IllustrationHEAD ON COLLISION AIR BAGS DID NOT DEPLOY SPEEDS 25-40 MPH
2003 Toyota Highlander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Toyota Highlander do not stand out strongly from the model-year median of 186.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Highlander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
360–25K
1525–50K
3150–75K
3875–100K
74100–150K
19150K+
213 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports1 fire reports10 injury reports
Air Bags complaints
9 reportsI WAS IN MOTION WHEN WE HIT A COW GOING 45MPH THAT JUMPED OUT AT MY HUSBAND AND I MY AIR BAGS DID NOT DEPLOY THE CAR IS TOTALED WAS CITY STREET
TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT FELT LIGHTHEADED AND CRASHED INTO A LIGHT POLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS LATER TAKEN TO AN INSURANCE LO…
Read full complaint
TL* THE CONTACT OWNS A 2003 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT FELT LIGHTHEADED AND CRASHED INTO A LIGHT POLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS LATER TAKEN TO AN INSURANCE LOT WHERE THE VEHICLE WAS REPAIRED FOR THE BODY DAMAGE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE AIR BAG FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
TL* THE CONTACT OWNED A 2003 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS IN REVERSE, IT ACCELERATED INDEPENDENTLY. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO EFFECTIVELY SLOW DOWN THE VEHICLE. THE GEAR SHIFTER BUTTON WAS PUSHED INTO DRIVE AND THE VEHICLE SPED FORWARD AND CRASHED INTO A TREE. THE AIR BAGS F…
Read full complaint
TL* THE CONTACT OWNED A 2003 TOYOTA HIGHLANDER. WHILE THE VEHICLE WAS IN REVERSE, IT ACCELERATED INDEPENDENTLY. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO EFFECTIVELY SLOW DOWN THE VEHICLE. THE GEAR SHIFTER BUTTON WAS PUSHED INTO DRIVE AND THE VEHICLE SPED FORWARD AND CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE FAILURE RECURRED TWICE PRIOR TO THE CRASH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. THE VEHICLE WAS DESTROYED. *JS
DURING A WRECK AIRBAGS DID NOT DEPLOY WHEN I HIT AN UNMARKED UTILITY POLE IN THE ROADWAY OF A PARKING LOT EXIT.
IN VERY COLD MAINE TEMPERATURES, AFTER THE VEHICLE HAS SET UNUSED ALL NIGHT, THE AIRBAG WARNING LIGHT COMES ON IN THE MORNING WHEN THE VEHICLE IS STARTED. THIS ALSO HAPPENS IN VERY WARM TEMPERATURES AFTER VEHICLE HAS SET UNUSED ALL NIGHT. AFTER THE VEHICLE HAS RUN A SHORT WHILE AND WARMED UP OR COOLED DOWN, THE AIRBAG SIGNAL WA…
Read full complaint
IN VERY COLD MAINE TEMPERATURES, AFTER THE VEHICLE HAS SET UNUSED ALL NIGHT, THE AIRBAG WARNING LIGHT COMES ON IN THE MORNING WHEN THE VEHICLE IS STARTED. THIS ALSO HAPPENS IN VERY WARM TEMPERATURES AFTER VEHICLE HAS SET UNUSED ALL NIGHT. AFTER THE VEHICLE HAS RUN A SHORT WHILE AND WARMED UP OR COOLED DOWN, THE AIRBAG SIGNAL WARNING GOES OFF.
I PURCHASED MY VEHICLE IN 2003 IN CALIFORNIA. IN 2005 I MOVED TO NORTH PORT, FLORIDA. I HAVE SEEN ON THE MEDIA THAT IF I LIVE IN A HUMID AREA, MY AIR BAGS ARE UNSAFE. I WENT TO WWW.SAFERCAR.GOV AND ENTERED MY VIN# I WAS TOLD MY CAR HAS "NO RECALLS". *TR
DT*: THE CONSUMER HIT A PATCH OF BLACK ICE TRAVELING AT 45 MPH WHEN APPROACHING A STOP SIGN; THE VEHICLE PROCEEDED THROUGH A STOP SIGN STRIKING ANOTHER VEHICLE IN THE PASSENGER SIDE. THE AIRBAGS DID NOT DEPLOY. THE PRE-BRAKING WAS MINIMAL DUE TO THE ICY ROAD CONDITIONS. BOTH OCCUPANTS OF THE VEHICLE WERE WEARING SEAT BELTS AN…
Read full complaint
DT*: THE CONSUMER HIT A PATCH OF BLACK ICE TRAVELING AT 45 MPH WHEN APPROACHING A STOP SIGN; THE VEHICLE PROCEEDED THROUGH A STOP SIGN STRIKING ANOTHER VEHICLE IN THE PASSENGER SIDE. THE AIRBAGS DID NOT DEPLOY. THE PRE-BRAKING WAS MINIMAL DUE TO THE ICY ROAD CONDITIONS. BOTH OCCUPANTS OF THE VEHICLE WERE WEARING SEAT BELTS AND SUSTAINED MINOR INJURIES. POLICE WERE ON THE SCENE AND A REPORT WAS TAKEN. THE VEHICLE SUSTAINED EXTENSIVE DAMAGE, BUT WAS NOT TOTALED DUE TO ASSESSMENT OF THE INSURANCE ADJUSTOR AND THE LACK OF AIRBAG DEPLOYMENT. PRIOR TO THE ACCIDENT, THE AIRBAG WARNING LIGHT ILLUMINATED IN COLD TEMPERATURES, BUT THE VEHICLE WAS NOT SEEN BY A DEALER FOR THIS PROBLEM. *JB PRIOR TO THE ACCIDENT, THE REAR BRAKES AND ROTORS WERE REPLACED. UPDATED 03/03/06. *JB UPDATED
AIR BAG COMPUTER SYSTEM HAD A DEFECT THAT CAUSED THE AIR BAG WARNING LIGHT TO COME ON, AND THE SYSTEM TO MALFUNCTION. DEALERSHIP INDICATED THAT AIR BAG WOULD NOT DEPLOY IN AN ACCIDENT. THE DEALERSHIP REPLACED THE COMPUTER SYSTEM.*AK
Official recalls
204V181000 · Latches/locks/linkages:doors:latch
Apr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
02V339000 · Wheels
Dec 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
Consequence & remedy
Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.