NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
25 reportsClear category filter25,581 miles · Oct 28, 2014
Service Brakes
ON JULY 16, 2014 I TURNED MY CAR ON, READY TO RETURN HOME TO NEW JERSEY FROM BROOKLYN, AT THIS POINT THE BRAKE LIGHT SIGNAL, ABS, AND WARNING ICON ALL TURNED ON. THE CAMERA DISPLAYED A TEXT STATING BRAKE MALFUNCTION AND GIVING INSTRUCTIONS TO PARK THE CAR IMMEDIATELY. I CALLED THE TOYOTA 800 NUMBER AND FOLLOWED THEIR RECOMMENDAT…
Read full complaint
ON JULY 16, 2014 I TURNED MY CAR ON, READY TO RETURN HOME TO NEW JERSEY FROM BROOKLYN, AT THIS POINT THE BRAKE LIGHT SIGNAL, ABS, AND WARNING ICON ALL TURNED ON. THE CAMERA DISPLAYED A TEXT STATING BRAKE MALFUNCTION AND GIVING INSTRUCTIONS TO PARK THE CAR IMMEDIATELY. I CALLED THE TOYOTA 800 NUMBER AND FOLLOWED THEIR RECOMMENDATIONS, L HAD THE CAR TOW TO THE NEAREST TOYOTA DEALER, BAY RIDGE TOYOTA OF BROOKLYN. I PICKED UP THE CAR ON THE 18 TH, I WAS TOLD THEY RAN ALL TESTS AN THEY FOUND EVERYTHING PROPERLY INSTALLED. THEY SCAN TEST CLEAN ALL DTC PERFORMED INITIALIZATION AND CALIBRATION OF THE LINEAR SOLENOID VALVE. THEY ROAD TESTED THE VEHICLE AND CONFIRMED REPAIR, NO LIGHTS ON, AT A COST OF $227 PLUS TAX. TODAY THE 28 OF OCTOBER AS I TURNED MY CAR ON I FACE THE SAME PROBLEM ALL THE BRAKE LIGHTS, ABS, WARNING, AND DISPLAY TEXT INDICATING MALFUNCTION, TO STOP THE CAR. I AGAIN CALLED FOR TOW WENT TO TOYOTA OF HILLSIDE IN NJ, EXPLAINED WHAT HAPPENED. WAS ASK WHY I HAD THE CAR TOW AFTER TELLING THE SERVICE REPRESENTATIVE ABOUT THE BRAKES. HOW CAN ANYONE DRIVE A VEHICLE THAT IS WARNING YOU NOT TO DO SO. I ALSO SPOKE TO THE SERVICE MANAGER STATING THAT I DON'T THINK I SHOULD PAY FOR THIS SERVICE AGAIN SINCE ITS BEEN ONLY 1500 MILES OR A LITTLE OVER 90 DAYS SINCE THE SAME PROBLEM. AM SURE THERE'S MORE TO THIS. THANK YOU *TR
NHTSA ODI #10650758
31,000 miles · Sep 29, 2014
EnginePower TrainService Brakes
TWICE IN SEPTEMBER 2014, AS I WAS APPROACHING A STOP LIGHT, I PRESSED THE BRAKES AND SLOWED TO NEARLY A STOP. THE ENGINE SUDDENLY ACCELERATED VERY HIGH, AND IF I HAD NOT ALREADY HAD A FOOT ON THE BRAKES, I WOULD HAVE GONE INTO AN INTERSECTION. THE ENGINE WAS RUNNING SO HIGH THAT IT WAS DIFFICULT TO KEEP IT FROM MOVING. I SHIF…
Read full complaint
TWICE IN SEPTEMBER 2014, AS I WAS APPROACHING A STOP LIGHT, I PRESSED THE BRAKES AND SLOWED TO NEARLY A STOP. THE ENGINE SUDDENLY ACCELERATED VERY HIGH, AND IF I HAD NOT ALREADY HAD A FOOT ON THE BRAKES, I WOULD HAVE GONE INTO AN INTERSECTION. THE ENGINE WAS RUNNING SO HIGH THAT IT WAS DIFFICULT TO KEEP IT FROM MOVING. I SHIFTED INTO NEUTRAL, CAME TO A COMPLETE STOP, AND WHILE THE TRANSMISSION WAS IN NEUTRAL, TOOK MY FOOT OFF THE BRAKE PEDAL. THE ENGINE IMMEDIATELY RETURNED TO NORMAL IDLE. THIS SAME