NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,459 reports31,082 miles · Mar 19, 2012
Service Brakes, Air
2009 TOYOTA COROLLA - JAPANESE BUILT ABS/BRAKE WARNING LIGHTS AT APPROXIMATELY 31,000 MILES. 1. DIAGNOSTIC COMPUTER INDICATES TROUBLE CODES C0210 (SPEED SENSOR FAILURE) AND C1238 (PLUG TO RIGHT REAR WHEEL ASSEMBLY). PLUG TO ABS SENSOR AND TERMINAL REPAIR KIT WORK AT 32, 126 MILES. 2. 2ND DIAGNOSTIC COMPUTER READING I…
Read full complaint
2009 TOYOTA COROLLA - JAPANESE BUILT ABS/BRAKE WARNING LIGHTS AT APPROXIMATELY 31,000 MILES. 1. DIAGNOSTIC COMPUTER INDICATES TROUBLE CODES C0210 (SPEED SENSOR FAILURE) AND C1238 (PLUG TO RIGHT REAR WHEEL ASSEMBLY). PLUG TO ABS SENSOR AND TERMINAL REPAIR KIT WORK AT 32, 126 MILES. 2. 2ND DIAGNOSTIC COMPUTER READING INDICATES "INACTIVITY WITH LEFT REAR ABS SENSOR". ABS/BRAKE WARNING LIGHTS AGAIN . IN ADDITION, LIGHTS ARE NOW ACCOMPANIED BY FREQUENT LOUD NOISES IN THE ENGINE COMPARTMENT, SIGNIFICANT VIBRATION THOUGH THE BRAKE PEDAL, MOMENTARY PARTIAL BRAKE FAILURE. 3. RETURN FOR 3RD INSPECTION OF BOTH LEFT/RIGHT REAR WHEEL HUB ASSEMBLIES. MECHANICS AGAIN REINSPECT, CLEAN AND APPLY ELECTRIC GREASE TO BOTH REAR ABS SENSORS AND ROAD TEST THE VEHICLE. SAME ISSUES REAPPEAR AFTER ONLY FEW MILES OF 3RD REPAIR. MECHANICS NOW DETERMINE THERE IS TOO MUCH CORROSION IN THE RIGHT REAR ABS SPEED SENSOR CONNECTION IN THE RIGHT REAR WHEEL HUB ASSEMBLY FOR THE ABS SPEED SENSOR PLUG TO CONNECT SECURELY AND THE RIGHT REAR WHEEL ASSEMBLY MUST BE REPLACED. THIS IS AN EXPENSIVE PART AT $372-$443 RETAIL PLUS LABOR FOR EITHER JAPANESE/NORTH AMERICAN BUILT COROLLAS. THE ACCOMPANYING LOUD NOISE IN THE ENGINE COMPARTMENT HAS BEEN DETERMINED TO BE THE SEPARATE BUT ASSOCIATED ABS MODULE WITHIN THE ENGINE COMPARTMENT. THE DEFECTIVE ABS SPEED SENSOR/REAR WHEEL HUB ASSEMBLY IN THE RIGHT REAR WHEEL CAUSES INCORRECT READINGS BY THE ABS MODULE IN THE ENGINE COMPARTMENT, INCORRECTLY ASSUMING THERE IS WHEEL SLIPPAGE AT CERTAIN WHEELS AND "CAUSING THE ABS MODULE TO GO HAYWIRE" IN ATTEMPTS TO CORRECT WHAT IT THINKS IS WHEEL SLIPPAGE. THIS APPEARS TO BE A COMMON DEFECT SINCE SIMILAR COMPLAINTS HAVE BEEN FILED; SEE "CONSUMER COMPLAINTS/ODI CASE NUMBERS 10381428 (2/10/11) AND 10320698 (3/18/10). *JS
NHTSA ODI #10452215
52,000 miles · Mar 12, 2012
SteeringCrash
WHILE MAKING A LEFT TURN YESTERDAY,MY STEERING WHEEL STARTED SHIFTING SO HARD THAT MADE ME LOSE CONTROL OF THE CAR, CAUSING ME TO SPIN AND HIT ANOTHER CAR ALSO TURNING LEFT.I WAS DRIVING WITH CAUTION, ESPECIALLY BECAUSE IT HAD BEEN PREVIOUSLY RAINING,BUT THE WORST PART IS THAT IT'S NOT THE FIRST TIME THIS HAS HAPPENED TO ME.I RE…
Read full complaint
