Vehicle Speed Control. Review the 266 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 224 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 208 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

150 crash reports19 fire reports67 injury reports

Power Train complaints

51 reports

Clear category filter

28,000 miles · Feb 12, 2012

Power Train

Read full complaint

THIS 2009 CAMRY WHICH IS STILL UNDER WARRANTY IS EQUIPPED WITH TRACTION CONTROL WITH NO SWITCH TO DISABLE IT DURING ICY CONDITIONS. THE CAR IS OPERATED IN COLORADO WHERE SNOW PACKED AND ICY ROADS ARE COMMON. WHEN THESE CONDITIONS EXIST AND THE CAR IS STOPPED ON A SLIGHT INCLINE OR AT A STOP SIGN OR TRAFFIC LIGHT ON AN INCLINE, THE POWER TO THE FRONT WHEELS IS AUTOMATICALLY SHUT DOWN BECAUSE THE WHEELS ARE SPINNING ON THE ICE AND THE TRACTION CONTROL SHUTS THE POWER DOWN TO THEM TO THE POINT THEY WILL NOT TURN. AT THIS POINT, THE CAR WILL NOT MOVE UNLESS YOU BACK IT UP AND TAKE A RUN AT THE HILL. THIS IS DANGEROUS FOR 2 REASONS: 1. IF THERE IS A CAR BEHIND YOU, YOU CANNOT BACK UP WHICH CREATES A TRAFFIC JAM AND REQUIRES CARS GO AROUND YOU WHICH CAN BE A HAZARD. 2. WHEN YOU GET THE OPPORTUNITY TO TAKE A RUN AT THE HILL, YOU CANNOT STOP OTHERWISE THE CAR WILL STALL WHICH MEANS YOU MUST ENTER INTO A STREET WITHOUT STOPPING WHICH IS DANGEROUS AND IN MANY CASES ILLEGAL. THE DEALERSHIP ADVISED THAT IT IS IMPOSSIBLE TO INSTALL A SWITCH, AND THAT I SHOULD EXPRESS MY CONCERNS TO THE TOYOTA EXPERIENCE LINE. THIS SITUATION IS A CATASTROPHE WAITING TO HAPPEN AND NEEDS IMMEDIATE ATTENTION. ALSO, THE 2012 CAMRY HAS A SWITCH TO DISABLE THE TRACTION CONTROL IN ICY CONDITIONS. IN THE INTEREST OF SAFETY THE SWITCH MUST BE RETROFITTED TO OLDER MODELS. *TR

NHTSA ODI #10448651

65,375 miles · Dec 16, 2011

Engine And Engine CoolingPower Train

WATER PUMP FAILURE AT 3 YEARS & 65,375 MILES. POWERTRAIN WARRANTY IS 5 YEARS OR 60,000 MILES. INTERNET SEARCH INDICATES POTENTIAL ISSUE WITH THE 90,000 MILE COOLANT. HAVE CONTACTED DEALER AND TOYOTA MOTOR CORP. USA TO NO AVAIL. SPOKE WITH [XXX]. TOYOTA MOTOR CORP., USA CASE NUMBER [XXX]. INFORMATION REDACTED PURSUANT TO …

Read full complaint

NHTSA ODI #10440212

Mileage unknown · Oct 6, 2011

Power TrainService Brakes, HydraulicCrashInjury

Read full complaint

VEHICLE WAS INVOLVED IN AN ACCIDENT AND AFTER THE INITIAL CONTACT OPERATOR TRIED TO STOP HER VEHICLE BUT IT WOULDN'T STOP. SHE STATED THAT SHE WAS PRESSING THE BRAKE BUT THE VEHICLE WAS ROLLING BACKWARDS. SHE STATED THAT SHE TRIED HER BRAKES, TRIED PUMPING HER BRAKES, TRIED PUTTING THE VEHICLE IN NEUTRAL AND TRIED THE BRAKES AGAIN BUT NONE OF THESE ACTIONS STOPPED HER VEHICLE FROM ROLLING. SHE STATED THAT SHE THEN PUT THE VEHICLE IN PARK AND TRIED THE BRAKES BUT THE VEHICLE CONTINUED TO ROLL BACKWARDS. SHE STATED THAT AT THAT POINT SHE MADE THE DECISION TO EXIT THE VEHICLE. SHE WAS KNOCKED TO THE GROUND AND DRAGGED BY THE VEHICLE SUFFERING LACERATIONS TO BOTH HER LEGS. SHE STATED THAT THE VEHICLE THEN ACCELERATED FORWARD AND FINALLY CAME TO REST ON SIDEWALK AND LAWN OF A RESIDENCE. WHILE RESPONDING MEDICAL PERSONNEL WERE TREATING THE ACCIDENT VICTIM, A MEMBER OF THE FIRE DEPARTMENT REACHED IN VEHICLE TO TURN THE VEHICLE OFF. THE VEHICLE THEN STARTED ROLLING FORWARD EVEN THOUGH VEHICLE WAS TURNED OFF AND IN PARK. *TR