SEQUENCE HAPPENED BOTH TIMES. THIS HAS HAPPENED TWICE THIS MONTH, BUT THESE ARE THE FIRST OCCURRENCES SINCE I PURCHASED THE VEHICLE NEW. I CALLED THE TOYOTA DEALER, AND THE SERVICE PERSON SAID THAT IF THE VEHICLE ISN'T DEMONSTRATING THAT BEHAVIOR WHEN I BRING IT IN, THEY WOULD NOT BE ABLE TO FIND WHAT CAUSED IT. THEY INDICATED THAT THE VEHICLE DATA RECORDER WOULD NOT RECORD SUCH AN EVENT. THEY SAID THEY WOULD ADD A NOTE ABOUT THIS TO THE RECORD THEY HAVE ON THIS VEHICLE (THEY HAVE DONE ALL THE SERVICE SINCE I PURCHASED IT FROM THEM). I HAVE ALREADY DECIDED THAT SHOULD IT HAPPEN AGAIN, I WILL TRADE THE VEHICLE. I DON'T LIKE HAVING TO KEEP MY HAND ON THE GEARSHIFT, READY TO SHIFT INTO NEUTRAL. I SAW A REPORT IN USATODAY THAT SUDDEN ACCELERATION IN TOYOTAS IS BEING INVESTIGATED AGAIN. I WANTED TO ADD MY EXPERIENCE TO THE MIX. *TR
NHTSA ODI #10639837
43,000 miles · Sep 3, 2014
Service Brakes
TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING THE BRAKES FAILED AND THE BRAKE PEDAL WENT TO THE FLOOR. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING, WHO STATED THIS WAS NORMAL FOR VEHICLE WITH ABS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. …
Read full complaint
TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING THE BRAKES FAILED AND THE BRAKE PEDAL WENT TO THE FLOOR. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING, WHO STATED THIS WAS NORMAL FOR VEHICLE WITH ABS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 43,000.
NHTSA ODI #10630297
52,000 miles · Apr 27, 2013
Service BrakesSteeringVehicle Speed ControlCrash
I'D STOPPED ON THE RESIDENTIAL STREET TO LET A CAR PASS. AFTER THE CAR PASSED, I ATTEMPTED TO PULL UP ALONG THE CURB TO PARK, BUT THE CAR ACCELERATED AND CRASHED INTO A TREE. THE BRAKES DID NOT RESPOND AND THE STEERING DID NOT SEEM TO RESPOND. THE SPACE BETWEEN ACCELERATION AND IMPACT WAS 10-15 FEET. IT'S LIKE THE CAR HAD A M…
Read full complaint
I'D STOPPED ON THE RESIDENTIAL STREET TO LET A CAR PASS. AFTER THE CAR PASSED, I ATTEMPTED TO PULL UP ALONG THE CURB TO PARK, BUT THE CAR ACCELERATED AND CRASHED INTO A TREE. THE BRAKES DID NOT RESPOND AND THE STEERING DID NOT SEEM TO RESPOND. THE SPACE BETWEEN ACCELERATION AND IMPACT WAS 10-15 FEET. IT'S LIKE THE CAR HAD A MIND OF ITS OWN, AND I HAD NO CONTROL. NO WARNING LIGHTS CAME ON AND THE AIRBAGS DID NOT DEPLOY. THE PASSENGER SIDE HEADLIGHT WAS SMASHED, THE HOOD WAS SMASHED, FRONT BUMPER AND PASSENGER SIDE FENDER WERE ALSO SMASHED. THE ONLY THING THAT STOPPED THE CAR WAS THE TREE. ONCE IT STOPPED, I SIMPLY TURNED THE IGNITION OFF. I IMMEDIATELY CALLED MY INSURANCE COMPANY AND THEY TOLD ME TO TOW IT TO SAN FRANCISCO TOYOTA FOR MECHANICAL INSPECTION. I CALLED SAN FRANCISCO TOYOTA AND SAID THAT I WAS TOWING MY