of the vehicle and injure other drivers. There are several articles online reporting the issue and will only be fixed if the vehicle is under warranty. Many of these vehicles are out of warranty due to their age. There was no prior warning other than a beeping noise when the door would not close properly.

THE REAR DOOR LOCKS DO NOT LOCK ALL THE TIME MAKING IT POSSIBLE FOR THE KIDS IN THE BACK SEAT TO OPEN THE DOORS WHILE DRIVING DOWN THE ROAD ON MY 2014 HIGHLANDER. IT ALSO MAKES IT PRETTY EASY FOR PEOPLE TO STEAL STUFF FROM YOUR CAR. THIS IS A HUGE SAFETY ISSUE. IT IS A KNOW ISSUE AND THE INTERNET FORUMS ARE FULL OF PEOPLE WITH THE SAME ISSUE WITH ZERO HELP FROM THE DEALER. NEW LOCK MECHANISMS ARE 300 DOLLARS. I HAVE ALREADY HAD TO REPLACE ONE AT 75K MILES,. NOW I HAVE TO DO THE OTHER. THE VEHICLE NOW HAS 100K. *TR

ENTUNE RADIO/HEADUNIT (HU) REBOOT ITSELF WHILE IN A CALL. REBOOT OCCURS WHILE VEHICLE IS IN MOTION AT ANY SPEED, DURING ANY DRIVING CONDITION. AS THE HU REBOOTS, DRIVER IS UNABLE TO USE REAR-VIEW CAMERA AND ANY OTHER FEATURE DISPLAYED IN HU. ROAD ATTENTION IS AFFECTED SINCE DRIVER IS DISTRACTED BY THE SCREEN GOING BLACK AND ON AGAIN. ALSO IF DRIVER IS IN A CALL HAS TO END CALL FROM THE PHONE AND CALL AGAIN USING THE PHONE.

TL* THE CONTACT OWNS A 2014 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE REAR POWER DOORS AND TRUNK MADE A BUZZING NOISE AND WERE INOPERATIVE. THE CONTACT REFERENCED SERVICE BULLETIN NUMBER: SB0023-16 AND NHTSA ID NUMBER: 10134306 (STRUCTURE, ELECTRICAL SYSTEM). SPARKS TOYOTA (LOCATED AT 4855 HIGHWAY 501, MYRTLE BEACH, SC 29526, 888-847-7870) WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.