NHTSA ODI #10428902

Mileage unknown · Sep 1, 2011

Power Train

Read full complaint

I HAVE CAMRY 2009. IT CURRENTLY HAS 34400 MILES. ACCORDING TO TOYOTA DEALER - AFTER A TECHNICIAN TESTS DRIVE THE VEHICLE - THE ISSUE IS DESCRIBED "DOWNSHIFT ISSUE UNDER HEAVY BRAKE". BELOW IS DETAILS OF THE PROBLEM. AFTER I APPLY BRAKE AT STOP SIGN OR TRAFFIC LIGHT, THE VEHICLE IS STOPPED BUT THEN VEHICLE IS STILL JUMPING UP - MOVING UP JUST RIGHT AFTER IT STOPS. BELOW IS HOW TOYOTA RESPONDS ON THE ISSUE. ON AUGUST 5TH, 2011, I BRING THE CAR TO TOYOTA DEALER. THE TECHNICIAN IS ABLE TO DUPLICATE THE ISSUE AND OPEN A CASE NUMBER REPORTING TO GST (GULF STATE TOYOTA). I HAVE TO WAIT FOR AN APPOINTMENT WITH GST AND TOYOTA DEALER UNTIL 8/30/2011. ON AUGUST 31ST, I BROUGHT THE CAR IN 2ND TIME SO THAT THE DEALER CAN COLLECT MORE INFORMATION AND SEND TO GST (ACCORDING TO THE DEALER). THE DEALER TOLD ME THEY COULD NOT DUPLICATE THE ISSUE LAST TIME. BUT THEY WILL NEED TO RE-PROGRAM (SOFTWARE) ON THE COMPUTER SYSTEM SO THAT THE COMPUTER SYSTEM CAN RE-LEARN THE SHIFTING PATTERN OF THE TRANSMISSION. HERE IS MY OPINIONS. I AM NOT CONVINCED AT ALL THIS WILL RE-SOLVE THE ISSUE. THE ISSUE MIGHT APPEAR AGAIN ANY TIME. HERE ARE SOME MORE FACTS. DURING THE WAITING TIME - 3 WEEKS - I DO NOT DRIVE THE VEHICLE AT ALL. THE DEALER CERTAINLY DOES NOT DRIVE THE VEHICLE LONG ENOUGH BEFORE THEY CAN SEE THE ISSUE AGAIN. WHEN I DRIVE THE VEHICLE TO THE DEALER ON THE 2ND TIME, I SEE IT HAPPENS TWICE. THIS KIND OF ISSUE ABSOLUTELY MAKES ME VERY NERVOUS WHEN I HAVE TO APPLY BRAKING. I HOPE TOYOTA CAN ROOT CAUSE THIS ISSUE AS SOON AS POSSIBLE. WHO KNOWS THIS ISSUE CAN BE WORST AND TOTALLY OUT OF CONTROLS ONE DAY. *TR

NHTSA ODI #10422909

42,600 miles · Mar 14, 2011

Engine And Engine CoolingPower Train

Read full complaint

ON WEDNESDAY, 2/16/11, AT 4:50 P.M. I WAS TRAVELING DOWN SUDBURY STREET IN BOSTON, MA TO MAKE A RIGHT HAND TURN ONTO CONGRESS STREET IN BOSTON. I CAME DOWN THE HILL AND STOPPED AT A RED TRAFFIC LIGHT. MY CAR, FOR NO APPARENT REASON, BEGAN TO RACE AND WOULD NOT STOP. I APPLIED MORE PRESSURE TO THE BRAKE AND SHIFTED THE CAR INTO PARK. IT CONTINUED TO RACE FOR 5-10 SECONDS AFTER I DID THIS. THIS WAS A VERY FRIGHTENING INCIDENT, GIVEN THERE WAS A STOPPED VEHICLE IN FRONT OF ME, A VEHICLE BEHIND ME AND MANY PEDESTRIANS AT THAT HOUR. I NO LONGER FEEL SECURE WITH THE CAR AND AM ANTICIPATING THAT THIS MAY RE-OCCUR AT ANY TIME. *TR UPDATED 1/13/2012 *LN *TR

NHTSA ODI #10390027

35,900 miles · Jan 22, 2011

Power Train

Read full complaint

I WAS DRIVING MY CAR DOWN THE ROAD ABOUT 2 MILES AWAY FROM MY HOUSE IT BECAME HARD TO ACCELERATE. THE SKID LIGHT, VSC LIGHT AND CHECK ENGINE LIGHT ALL CAME ON AT ONCE. I PULLED OVER TO THE SIDE OF THE ROAD. I TURNED THE CAR OFF STARTED IT BACK UP IT DROVE FINE BUT THE LIGHTS WERE STILL ON. I CONTACTED THE DEALERSHIP AND TOOK THE CAR IN. THIS WAS PURCHASED AS A DEALER DEMO AND HAS 36,000 MILES ON IT. THEY TOLD ME THERE IS WATER IN MY ENGINE AND THE OIL WAS MILKY. TO ME THIS SOUNDED LIKE A HEAD GASKET BUT THEY ASSURED ME THEY RAN A TEST FOR THAT. THEY REPLACED THE THROTTLE BODY AND THE PCV VALVE CLAIMING THE VALVE WAS NOT WORKING PROPERLY THIS WAS THE CAUSE FOR THE WATER. I DON'T KNOW IF THE PART IS STILL AROUND OR NOT. I HOPE THIS FIXES THE PROBLEM. THEY TOLD ME I SHOULD WARM IT UP FOR 15 TO 20 MINUTES A DAY WHICH SOUNDS A LITTLE WEIRD TO ME BEING A FAIRLY NEW CAR. *TR

NHTSA ODI #10378253

11,400 miles · Jan 18, 2011

Power Train

Read full complaint

TL*THE CONTACT OWNS A 2009 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD HESITATE WHEN TRYING TO ACCELERATE TO HIGHER SPEEDS. APPROXIMATELY ONE WEEK LATER THE VEHICLE JUST COMPLETELY STALLED. NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 11,400.

NHTSA ODI #10377046

Mileage unknown · Jan 5, 2011

Power TrainService Brakes, Hydraulic

Read full complaint

2009 TOYOTA CAMRY. CONSUMER WRITES REGARDING VEHICLE STALLING IN THE ACCELERATION PROCESS *TGW THE DEALER STATED THE STALL IN THE ACCELERATION, WAS CAUSED BY THE SEQUENCING OF THE TRANSMISSION. THE STALL WOULD OCCUR AS THE CONSUMER MADE A RAPID CHANGE FROM DECELERATION TO ACCELERATION. THE CONSUMER WAS INFORMED THE STALL WAS A BUILT IN DESIGN FEATURE. THE CONSUMER STATED TO MINIMIZE THE STALL, SHE MUST MANUALLY DOWN SHIFT THE TRANSMISSION WHENEVER THE ENGINE IS IN THE DECELERATION PHASE. RECENTLY, A SLOW MOVING 18 WHEELER UNEXPECTEDLY PULLED INTO THE CONSUMERS LANE OF TRAFFIC, WHILE TRAVELING AT HIGHWAY SPEEDS. THE CONSUMER STATED HER NATURAL REACTION WAS TO REMOVE HER FOOT FROM THE ACCELERATOR, PUTTING THE ENGINE /TRANSMISSION INTO DECELERATION MODE. AS THE SITUATION UNFOLDED, SHE CONCLUDED THAT THE RAPID ACCELERATION AND LANE CHANGE WAS THE SAFEST METHOD. WHEN THE CONSUMER TRIED TO ACCELERATE AROUND THE TRUCK, THERE WAS NO REACTION FROM THE VEHICLE. THE TRANSMISSION DELAYED RESPONDING AND WHEN IT DID RESPOND, IT CHOSE A GEAR WHICH PRODUCED NO MEANINGFUL FORWARD MOTION, BUT LOTS OF NOISE. CONSEQUENTLY, SHE WAS FORCED TO BRAKE VERY HARD, BUT THE BRAKES FAILED TO PERFORM AS DESIGNED. THE NEXT DAY, THE DEALER EXPLAINED THERE WAS A FACTORY ALERT ISSUE ON THE BRAKE PADS. THE PADS WERE REPLACED, AND THE ROTORS WERE TURNED. *JB

NHTSA ODI #10374591

30,000 miles · Oct 17, 2010

Power TrainVehicle Speed Control

2009 TOYOTA CAMRY - EXCESSIVE ACCELERATION AND ABRUPT CHANGE IN TRANSMISSION WHEN CRUISE CONTROL TRIES TO CATCH UP WITH THE SET SPEED LIMIT AFTER A DIP IN SPEED- TOYOTA TECH SAW THE PROBLEM, ACCEPTS THAT ITS HAPPENING - TOYOTA'S RESPONSE "GET USED TO IT". *TR

NHTSA ODI #10360834

Mileage unknown · Sep 21, 2010

Power TrainTires

VEHICLE HESITATE DURING ACCELERATION. VEHICLE SURGES/ACCELERATES SLIGHTLY WHEN NOT PRESSING PEDAL TO ACCELERATE. TIRE PRESSURE LIGHT ALWAYS COMES ON EVEN WHEN TIRES ARE PROPERLY INFLATED. VEHICLE RUNS "HARD" WHEN CRUISING AT 40MPH. THERE IS A HARD ENGINE RUNNING SOUND. *TR

NHTSA ODI #10356802

Official recalls

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

15V689000 · Visibility:power Window Devices And Controls

Oct 22, 2015

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence & remedy

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

14V743000 · Seats:front Assembly:seat Heater/cooler

Nov 19, 2014

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence & remedy

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Seats

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Air Bags:frontal:sensor/control MODULE-INACTIVE

12V491000 · Visibility:power Window Devices And Controls

Oct 10, 2012

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Consequence & remedy

Consequence: If the switch overheats, it may melt, possibly resulting in a fire.

Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

12V091000 · Exterior Lighting:brake Lights:switch

Mar 7, 2012

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2009 CAMRY VEHICLES MANUFACTURED FROM JULY 1, 2008, THROUGH FEBRUARY 28, 2009, AND MODEL YEAR 2009-2011 VENZA VEHICLES MANUFACTURED FROM OCTOBER 20, 2008, THROUGH JANUARY 4, 2011. DURING ASSEMBLY OF THE CONTACT-TYPE STOP LAMP SWITCH, SILICONE GREASE MAY HAVE COME IN CONTACT WITH THE SURFACE OF THE SWITCH WHICH COULD CAUSE CONTACT RESISTANCE. IF THIS OCCURS, WARNING LAMPS COULD ILLUMINATE, A NO START CONDITION COULD RESULT, THE SHIFT LEVER MAY NOT SHIFT FROM THE PARK POSITION, OR THE VEHICLES BRAKE LIGHTS COULD BECOME INOPERATIVE.

Consequence & remedy

Consequence: INOPERATIVE BRAKE LIGHTS WOULD NOT WARN OTHER DRIVERS THAT THE VEHICLE IS SLOWING OR STOPPING, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE STOP LAMP SWITCH, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

10V017000 · Vehicle Speed Control:accelerator Pedal

Jan 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Consequence & remedy

Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12006 · Power Window Master Switch Fire

Opened Jun 14, 2012 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

Additional source detail variants (3)

Electrical System

Structure:body

Unknown Or Other

PE12002 · Power Window Master Switch Fire

Opened Feb 6, 2012 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

Additional source detail variants (3)

Electrical System

Structure:body

Unknown Or Other

Go deeper into Toyota Camry problems

Toyota Camry electrical problems →Toyota Camry transmission problems →