CAR DOWN AND WAS TOLD THEY'D BE WAITING FOR IT. LATER THAT DAY I RECEIVED A CALL FROM DON'S AUTOBODY TELLING ME THEY HAD MY CAR. I CONFIRMED WITH SF TOYOTA AND THEY SAID THEY SENT THE CAR THERE AND THE AUTO BODY WORK HAD TO BE DONE PRIOR TO A MECHANICAL INSPECTION. ON 4/15/13, I WAS INFORMED THE CAR HAD BEEN REPAIRED AND WAS SENT TO SF TOYOTA. I REPEATEDLY CALLED SF TOYOTA TO SEE IF THEY HAD FOUND ANY MECHANICAL DEFECTS. ON 4/16/13, I WAS CONTACTED BY DON'S AUTOBODY AND TOLD THAT TOYOTA REFUSED TO INSPECT THE CAR. SINCE WE DON'T KNOW IF THE CAR IS SAFE TO DRIVE, THE PERSON FROM THE AUTOBODY SHOP SUGGESTED WE CALL TOYOTA USA. TOYOTA USA OPENED A CASE AND HAS ENLISTED BILL FROM ENGINEERING ANALYTICS TO INSPECT THE CAR. BILL PLANS TO INSPECT THE CAR ON 4/30/13. HE WILL COLLECT DATA AND SEND IT TO TOYOTA. TOYOTA SAID THEY'LL REVIEW THE DATA AND WILL MAIL US THE RESULTS WITHIN 30 BUSINESS DAYS. WHEN WE EXPRESSED CONCERN THAT TOYOTA WAITED 6 WEEKS TO LOOK AT OUR CAR (WHICH THE AUTOBODY SAID THEY'VE DRIVEN), TOYOTA HAD NO COMMENT. *TR
NHTSA ODI #10509771
33,000 miles · Aug 3, 2012
Service BrakesCrash
AS I WAS DRIVING TRAFFIC CAME TO A SUDDEN STOP. I APPLIED THE BRAKES HARD, HOWEVER WAS NOT ABLE TO STOP BEFORE HITTING THE VEHICLE IN FRONT OF ME. AS PART OF THE NECESSARY VEHICLE REPAIRS AFTER THE ACCIDENT, TO GET THE BRAKES TO OPERATE AGAIN PROPERLY, THE BRAKE LOAD SENSOR - AN ELECTRIC SENSOR ON THE BRAKE PEDAL THAT FEEDS B…
Read full complaint
AS I WAS DRIVING TRAFFIC CAME TO A SUDDEN STOP. I APPLIED THE BRAKES HARD, HOWEVER WAS NOT ABLE TO STOP BEFORE HITTING THE VEHICLE IN FRONT OF ME. AS PART OF THE NECESSARY VEHICLE REPAIRS AFTER THE ACCIDENT, TO GET THE BRAKES TO OPERATE AGAIN PROPERLY, THE BRAKE LOAD SENSOR - AN ELECTRIC SENSOR ON THE BRAKE PEDAL THAT FEEDS BACK TO THE BRAKING COMPUTER SYSTEM HOW HARD BRAKES ARE BEING APPLIED WAS FOUND TO HAVE FAILED, PRESUMABLY AT THE TIME AS A RESULT OF THE IMPACT. THIS MALFUNCTION TRIPS A WARNING IN THE BRAKE SYSTEM, AND AFFECTS OPERABILITY OF THE BRAKES. RECENTLY ON JUNE 18, 2012 WHILE DRIVING ON A LOCAL STREET AT 25 MPH, A VEHICLE PASSED A STOP SIGN CROSSING IN FRONT OF ME NECESSITATING I BRAKE HARD TO AVOID AN ACCIDENT. WHILE AN ACCIDENT WAS AVOIDED, IMMEDIATELY FOLLOWING THIS A BRAKE MALFUNCTION WARNING CAME ON, AND THE BRAKE SYSTEM STOPPED OPERATING NORMALLY. THE DEALER FOUND THAT DUE TO THE HARD BRAKING, THE BRAKE PEDAL BECAME MISALIGNED, AND THE BRAKE LOAD SENSOR FAILED AGAIN. THIS PATTERN LEADS ME TO BELIEVE THAT IN INSTANCES OF HARD BRAKING, DAMAGE TO THE BRAKE PEDAL AND/OR LOAD SENSOR CAN OCCUR, CAUSING A LOSS OF BRAKE POWER POSSIBLY RESULTING IN AN ACCIDENT. *TR
NHTSA ODI #10469061
Official recalls
10Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration