Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports1 fire reports10 injury reports

Structure complaints

18 reports

Clear category filter

36,100 miles · Jan 19, 2005

Structure

PAINFUL, DRUMMING NOISE WHEN REAR WINDOWS ARE OPEN. SEVERE VIBRATION WHEN IN DRIVE AT FULL STOP WITH BRAKE. *NM

NHTSA ODI #10107550

100 miles · Apr 25, 2004

Structure

Read full complaint

TOYOTA HIGHLANDER: WITH ONE REAR WINDOW ROLLED DOWN, SLIGHTLY, THERE IS VERY PAINFULL NOISE THAT IS ALMOST UNBEARABLE WHILE DRIVING AT CITY SPEEDS (30-45 MPH). MANF. STATES THAT THIS IS COMMON IN SOME VEHICLES. IN THIS ONE IT IS BECAUSE THE VEHICLE IS SO TIGHTLE SEALED THERE IS NO PLACE FOR THE AIR TO GO THUS CREATING A PRESSURE DIFFERENCE. NOTICED ON 2ND ADAY AFTER DELIVERY. DEALER FAILED TO PROVIDE US WITH INFO ABOUT THIS PROBLEM. IN FACT THEY CLAIMED IF WAS THE FIRST THEY HAD HEARD ABOUT THIS PROBLEM. NOW AFTER 10 MONTHS I WAS DRIVING ON THE INTERSTATE AT 65 MPH, WITH ALL THE WINDOWS SLIGHLTY DOWN AND THE PROBLEM IS WORSE THANEVER. THIS IS A DESIN FLAW THAT TOYOTA HAS FAILED TO CORRECT. THIS GOING TO THE LAST TOYOTA OUR FAMILY WILL PURCHASE!!! CARL783@JUNO.COM. *AK

NHTSA ODI #10067794

Mileage unknown · Dec 1, 2003

Structure

Read full complaint

UNABLE TO DRIVE THE VEHICLE WITH WINDOWS ROLLED DOWN. AS NOTED IN SEVERAL OTHER COMPLAINTS THIS VEHICLE IS COMPLETELY NON-DRIVABLE WITH WINDOWS ROLLED DOWN. THIS FACT IS NEVER MENTIONED TO ANY CUSTOMERS AT THE TIME OF PURCHASE. I FEEL THAT IF ANYONE BUYING A VEHICLE FOR MORE THAN 30K SHOULD HAVE ACCESS TO ANY SUCH DESIGN FLAW. EVEN WHEN ASKING THE DEALER, LATER ON, THE RESPONSE WAS THAT THIS IS A DESIGN PROBLEM. TOYOTA NEEDS TO CAREFULLY LOOK INTO THIS AS WITH WINDOWS ROLLED DOWN ON FREEWAY SPEEDS, IT CREATES ALMOST A LOW PRESSURE ENV WITHIN THE VEHICLE WITH EAR-ACHES FOR ALL PASSENGERS.*AK

NHTSA ODI #10048959

178 miles · Oct 7, 2003

Structure

WITH REAR WINDOWS LOWERED A DEAFENING BUFFETING VIBRATION OCCURS FROM THE AFT CARGO COMPARTMENT. WHEN THE SPEED IS INCREASED, THE BUFFETING INCREASES TO AN UNBEARABLE LEVEL. DEALER DID NOT DISCLOSE THIS INFORMATION PRIOR TO PURCHASE. *JB

NHTSA ODI #10041380

25 miles · Jul 30, 2003

Structure

Read full complaint

I PICKED UP CAR AT THE DEALER AND THE SAME EVENING ROLLED THE REAR WINDOWS DOWN SLIGHTLY AND THE RESULT WAS A PAINFUL PULSATING PRESSURE THAT ALMOST CAUSED MY WIFE TO GO OFF THE ROAD. THIS IS WELL DOCUMENTED SINCE 2001 AND TOYOTA HAD AN OPPORTUNITY AT THAT POINT TO RECTIFY THE SITUATION IMMEDIATELY. THE DEALER SAID IT WAS THE FIRST HE EVER HEARD OF THE PROBLEM. TOYOTA RECOGNIZES THE PHENOMENON AND FAXED ME ARBITRATION PAPERS WHICH I FILED AND WAS DENIED BECAUSE IT IS "A DESIGN ISSUE" NOT COVERED UNDER WARRANT". I WILL NOT DRIVE AN UNSAFE VEHICLE AND WOULD APRECIATE THE ASSISTANCE OF THE NHTSA IN ORDER TO PREVENT NON-DISCLOSURE OF A SERIOUS DESIGN FLAW THAT IS UNSAFE AND HARMFUL TO THE EARS. *AK

NHTSA ODI #10030400

3,000 miles · Apr 11, 2003

Structure

WHEN THE DRIVER'S WINDOW WAS DOWN, A LOUD WHISTLING NOISE WAS HEARD. *JB

NHTSA ODI #10015709

Mileage unknown · Mar 25, 2003

Structure

WIND NOISE INSIDE VEHICLE WITH WINDOWS OPEN MAKES A DRUMMING NOISE THAT BORDERS ON BEING PAINFUL AT ANY SPEED OVER 30 MPH. OPENING ONE OF THE FRONT WINDOWS LESSENS THE NOISE BUT DOES NOT ELIMINATE IT. IT IS VIRTUALLY IMPOSSIBLE TO DRIVE THE CAR WITH ONE OR MORE WINDOWS OPEN.

NHTSA ODI #10010990

193 miles · Mar 13, 2003

Structure

PASSENGER SIDE DOORS (FRONT & BACK) BECOME OFF BALANCED. THEN THE DOORS HAVE TO BE CLOSED VERY HARD. *JB

NHTSA ODI #10010386

Official recalls

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

02V339000 · Wheels

Dec 17, 2002

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.

Consequence & remedy

Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.

Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.