NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
216 reports48,800 miles · Jan 20, 2015
Steering
TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. WHILE DRIVING AT APPROXIMATELY 5 MPH AND MAKING A RIGHT TURN, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE INTERMEDIATE SHAFT AND TSB NEEDED TO …
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. WHILE DRIVING AT APPROXIMATELY 5 MPH AND MAKING A RIGHT TURN, THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE INTERMEDIATE SHAFT AND TSB NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,800.
NHTSA ODI #10676775
65,462 miles · Jan 20, 2015
Visibility/wiper
THE DRIVER'S SIDE VISOR FAILS TO STAY UP AND DROPS TO BLOCK DRIVER'S VIEW. *TR
NHTSA ODI #10676740
50,000 miles · Jan 20, 2015
Visibility/wiper
THE DRIVER'S SIDE SUN VISOR WILL NOT STAY UP. REPEATED ATTEMPTS TO GET THE LOCAL TOYOTA DEALER TO FIX THE PROBLEM RESULTED IN THEM SAYING THAT IT IS NOT COVERED BY THE WARRANTY. THIS IS A SAFETY ISSUE. THE VISOR COULD FALL ENOUGH TO BLOCK THE DRIVER'S VISION. ALSO, IN THE EVENT OF AN ACCIDENT THE DRIVER'S FOREHEAD WOULD BE PROP…
Read full complaint
THE DRIVER'S SIDE SUN VISOR WILL NOT STAY UP. REPEATED ATTEMPTS TO GET THE LOCAL TOYOTA DEALER TO FIX THE PROBLEM RESULTED IN THEM SAYING THAT IT IS NOT COVERED BY THE WARRANTY. THIS IS A SAFETY ISSUE. THE VISOR COULD FALL ENOUGH TO BLOCK THE DRIVER'S VISION. ALSO, IN THE EVENT OF AN ACCIDENT THE DRIVER'S FOREHEAD WOULD BE PROPELLED INTO THE EDGE OF A SUN VISOR THAT IS PARTIALLY DOWN CAUSING A POSSIBLE SERIOUS HEAD INJURY. THIS ISSUE SHOULD BE A SAFETY RECALL. *TR
NHTSA ODI #10676702
45,000 miles · Jan 3, 2015
Visibility/wiper
I PURCHASED THIS 2010 TOYOTA HIGHLANDER NEW. AT 45,000 MILES, THE DRIVER-SIDE SUN VISOR FAILED TO REMAIN IN THE UPRIGHT POSITION. IT CONTINUES TO FALL AND BLOCK THE DRIVER'S VIEW WHEN DRIVING. EVEN THOUGH THE VEHICLE WAS WITHIN THE 50,000 MILE WARRANTY PERIOD, THE DEALERSHIP SAID THE SUN VISOR IS NOT COVERED UNDER THE WARRANT…
Read full complaint
I PURCHASED THIS 2010 TOYOTA HIGHLANDER NEW. AT 45,000 MILES, THE DRIVER-SIDE SUN VISOR FAILED TO REMAIN IN THE UPRIGHT POSITION. IT CONTINUES TO FALL AND BLOCK THE DRIVER'S VIEW WHEN DRIVING. EVEN THOUGH THE VEHICLE WAS WITHIN THE 50,000 MILE WARRANTY PERIOD, THE DEALERSHIP SAID THE SUN VISOR IS NOT COVERED UNDER THE WARRANTY. I NEW VISOR IS OVER $200. I USED TO WORK FOR THE TOYOTA AT THE HEADQUARTERS LOCATED IN TORRANCE, CALIFORNIA. IT IS UNFORTUNATE THAT TOYOTA DOES NOT RECOGNIZE THIS SUN VISOR AS A CUSTOMER HAZARD AND FAILURE OF THE PART. THIS FAILURE SHOULD BE REPAIRED/REPLACED AT TOYOTA'S EXPENSE BEFORE IT CAUSES SERIOUS HARM TO THE DRIVER AND PASSENGERS. *TR
NHTSA ODI #10669848
40,000 miles · Dec 27, 2014
Equipment Adaptive/mobilityVisibility/wiper