WHILE MAKING A LEFT TURN YESTERDAY,MY STEERING WHEEL STARTED SHIFTING SO HARD THAT MADE ME LOSE CONTROL OF THE CAR, CAUSING ME TO SPIN AND HIT ANOTHER CAR ALSO TURNING LEFT.I WAS DRIVING WITH CAUTION, ESPECIALLY BECAUSE IT HAD BEEN PREVIOUSLY RAINING,BUT THE WORST PART IS THAT IT'S NOT THE FIRST TIME THIS HAS HAPPENED TO ME.I REPORTED ANOTHER ACCIDENT IN 2010 CAUSED BY THE SAME FAILED COMPONENT.I WAS DRIVING ON A STRAIGHT LANE WHILE RAINING AND ALL OF THE SUDDEN MY STEERING WHEEL LOST CONTROL AND MY CAR SPAN 2 TIMES,MAKING ME END ON A DITCH. THANKS GOD THE ROAD WAS CLEAR, SO MY CAR DIDN'T HIT ANY OTHER CAR;HOWEVER, THIS HAS BEEN THE MOST TERRIFYING EXPERIENCE OF MY LIFE!; IT LEFT ME WITH A TRAUMA THAT WAS WITH ME FOR OVER A YEAR. IT MADE ME TERRIFIED OF DRIVING THIS CAR, ESPECIALLY UNDER RAINING CONDITIONS. AFTER THAT I BOUGHT NEW TIRES,THEN TOOK IT TO TOYOTA TO GET CHECKED.THEY SAID THE STEERING WAS IN FACT SHIFTING, AND THAT THE COMPUTER THAT CONTROLS IT WASN'T WORKING CORRECTLY, SO THEY REPLACED IT.I FELT MORE SECURE AFTERWARDS,SO I DROVE MY CAR NORMALLY, STILL FEELING THE SHIFT UNDER WINDY CONDITIONS,BLAMING IT ON THE WIND FOR NOT FEELING TERRIFIED ANYMORE..UNTIL YESTERDAY!THIS TIME CAUSING ME TO CRASH ONTO ANOTHER CAR!NOW I'M SCARED TO DEATH TO DRIVE MY CAR, AND HAVE TO LOSE TIME, STRESS AND AGGRAVATION ON SOMETHING THAT SHOULD'VE BEEN A RECALL YEARS AGO! IT IS RIDICULOUS THAT AFTER HAVING THE POWER TO FORCE ANY COMPANY WHO'S NOT FOLLOWING SECURITY REGULATIONS,THE NHTSA IS STILL NOT CENSURING TOYOTA WHO CLAIMS SO STRONGLY "SECURITY FIRST".HOW MANY WRECKS, INJURIES AND DEATHS NEED TO OCCUR FOR NHTSA TO REALIZE THIS AS A MAJOR SAFETY ISSUE BECAUSE IT AFFECTS THE DRIVER IN SUCH AN ABRUPT MANNER! SOMETHING NEEDS TO BE DONE NOW! GOD FORBIDS, THIS HAPPENS AGAIN AND I'LL MAKE SURE ALL ORGANIZATIONS/CORPORATIONS INVOLVED GET SUED FOR NOT TAKING DRASTIC MEASURES. *TR
NHTSA ODI #10451313
25,000 miles · Mar 5, 2012
Air BagsVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS TRAVELING 5 MPH WHEN THE VEHICLE SUDDENLY SURGED FORWARD WITHOUT WARNING, CAUSING THE CONTACT TO CRASH INTO THE REAR OF A PRECEDING VEHICLE. THE CONTACT SUFFERED INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 28,000 AND THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS TRAVELING 5 MPH WHEN THE VEHICLE SUDDENLY SURGED FORWARD WITHOUT WARNING, CAUSING THE CONTACT TO CRASH INTO THE REAR OF A PRECEDING VEHICLE. THE CONTACT SUFFERED INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 28,000 AND THE FAILURE MILEAGE WAS 25,000. UPDATED 03/22/12 *BF THE CONSUMER ALSO STATED THE AIR BAG FAILED TO DEPLOY. UPDATED 05/11/12 UPDATED 5/12/2012 *JS
NHTSA ODI #10450308
110,000 miles · Mar 4, 2012
Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control
I HAVE HAD THIS COROLLA FOR ABOUT 3 YEARS, AVERAGE ABOUT 700 MILES PER WEEK - DRIVE IT DAILY. I HAVE HAD NO SIGNIFICANT ISSUES WITH IT UNTIL THE PAST MONTH OR SO IN WHICH I HAVE EXPERIENCED TWO "SUDDEN ACCELERATION" EVENTS. IN BOTH CASES I WAS TRAVELING AT A VERY LOW SPEED, ABOUT 10 MPH OR SO IN PARKING LOTS. WHILE COASTING /…
Read full complaint
I HAVE HAD THIS COROLLA FOR ABOUT 3 YEARS, AVERAGE ABOUT 700 MILES PER WEEK - DRIVE IT DAILY. I HAVE HAD NO SIGNIFICANT ISSUES WITH IT UNTIL THE PAST MONTH OR SO IN WHICH I HAVE EXPERIENCED TWO "SUDDEN ACCELERATION" EVENTS. IN BOTH CASES I WAS TRAVELING AT A VERY LOW SPEED, ABOUT 10 MPH OR SO IN PARKING LOTS. WHILE COASTING / BRAKING WITH MY FOOT ON THE BRAKE PEDAL, SUDDENLY IT WAS AS IF THE BRAKE PEDAL TURNED INTO AN ACCELERATOR PEDAL! I FELT ALL OF THE BACK-PRESSURE THE BRAKE PEDAL NORMALLY HAS LEAVE AND IT WENT ALMOST COMPLETELY DOWN TO THE FLOOR. AT THE VERY SAME INSTANT THE ENGINE REVVED AND BEGAN TO ACCELERATE AND THE CAR "LEAPED" FORWARD. IN BOTH CASES THIS LASTED ONLY A FEW SECONDS THEN THINGS WENT BACK TO NORMAL. THERE WERE NO INDICATOR LIGHTS ON THE PANEL WARNING OF ANYTHING WRONG. IN BOTH CASES MY FOOT WAS CLEARLY ON THE BRAKE PEDAL AND NOWHERE NEAR THE ACCELERATOR PEDAL. I VISUALLY INSPECTED THE FLOOR MAT AND THERE WAS ABSOLUTELY NO INTERFERENCE BETWEEN IT AND THE ACCELERATOR PEDAL. THIS CAR HAS ALREADY HAD ALL OF TOYOTA'S "RECALL" REMEDIES APPLIED TO IT AND COULD BE EASILY ASCERTAINED BY EXAMINING THE MAINTENANCE RECORDS AT BUTLER TOYOTA OF MACON, GEORGIA. I WOULD LIKE IT IF SOMEONE COULD EXAMINE THE CAR'S COMPUTER (NOT THE TOYOTA PEOPLE FOR OBVIOUS REASONS)TO SEE IF THESE EVENTS WERE RECORDED OR NOT. UNTIL NOW I HAVE LIKED THIS CAR VERY MUCH IN EVERY WAY. HOWEVER, CONSIDERING ALL OF THE RECENT REPORTS AND NOW MY PERSONAL EXPERIENCES TWICE I AM VERY MUCH CONCERNED ABOUT THE CAR'S SAFETY. *TR
NHTSA ODI #10450183
40,500 miles · Feb 29, 2012
Steering
WHEN CAR IS DRIVEN AT HIGHWAY SPEEDS, 70-75 MPH, STEERING PULLS LEFT AND RIGHT RAPIDLY, CAUSING CAR TO BECOME VERY UNSTABLE IN HANDLING. SEEMS TO DRIFT IN ITS LANE. WHEN DRIVING IT IS VERY UNPREDICTABLE. I JUST PURCHASED THIS VEHICLE USED AND BECAME AWARE OF IT. NO ACCIDENT ISSUES ONLY 40,000 MILES CONTACTED TOYOTA DEALE…
Read full complaint
WHEN CAR IS DRIVEN AT HIGHWAY SPEEDS, 70-75 MPH, STEERING PULLS LEFT AND RIGHT RAPIDLY, CAUSING CAR TO BECOME VERY UNSTABLE IN HANDLING. SEEMS TO DRIFT IN ITS LANE. WHEN DRIVING IT IS VERY UNPREDICTABLE. I JUST PURCHASED THIS VEHICLE USED AND BECAME AWARE OF IT. NO ACCIDENT ISSUES ONLY 40,000 MILES CONTACTED TOYOTA DEALER IN GREEN BAY, AND THEY SAID THEY NEVER HEARD OF ANY COMPLAINTS REGARDING THE 2009 COROLLA ELECTRIC ASSISTED POWER STEERING. FURTHER STATED I SHOULD 'TRY AND FIND SOMETHING ON THE INTERNET' TO SHOW IF THERE ARE ANY ISSUES.. COMPLETE STONEWALLING.. *TR
NHTSA ODI #10449729
Mileage unknown · Feb 24, 2012
Electrical SystemEngine And Engine Cooling
2009 TOYOTA COROLLA. CONSUMER STATES ISSUES WITH SCREECHING NOISE *TGW THE CONSUMER STATED THE NOISE WOULD OCCUR, WHEN SHE STARTED THE VEHICLE, FOLLOWED BY THE BATTERY LIGHT ILLUMINATING. THE BATTERY LIGHT WOULD EVENTUALLY GO OFF AND THEN THE VEHICLE WOULD MAKE THE SCREECHING NOISE AGAIN. THE PROBLEM STARTED INTERMITTENTLY IN …
Read full complaint
2009 TOYOTA COROLLA. CONSUMER STATES ISSUES WITH SCREECHING NOISE *TGW THE CONSUMER STATED THE NOISE WOULD OCCUR, WHEN SHE STARTED THE VEHICLE, FOLLOWED BY THE BATTERY LIGHT ILLUMINATING. THE BATTERY LIGHT WOULD EVENTUALLY GO OFF AND THEN THE VEHICLE WOULD MAKE THE SCREECHING NOISE AGAIN. THE PROBLEM STARTED INTERMITTENTLY IN OCTOBER AND ONE DAY IT COMPLETELY DRAINED THE BATTERY. THE BATTERY WAS REPLACED AND THE ISSUE CONTINUED, BECOMING MORE FREQUENT. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY INFORMED HER THE PROBLEM WAS THE DRIVE BELT, WHICH WAS REPLACED. THE NOISE CONTINUED AND A HOT BURNING SMELL APPEARED AFTER THE SCREECHING NOISE. THE CONSUMER WENT TO GET A SECOND OPINION AND WAS INFORMED THE PROBLEM WAS THE CLUTCH PULLEY IN WHICH A RECALL HAD BEEN ISSUED, BUT NOT FOR HER MODEL. THE CONSUMER THEN WENT BACK TO THE DEALER WITH THE NEW INFORMATION AND WAS TOLD SHE NEEDED A NEW ALTERNATOR. THE CONSUMER ALSO STATED THERE WAS AN ISSUE WITH THE VEHICLE IDLING IN A STRANGE MANNER. THE VEHICLE RANDOMLY VIBRATED AND IDLED VERY LOW WHEN STOPPING AT A RED LIGHT OR STOP SIGN. *JB
NHTSA ODI #10449813
38,000 miles · Feb 17, 2012
Steering
EVERY SINCE BUYING THIS CAR SOMETHING HAS FELT WRONG WITH THE STEERING. IT HAS GOTTEN WORSE OVER TIME. IT FEELS LIKE YOU ARE SKATING ON ICE AS YOU DRIVE DOWN THE HIGHWAY EVEN ON DRY PAVEMENT WITH NO WIND. THE STEERING WANDERS CONSTANTLY CAUSING ME TO HAVE TO CORRECT IT. YOU CAN'T DRIVE IT WITH ONE HAND AT ALL. I'VE HAD 3 SE…
Read full complaint
EVERY SINCE BUYING THIS CAR SOMETHING HAS FELT WRONG WITH THE STEERING. IT HAS GOTTEN WORSE OVER TIME. IT FEELS LIKE YOU ARE SKATING ON ICE AS YOU DRIVE DOWN THE HIGHWAY EVEN ON DRY PAVEMENT WITH NO WIND. THE STEERING WANDERS CONSTANTLY CAUSING ME TO HAVE TO CORRECT IT. YOU CAN'T DRIVE IT WITH ONE HAND AT ALL. I'VE HAD 3 SETS OF TIRES AND TWO ALIGNMENTS TO TRY AND CORRECT THE PROBLEM. THE MECHANICS SAY THEY CAN FIND NOTHING WRONG. *TR
NHTSA ODI #10448376
85,000 miles · Feb 15, 2012
VisibilityFire
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT STATED THAT SHORTLY AFTER CLOSING THE DRIVER SIDE WINDOW WHILE DRIVING 40 MPH, SHE NOTICED SMOKE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE WIRE THAT CONTROLLED THE WINDOW SWITCH SHORTED, CAUSING THE PASSENGER WINDOW MOTOR TO BURN. AS A RESULT, BOTH NEEDED …
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT STATED THAT SHORTLY AFTER CLOSING THE DRIVER SIDE WINDOW WHILE DRIVING 40 MPH, SHE NOTICED SMOKE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE WIRE THAT CONTROLLED THE WINDOW SWITCH SHORTED, CAUSING THE PASSENGER WINDOW MOTOR TO BURN. AS A RESULT, BOTH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 85,000.
