NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
31 reportsClear category filterMileage unknown · Mar 13, 2026
EngineFuel/propulsion SystemUnknown Or Other
Error message that said 'drive start control malfunction. Took 6 mos and numerous attempts to resolve. Replaced numerous parts including the fuel pump because the plastic it's made out of was just disintegrating and and cracking. This has cost thousands of dollars in parts and labor. Also getting a msg on info screen 'connect…
Read full complaint
Error message that said 'drive start control malfunction. Took 6 mos and numerous attempts to resolve. Replaced numerous parts including the fuel pump because the plastic it's made out of was just disintegrating and and cracking. This has cost thousands of dollars in parts and labor. Also getting a msg on info screen 'connected device not supported' now. Apparently toyota did an update and there was a bug in the program yet I have to pay to fix their error to the dcm.
NHTSA ODI #11724036
Mileage unknown · Aug 28, 2025
Air BagsFuel/propulsion System
I had recalls “repaired”, but my airbags do not work and Bob Howard Toyota told me that they work and that they only check the sensor to make sure the sensor works. My fuel pump was was supposedly replaced but I still experience issues such as stuttering, slight stalling, engine is working harder to produce normal speeds, fuel e…
Read full complaint
I had recalls “repaired”, but my airbags do not work and Bob Howard Toyota told me that they work and that they only check the sensor to make sure the sensor works. My fuel pump was was supposedly replaced but I still experience issues such as stuttering, slight stalling, engine is working harder to produce normal speeds, fuel economy has depleted and I’m loosing 194 mpg after each fuel up. There are no lights on, but I have a code reader that pulls in two issues. I reported to Toyota’s customer service and because they put in the system everything is okay they were unable to do anything.
NHTSA ODI #11683795
Mileage unknown · Aug 17, 2025
EngineFuel/propulsion SystemPower Train
I have a 2019 Toyota Corolla Hatchback. The problems started on July 21st, 2025. While driving my 2019 Toyota Corolla Hatchback, I noted white exhaust smoke, even after the engine was warm. One week prior, I had filled the coolant reservoir, but when I checked it, the coolant was almost gone again. There were no visible leaks or…
Read full complaint
I have a 2019 Toyota Corolla Hatchback. The problems started on July 21st, 2025. While driving my 2019 Toyota Corolla Hatchback, I noted white exhaust smoke, even after the engine was warm. One week prior, I had filled the coolant reservoir, but when I checked it, the coolant was almost gone again. There were no visible leaks or puddles under the car. I refilled the coolant, but within days the car began shaking severely upon startup and emitted a coolant-burning smell. 5 minutes after, multiple warning lights illuminated on the dashboard simultaneously. I replaced the car battery, and the warnings disappeared. However, while merging onto the freeway, the same warning lights came back, the car lost power, and I could not accelerate above ~25 mph. If this occurred in heavy traffic, it could lead to a serious collision. I exited the freeway and had the car towed. DTCs from the independent mechanic and the Toyota dealer included: P11ED00 P030085 P030027 P030200 (Cylinder 2 misfire) C142571 (Stop light relay actuator stuck) U1117 B2284 B15AD The Toyota dealer identified a “Port Injector #2 malfunction” and recommended replacing all four injectors (~$2,000) but could not confirm this would fix it. They noted a coolant-burning smell but advised addressing the misfire first before further diagnosis. There is an active class action lawsuit alleging that 2019–2023 Toyota Corolla and RAV4 models have defective coolant bypass valves that may cause engine issues, overheating, or coolant loss without visible leaks. This matches the coolant loss, white exhaust smoke, and eventual power loss while driving. I request that NHTSA investigate this issue in connection to the reported coolant bypass valve defects affecting 2019–2023 Toyota Corolla models.