VISOR ON DRIVER'S SIDE DROPPED DOWN AND WILL NOT STAY UP. IT IS AN ABSOLUTE HAZARD. *TR
NHTSA ODI #10668429
40,000 miles · Dec 9, 2014
Structure
APPARENTLY THIS IS A VERY COMMON PROBLEM FROM MY RESEARCH AND MY DISCUSSION WITH THE DEALER. MY 2010 HIGHLANDER WITH 40K MILES HAS A POWER REAR DOOR. THE HINGES HOLDING THE DOOR ARE SPACED TOO FAR WHICH CAUSES STRESS ON THE MECHANICAL ARM AND BOLT THAT ATTACH TO THE DOOR. MY WIFE WAS IN THE VEHICLE AND PRESSED THE BUTTON TO CLOS…
Read full complaint
APPARENTLY THIS IS A VERY COMMON PROBLEM FROM MY RESEARCH AND MY DISCUSSION WITH THE DEALER. MY 2010 HIGHLANDER WITH 40K MILES HAS A POWER REAR DOOR. THE HINGES HOLDING THE DOOR ARE SPACED TOO FAR WHICH CAUSES STRESS ON THE MECHANICAL ARM AND BOLT THAT ATTACH TO THE DOOR. MY WIFE WAS IN THE VEHICLE AND PRESSED THE BUTTON TO CLOSE THE REAR POWER DOOR WHEN SHE HEARD A LOUD "POP". THE BOLT ATTACHING THE "ARM" TO THE DOOR STRIPPED AND CAME OUT OF THE DOOR. THE DEALER SAID MY FULL COVERAGE "BUMPER TO BUMPER" WARRANTY DOES NOT COVER THIS AND GAVE ME THE PHONE NUMBER TO TOYOTA. I SPOKE WITH TOYOTA AND THEY INVESTIGATED THE ISSUE WITH THE DEALER. TOYOTA CAME BACK AND OFFERED TO SPLIT THE COST 50%. THIS IS UNACCEPTABLE IN MY OPINION AS IT IS CLEARLY A MANUFACTURING ISSUE AS WELL AS A SAFETY CONCERN. IF MY WIFE HAD BEEN BEHIND THE VEHICLE AND PRESSED THE POWER DOOR BUTTON, SHE COULD HAVE BEEN STRUCK IN THE FACE WITH THE METAL BAR WHEN IT PULLED ITSELF OUT OF THE DOOR. TOYOTA SHOULD STAND BEHIND THEIR PRODUCT ESPECIALLY TO THOSE WHO WENT THE EXTRA STEP AND PURCHASED AN EXTENDED WARRANTY THROUGH THEM. THIS SHOULD BE BEYOND THE STANDARD 3 YEAR 36K WARRANTY AND ABOVE THAT, SHOULD BE A RECALL ISSUE DUE TO THE POTENTIAL SAFETY HAZARD THIS ISSUE CAN CAUSE. *TR
NHTSA ODI #10663231
65,000 miles · Dec 5, 2014
Visibility/wiper
DRIVER SIDE SUN VISOR SPRING SEEMS TO BE DEFECTIVE AND THE SUN VISOR KEEPS FALLING DOWN (DOES NOT STAY IN UP POSITION) BLOCKING THE VISIBILITY OF THE ROAD. *TR
NHTSA ODI #10662449
120,000 miles · Nov 11, 2014
Visibility/wiper
DRIVER SIDE SUN VISOR TENSION COMPLETELY BROKE UNDER NORMAL USE. VISOR HANGS STRAIGHT DOWN AND WON'T RETURN TO THE UP POSITION, OR ANY OTHER POSITION. BLOCKS MUCH OF THE FIELD OF VIEW FOR ANY DRIVER (LIKE ME) TALLER THAN 5'5". *TR
NHTSA ODI #10654206
25,581 miles · Oct 28, 2014
Service Brakes
ON JULY 16, 2014 I TURNED MY CAR ON, READY TO RETURN HOME TO NEW JERSEY FROM BROOKLYN, AT THIS POINT THE BRAKE LIGHT SIGNAL, ABS, AND WARNING ICON ALL TURNED ON. THE CAMERA DISPLAYED A TEXT STATING BRAKE MALFUNCTION AND GIVING INSTRUCTIONS TO PARK THE CAR IMMEDIATELY. I CALLED THE TOYOTA 800 NUMBER AND FOLLOWED THEIR RECOMMENDAT…
Read full complaint