NHTSA ODI #10448095
44,000 miles · Feb 10, 2012
Engine And Engine CoolingSteering
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT STATED WHILE THE OIL WAS BEING CHANGED BY AN AUTHORIZED DEALER, HE WAS INFORMED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FRONT PASSENGER SIDE WHEEL WAS SHAKING AND THE STEERING RACK NEEDED TO BE REP…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT STATED WHILE THE OIL WAS BEING CHANGED BY AN AUTHORIZED DEALER, HE WAS INFORMED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FRONT PASSENGER SIDE WHEEL WAS SHAKING AND THE STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,000. UPDATED 03/21/2012 *BF
NHTSA ODI #10447387
71,200 miles · Jan 15, 2012
Fuel System, GasolineUnknown Or Other
MY CAR RECENTLY GOT RECALL REPAIR.AFTER THE REPAIR DONE, MY CAR BECAME TAKE A LOT GAS ON DRIVING.THEN I TOOK BACK TO DEALER , DEALER JUST SAID WAS FUEL SYSTEM NEED CLEAN. I THINK THAT IS BIG ISSUE. BECAUSE AFTER RECALL REPAIR DONE. IT TAKE A LOT GAS THAN BEFORE IF SOMETHING I DESCRIP NOT CLEARLY. YOU CAN CALL ME [XXX]. THANK YOU…
Read full complaint
MY CAR RECENTLY GOT RECALL REPAIR.AFTER THE REPAIR DONE, MY CAR BECAME TAKE A LOT GAS ON DRIVING.THEN I TOOK BACK TO DEALER , DEALER JUST SAID WAS FUEL SYSTEM NEED CLEAN. I THINK THAT IS BIG ISSUE. BECAUSE AFTER RECALL REPAIR DONE. IT TAKE A LOT GAS THAN BEFORE IF SOMETHING I DESCRIP NOT CLEARLY. YOU CAN CALL ME [XXX]. THANK YOU PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC
NHTSA ODI #10443880
Official recalls
13Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013 Scion xB, Toyota Corolla, Corolla Matrix, Sienna, 4Runner, Lexus IS250, IS350, IS250C, IS350C, IS-F, and GX460 vehicles sold, ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP (Saipan), and the U.S. VI or "Zone A." Toyota is also recalling certain 2010 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, 4Runner, Lexus IS250, IS350, IS250C, IS350C, ES350, IS-F, GX460, and Pontiac Vibe vehicles sold, ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Toyota is also recalling certain 2009 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, Lexus IS250, IS350, ES350, IS-F, and Pontiac Vibe vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began on January 29, 2018. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Jan 9, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Aug 27, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2009 SCION XD AND MY 2009-2010 COROLLA, AND COROLLA MATRIX VEHICLES EQUIPPED WITH 1.8L ENGINE AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHEN DRIVING UNDER CERTAIN UNIQUE CONDITIONS IN EXTREMELY LOW AMBIENT TEMPERATURES, THE INTAKE MANIFOLD SUCTION PORT FOR THE BRAKE VACUUM CAN BECOME BLOCKED DUE TO THE FREEZING OF CONDENSATION RESULTING FROM POSITIVE CRANKCASE VENTILATION.
Consequence & remedy
Consequence: THIS COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED INTAKE AIR CONNECTOR WHICH WILL RELOCATE THE BRAKE SYSTEM VACUUM PORT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
DP14003 · Low-speed Surging
Opened Sep 19, 2014 · Closed Apr 29, 2015
Status: closed (inferred from source dates) · Vehicle Speed Control
The Agency received a petition on September 11, 2014 requesting an investigation into, low-speed surging in the 2006-2010 Toyota Corolla [vehicles] with ETCS-i, in which the brakes fail to stop the vehicle in time to prevent a crash.NHTSA conducted a technical review of the material cited and provided by the petitioner, material Toyota submitted in response to a NHTSA formal request, interviews with complainants and manufacturer representatives, as well as the results of testing of the complaint vehicle.Taking into account the allocation of agency resources, agency priorities, and the likelihood that an additional investigation would result in a finding that a defect related to motor vehicle safety exists, NHTSA has concluded that further investigation of the issues raised by the petition is not warranted.The agency accordingly has denied the petition.The official petition denial, as published in the Federal Register, is available in the document file for this defect petition, as well as copies of reference material related to the denial.Regarding the VOQs associated with the closing of this investigation, the scope as defined by the petitioner is MY 2006 through 2010 Toyota Corollas.Of the 163 VOQs submitted by the petitioner, 149 are within that specific population (11 of the 163 were outside the model and model year scope of investigation as defined by the petitioner and 3 VOQs were submitted by owners from foreign countries) and 6 of the 163 are duplicate submissions.Therefore, there are 143 unique vehicles vins are within the specific population.Of the 143 only 105 fit the alleged defect category as defined by the petitioner.The single complaint and crash noted in the Failure Report above is the petitioner's VOQ.The 143 VOQs are: 10165337, 10166526, 10209540, 10216514, 10256808 (duplicate with 10266580 and 10335955), 10272505, 10293497, 10293688, 10294727, 10297407, 10298012, 10302217, 10302877, 10303106, 10303469, 10303730, 10304192, 10305748, 10305845, 10306012, 10306480, 10307953, 10310973, 10311137, 10311176, 10311185, 10311756, 10312246, 10312272 (duplicate with 10343088), 10312771, 10313972, 10314880, 10315240, 10315442, 10315836, 10315927, 10316192, 10316627, 10316643, 10316800, 10316952, 10317128, 10317598, 10317725, 10317804, 10317894, 10317972, 10317978, 10318562, 10319589, 10320693, 10320720, 10322163, 10322213, 10322333, 10322415, 10324355, 10325755, 10326481, 10327623, 10328492, 10328519, 10329537, 10330026 (duplicate with 10356866), 10330952, 10332679, 10334005 (duplicate with 10340570 and 10547602), 10334028, 10334628, 10334936, 10336649, 10339772, 10339969, 10341515, 10342670, 10342932, 10343174, 10344874, 10345714, 10348120, 10350342, 10351112, 10352668, 10352691, 10353587, 10358767, 10359645, 10360875, 10360905, 10361254, 10363529, 10363685, 10363866, 10364127, 10366100, 10366413, 10369073, 10369494, 10371991, 10376535, 10376721, 10377193, 10379320, 10380210, 10381365, 10381849, 10382018, 10392618, 10396747, 10402827, 10412382, 10433860, 10437011, 10437801, 10450183, 10461118, 10479582, 10482133, 10489344, 10494568, 10496026, 10499932, 10520195, 10521013, 10523677, 10534094, 10537426, 10543949, 10549101, 10551478, 10552563, 10558153, 10562577, 10564980, 10566370, 10572873, 10578871, 10579722, 10587140, 10597296, 10621449, and 10637908 (which is the petitioner's VOQ and not one of the 163 submitted with the petition).The three VOQs that were submitted from foreign countries: 10303105, 10303749, and 10308974. The eleven VOQs that are out of the specified population by model or model year: 10447756, 10453401, 10490200, 10507434, 10521377, 10563214, 10563585, 10575230, 10583796, 10584534,
PE10008 · Steering Wander Or Drift
Opened Feb 18, 2010 · Closed May 4, 2011
Status: closed (inferred from source dates) · Steering
On February 18, 2010, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE10-008 to investigate complaints of steering wander or drift in model year (MY) 2009 and 2010 Toyota Corolla and Matrix vehicles.The complaint descriptions indicated dissatisfaction with the on-center steering feel in the subject vehicles. Some drivers (~25%) related the feel to driving in a strong crosswind and others indicated that the effort and attention required to maintain heading increased driver fatigue on long trips.These complaints all relate to the system operating as designed and do not involve failure of any steering system components.The subject vehicles are equipped with an electronic power steering system that was introduced in the MY 2009 vehicles.The power assist, including on-center steering feel, is controlled electronically and is part of the system calibration.Toyota responded to steering feel concerns from some customers by issuing a technical service bulletin (TSB-0140-10 STEERING ON-CENTER FEEL) that released an optional EPS electronic control unit that has a re-calibrated on-center feel.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted by the circumstances.For further details see the attached VRTC and ODI Closing Reports.
Illustration