2003 Toyota Highlander

THE ENGINE ON THIS VEHICLE REQUIRED A COMPLETE REBUILD, AT A COST OF OVER $5000 DUE TO OIL LEAKING INTO THE ENGINE AND FOULING THE COMPONENTS. IN THE MONTHS LEADING UP TO THE COMPLETE ENGINE FAILURE, THE VEHICLE STALLED REPEATEDLY ON BOTH CITY ROADS AND HIGHWAYS, CREATING A DANGEROUS SITUATION SEVERAL TIMES. WHENEVER THE OIL WAS CHANGED, THE PROBLEM BECAME WORSE AND THE VEHICLE WOULD USE UP TO 4 QUARTS OF OIL PER WEEK FOR SEVERAL WEEKS. I CONTACTED TOYOTA'S CORPORATE OFFICE BY LETTER AND PHONE AND WAS TOLD THAT NO DEFECT EXISTED. TOYOTA IS CURRENTLY RECALLING EARLIER MODELS OF THIS VEHICLE FOR THE SAME PROBLEM. THE VEHICLE WAS EMITTING WHITE SMOKE FROM THE TAILPIPE FOR SEVERAL MONTHS BEFORE THE ENGINE FAILED. EVENTUALLY, IT WOULD ONLY SUSTAIN A SPEED OF 30 MPH. THE VEHICLE WAS CHECKED BY THREE MECHANICS WHO ALL FOUND THE SAME PROBLEM. THIS VEHICLE IS USED TO TRANSPORT A HANDICAPPED PERSON, AND WAS ALSO USED TO TRANSPORT CHILDREN FREQUENTLY. IN ORDER TO SAVE THE MONEY FOR THE REPAIRS, WHICH I HAD TO MAKE BECAUSE I AM STILL MAKING PAYMENTS ON THE LOAN FOR THIS CAR, I HAD TO PURCHASE A VERY OLD AND INEXPENSIVE CAR TO GET TO WORK. THE TOYOTA SAT PARKED FOR 9 MONTHS BEFORE IT COULD BE FIXED. HAD I NOT BEEN ABLE TO BUY THIS SECOND CAR, I WOULD HAVE LOST MY JOB. I COULD NOT PUT MY DAUGHTER'S WHEELCHAIR IN THE OTHER CAR. SHE IS ABLE TO WALK ONLY FOR SHORT DISTANCES. THIS CREATED A SEVERE HARDSHIP AND ALSO CONTRIBUTED TO HER DEVELOPING A FOOT WOUND AND INFECTION OF THE BONE IN HER FOOT. THIS MEDICAL ISSUE REQUIRED 3 SURGERIES AND 5 HOSPITALIZATIONS, PLUS OVER 6 MONTHS OF IV ANTIBIOTIC THERAPY. I NARROWLY AVOIDED SEVERAL ACCIDENTS WHEN THE CAR STALLED IN TRAFFIC. IF I WAS NOT SUCH AN EXPERIENCED DRIVER, IT IS HIGHLY LIKELY THAT A SERIOUS ACCIDENT WOULD HAVE OCCURRED. *KB

UNUSUAL FRAYING OF DRIVERS SEAT BELT DUE TO DESIGN PROBLEM WITH STITCHING OF BELT MATERIAL. BEGAN TO UNRAVEL AND RUN ALONGSIDE APPROX 18" OF BELT LENGTH. THIS CAUSED BELT TO BIND AND SNAG ON BUCKLE FURTHER EXACERBATING PROBLEM. THIS OCCURRED DURING ROUTINE USE AND IS A COMMON PROBLEM ON THIS MODEL. TOYOTA DOES NOT WARRANTY SAFETY RESTRAINT DEVICES FOR THE LIFE OF THE VEHICLE LIKE OTHER SIMILAR MAJOR MANUFACTURERS (NISSAN, HONDA, MAZDA, ETC) AND DEALERSHIP STATED THAT THEIR WARRANTY WAS GOOD FOR 5 YR/60,000 MILES. THOUGH THE VEHICLE HAS LESS THAN 60,000 MILES, IT IS >5 YEARS AND THEREFORE NOT COVERED. TOYOTA CORPORATE DOES NOT SEEM CONCERNED ABOUT RECENT GLARING SAFETY CONCERNS RESULTING IN CONSUMER DEATHS (STICKING WOT ACCELERATORS, FAILING BRAKES, ETC) AND IS UNWILLING TO COVER ANY PORTION OF THE ESTIMATED $450 REPAIR. I WOULD LIKE TO DOCUMENT THIS DEFECT WHICH IS EXTENSIVELY REPORTED ON THE INTERNET BY OTHER CONSUMERS IN HOPES THAT TOYOTA COULD BE FORCED TO CORRECT THIS SERIOUS SAFETY ISSUE BEFORE MORE DEATHS OCCUR. *TR

TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE HEAD BOLT DETACHED FROM THE ENGINE BLOCK WHILE DRIVING 65 MPH. THE VEHICLE BEGAN RUNNING HOT AND WATER WAS LEAKING FROM THE BACK OF THE ENGINE. THE VEHICLE WAS TAKEN TO A MECHANIC WHO INSPECTED THE VEHICLE AND ADVISED THAT THE HEAD BOLT WAS STRIPPED FROM THE ENGINE BLOCK. THE MECHANIC ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT YET TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 189,000.

TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE PARKED, THE CONTACT NOTICED THAT THE DRIVER SIDE BRAKE LIGHT WOULD NOT FUNCTION WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT TAKEN TO DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE CONSUMER STATED THE DRIVER SIDE BRAKE LIGHT BULBS INTERMITTENTLY FAILED. UPDATED 12/12/11

TL*THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH THE VEHICLE STARTED TO OVERHEAT. SHE DROVE ONTO THE EMERGENCY LANE AND WAITED FOR THE VEHICLE TO COOL OFF. THE VEHICLE WAS THEN INSPECTED BY A INDEPENDENT MECHANIC WHO ADVISED HER THAT THE ENGINE BOLT WAS STRIPPED AND CAUSED THE COOLANT TO LEAK ONTO THE ENGINE. THE MECHANIC ALSO STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 111,400.