NHTSA ODI #11681200
Mileage unknown · Aug 13, 2025
EngineFuel/propulsion System
While driving my 2019 Toyota Corolla Hatchback XSE, I lost almost all power to my accelerator and a check engine light appeared on my dash. I came to a stop and stalled the vehicle, once it stalled I turned the engine back on and shifted into reverse a felt and heard a loud clunk noise coming from right under my car and its not …
Read full complaint
While driving my 2019 Toyota Corolla Hatchback XSE, I lost almost all power to my accelerator and a check engine light appeared on my dash. I came to a stop and stalled the vehicle, once it stalled I turned the engine back on and shifted into reverse a felt and heard a loud clunk noise coming from right under my car and its not only shifting into reverse is the loud noise active but its also shifting into drive from reverse. I scanned my vehicle with a aftermarket scan tool and got 2 exact same codes for "Torque Converter Clutch Pressure Control Solenoid Control Circuit Performance/Stuck Off" and then two more codes for "Torque Converter Clutch Pressure Control Solenoid Control Actuator Stuck On". My torque converter in my CTV transmission failed. I was not at a risk of putting other people or myself in danger but if would have if i was moving faster at the time this happened. I have done my research on the recalls that are active on this vehicle and on the Toyota OEM TIS website there is only 1 recall that was taken care of in 2021 for the fuel pump and then there is a Warranty Enhancement Program for the Flow Shut-off Valve Coolant Leak. I did not find anything on that Toyota TIS website about the CVT recall but when i search my year, make and model on the web, I see that there is a recall for about 3,400 vehicles in the USA and nearly 1,000 in Canada that have a active recall for the CTV. I also saw the recall consequence and it matches up with what happened with my Corolla. I have attempted to contact 5 difference Toyota dealerships in my state to have them help me figure out the issue I am having with my vehicle not being listed in the recall but my CTV just failed. No one has reached back out in the past two days and I am continuing to call almost 3 times a day. I would like some clarity on how I should go about handling this issue.
NHTSA ODI #11680495
Mileage unknown · Apr 30, 2025
Fuel/propulsion System
My vehicle has a production date that falls within an existing safety recall J07 but Toyota is denying coverage. The cvt is making a grinding noise consistent with the torque converter issue described in the recall and my door has a stamp with being produced in 10/2018 when this recall was in effect. However they are denying c…
Read full complaint
My vehicle has a production date that falls within an existing safety recall J07 but Toyota is denying coverage. The cvt is making a grinding noise consistent with the torque converter issue described in the recall and my door has a stamp with being produced in 10/2018 when this recall was in effect. However they are denying coverage.
NHTSA ODI #11657867
Mileage unknown · Jan 24, 2025
Air BagsFuel/propulsion SystemUnknown Or OtherCrash
UNKNOWN The vehicle stalled mid turn as I was turning left, my wheel locked up and brakes wouldn’t engage.
NHTSA ODI #11638180
Mileage unknown · Dec 16, 2024
Fuel/propulsion System
2 years ago, I took my vehicle to the dealership that I bought it from, because I was given notice that there was a recall to the fuel injector system, and my scheduled maintenance was due. The dealership performed the maintenance and fixed the recall, and I drove the car home. The very next day I started the car and noticed tha…
Read full complaint
2 years ago, I took my vehicle to the dealership that I bought it from, because I was given notice that there was a recall to the fuel injector system, and my scheduled maintenance was due. The dealership performed the maintenance and fixed the recall, and I drove the car home. The very next day I started the car and noticed that it took 2 key turns to start and didn't think too much about it. Since then, I've put 5000 more miles on the car so the odometer now says 23000 miles. Today I take my vehicle in for maintenance because I want to resolve the 2 key turn issue, and now the dealership says that my fuel injector is broken and I need to pay for the part and labor to replace. I don't understand how the fuel injector being physically damaged is something that I as the customer could have done in 5000 miles, unless the dealer made a mistake when fixing the recall.
NHTSA ODI #11631057
Mileage unknown · Aug 29, 2024
EngineFuel/propulsion SystemVehicle Speed Control
At around 36,500 miles, my Toyota Corolla began experiencing issues with the coolant bypass valve, leading to engine overheating. This malfunction has significantly impacted my ability to drive safely, as the vehicle displays a notification every five seconds, obstructing my view of the digital speedometer and making it difficul…
Read full complaint
At around 36,500 miles, my Toyota Corolla began experiencing issues with the coolant bypass valve, leading to engine overheating. This malfunction has significantly impacted my ability to drive safely, as the vehicle displays a notification every five seconds, obstructing my view of the digital speedometer and making it difficult to accurately monitor my speed. The issue was not indicated by a check engine light but a persistent "Engine Maintenance Required" message. This defect poses a serious safety risk, and there's a potential class-action lawsuit in progress regarding this very issue, suggesting Toyota might have known about the defect but failed to disclose it. The faulty component is not available for inspection upon request. As more people began to experience similar circumstances, it could lead to fatalities. Other participants to the forums says the issues start when their covered warranty expires. Within these forums there's a inconstancy of service centers honoring fixes, with no cost, knowing that there is an issue. I took the car to both a third-party mechanic and an authorized dealership, and both confirmed the problem. I was quoted $732.85 for the parts and labor within my area. I also called Toyota Global which I was told "a low mileage car shouldn't be having this issue", however, there are countless of forums saying otherwise. **Toyota Models Affected** 2019 Toyota RAV4 2020 Toyota RAV4 2021 Toyota RAV4 2022 Toyota RAV4 2023 Toyota RAV4 2019 Toyota Corolla 2020 Toyota Corolla 2021 Toyota Corolla 2022 Toyota Corolla 2023 Toyota Corolla [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11611677
Mileage unknown · Jun 22, 2024
Fuel/propulsion System
we took our corolla to the San Luis Obispo toyota dealership for replacement of fuel pump per national recall of that part. Since then whenever we park the car on an incline we can strongly smell gas fumes in the cabin. When we took it back stating the problem they took it in but did not touch anything on the car (there were i…
Read full complaint
we took our corolla to the San Luis Obispo toyota dealership for replacement of fuel pump per national recall of that part. Since then whenever we park the car on an incline we can strongly smell gas fumes in the cabin. When we took it back stating the problem they took it in but did not touch anything on the car (there were items on the back seat they would need to remove I order to get to the gas tank that contains the fuel pump.) When we went in the invoice was marked "call after five" in pencil
NHTSA ODI #11595930
Mileage unknown · Oct 29, 2023
Fuel/propulsion System
Vehicle has a bank to lean 1 engine code and when at idle, fluctuates from 700 rpm down below 500 RPM and shakes the car. The vehicle has stalled twice on me while stopped at a stop light. I understand the vehicle has had two recalls for the same issue and it has not fixed the problem yet.
NHTSA ODI #11552515
Official recalls
5Jan 17, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2011-2019 Corolla, 2011-2013 Matrix, 2012-2018 Avalon, and 2013-2018 Avalon Hybrid vehicles. During certain crashes, the air bag electronic control unit (ECU) may malfunction, possibly disabling the deployment of the air bags and/or seat belt pretensioners.
Consequence & remedy
Consequence: In the event of a crash, air bags and/or seat belt pretensioners that do not deploy as intended may increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will inspect the ECU and install a noise filter between the air bag control module and its wire harness, as necessary, free of charge. Owners were notified of the safety risk beginning March 2, 2020. A second letter notifying owners of the remedy repair will be mailed between March 16, 2020 and June 27, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are 20TB03, 20TA03 and 20TA05.
Jan 13, 2020
Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Mar 27, 2019
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Dec 19, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Toyota Corolla hatchback vehicles equipped with Continuously Variable Transmissions (CVT). The pump impeller blades within the torque converter may detach, especially when driven under high load, potentially causing a vehicle stall.
Consequence & remedy
Consequence: A vehicle stall, especially when driving a high rate of speed, can increase the risk of a crash.
Remedy: Toyota has notified owners, and dealers will replace the CVT and torque converter, free of charge. The recall began April 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J17/J07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
Illustration