ON JULY 16, 2014 I TURNED MY CAR ON, READY TO RETURN HOME TO NEW JERSEY FROM BROOKLYN, AT THIS POINT THE BRAKE LIGHT SIGNAL, ABS, AND WARNING ICON ALL TURNED ON. THE CAMERA DISPLAYED A TEXT STATING BRAKE MALFUNCTION AND GIVING INSTRUCTIONS TO PARK THE CAR IMMEDIATELY. I CALLED THE TOYOTA 800 NUMBER AND FOLLOWED THEIR RECOMMENDATIONS, L HAD THE CAR TOW TO THE NEAREST TOYOTA DEALER, BAY RIDGE TOYOTA OF BROOKLYN. I PICKED UP THE CAR ON THE 18 TH, I WAS TOLD THEY RAN ALL TESTS AN THEY FOUND EVERYTHING PROPERLY INSTALLED. THEY SCAN TEST CLEAN ALL DTC PERFORMED INITIALIZATION AND CALIBRATION OF THE LINEAR SOLENOID VALVE. THEY ROAD TESTED THE VEHICLE AND CONFIRMED REPAIR, NO LIGHTS ON, AT A COST OF $227 PLUS TAX. TODAY THE 28 OF OCTOBER AS I TURNED MY CAR ON I FACE THE SAME PROBLEM ALL THE BRAKE LIGHTS, ABS, WARNING, AND DISPLAY TEXT INDICATING MALFUNCTION, TO STOP THE CAR. I AGAIN CALLED FOR TOW WENT TO TOYOTA OF HILLSIDE IN NJ, EXPLAINED WHAT HAPPENED. WAS ASK WHY I HAD THE CAR TOW AFTER TELLING THE SERVICE REPRESENTATIVE ABOUT THE BRAKES. HOW CAN ANYONE DRIVE A VEHICLE THAT IS WARNING YOU NOT TO DO SO. I ALSO SPOKE TO THE SERVICE MANAGER STATING THAT I DON'T THINK I SHOULD PAY FOR THIS SERVICE AGAIN SINCE ITS BEEN ONLY 1500 MILES OR A LITTLE OVER 90 DAYS SINCE THE SAME PROBLEM. AM SURE THERE'S MORE TO THIS. THANK YOU *TR
NHTSA ODI #10650758
3,000 miles · Oct 21, 2014
Electrical SystemVisibility
SEVERAL TIMES SINCE WE PURCHASED THE VEHICLE, THE FRONT DRIVER'S WINDOW WILL COME OFF TRACK AND NOT ALLOW TO ROLL UP THE WINDOW. THIS REALLY IS NOT A SAFETY ISSUE HOWEVER ONE TIME THE WINDOW DID NOT COME OFF TRACK HOWEVER THE DOOR WOULD NOT OPEN FROM THE INSIDE. WE HAD TO ROLL DOWN THE WINDOW TO OPEN FROM THE OUTSIDE. THIS WAS V…
Read full complaint
SEVERAL TIMES SINCE WE PURCHASED THE VEHICLE, THE FRONT DRIVER'S WINDOW WILL COME OFF TRACK AND NOT ALLOW TO ROLL UP THE WINDOW. THIS REALLY IS NOT A SAFETY ISSUE HOWEVER ONE TIME THE WINDOW DID NOT COME OFF TRACK HOWEVER THE DOOR WOULD NOT OPEN FROM THE INSIDE. WE HAD TO ROLL DOWN THE WINDOW TO OPEN FROM THE OUTSIDE. THIS WAS VERY SCARY SINCE MY WIFE DRIVES THE VEHICLE AND TRANSPORTS OUR CHILDREN AND GRANDSON. I WAS AFRAID IF SHE WERE IN AN ACCIDENT AND THE POWER WINDOW DID NOT WORK SHE WOULD HAVE TO FIND ANOTHER WAY TO EXIT THE VEHICLE. SINCE THE VEHICLE HAS BEEN OUT OF WARRANTY, WE FOUND ANOTHER PLACE TO FIX THE ISSUE. WE STILL HAVE ISSUES AT TIMES WITH THE WINDOW. ANOTHER ISSUE IS THAT THE REAR DOOR SENSOR CONSTANTLY INDICATES THE DOOR IS OPEN WHEN IT IS NOT. WHEN THIS HAPPENS, THE REAR DISPLAY STOPS WORKING AND SAYS REAR DOOR OPEN, THE OVERHEAD LIGHTS FLASH, AND THE DOOR CHIME SOUNDS. I CONSIDER THIS A SAFETY ISSUE SINCE IT CAUSES A DISTRACTION WHILE DRIVING. WITH THE DOOR CHIMING, LIGHTS FLASHING, AND THE REAR DISPLAY SHOWING A MESSAGE, IT TAKES OUR ATTENTION AWAY FROM DRIVING. *TR
NHTSA ODI #10649182
Official recalls
10Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration