NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
721 reports6,500 miles · Jul 6, 2005
Vehicle Speed Control
DT: 2005 TOYOTA CAMRY XLE, CRUISE CONTROL DOES NOT HOLD VEHICLE BACK. THIS IS NOT A PROBLEM ON LEVEL GROUND OR UP HILL. IF THE VEHICLE IS GOING DOWN HILL, THE CRUISE CONTROL WILL NOT STAY, CAUSING THE VEHICLE TO ACCELERATE AT A FASTER SPEED THAN IS SAFE UNDER THE CIRCUMSTANCES. AFTER THE CONSUMER PURCHASED THE VEHICLE, THE …
Read full complaint
DT: 2005 TOYOTA CAMRY XLE, CRUISE CONTROL DOES NOT HOLD VEHICLE BACK. THIS IS NOT A PROBLEM ON LEVEL GROUND OR UP HILL. IF THE VEHICLE IS GOING DOWN HILL, THE CRUISE CONTROL WILL NOT STAY, CAUSING THE VEHICLE TO ACCELERATE AT A FASTER SPEED THAN IS SAFE UNDER THE CIRCUMSTANCES. AFTER THE CONSUMER PURCHASED THE VEHICLE, THE DEALER AND THE MANUFACTURER TOLD CONSUMER THAT WAS THE WAY THE VEHICLE PERFORMED. CONSUMER CONSIDERS THIS IS A SAFETY ISSUE, AND IT IS NOT ACCEPTABLE, CONSUMER FILED A COMPLAINT # 20050706 ON JULY 6, 2005 WITH TOYOTA. THERE ARE NO OTHER KNOWN PROBLEMS WITH THIS VEHICLE AND IT IS STILL UNDER WARRANTY. *AK
NHTSA ODI #10127662
69 miles · Jul 5, 2005
Power Train
I BOUGHT A 2005 CAMRY XLE LAST MONTH. THE TRANSMISSION IS COMPLETELY FAULTY AND THERE IS NO RESPONSE FROM THE COMPANY. THE ELECTRONICALLY CONTROLLED TRANSMISSION (ECT) IS SLOW TO RESPOND. THERE IS A DELAY WHEN YOU PRESS THE GAS SO YOU NEVEN KNOW WHEN THE CAR WILL ACTUALLY KICK INTO GEAR. THIS IS NOT A PROBLEM EXCEPT WHEN YOU…
Read full complaint
I BOUGHT A 2005 CAMRY XLE LAST MONTH. THE TRANSMISSION IS COMPLETELY FAULTY AND THERE IS NO RESPONSE FROM THE COMPANY. THE ELECTRONICALLY CONTROLLED TRANSMISSION (ECT) IS SLOW TO RESPOND. THERE IS A DELAY WHEN YOU PRESS THE GAS SO YOU NEVEN KNOW WHEN THE CAR WILL ACTUALLY KICK INTO GEAR. THIS IS NOT A PROBLEM EXCEPT WHEN YOU ENTER A HIGHWAY OR TRY AVOID A CRASH.
NHTSA ODI #10127532
800 miles · Jul 5, 2005
Air Bags
DT: CONSUMER STATES THE DRIVER'S SIDE AIR BAG LIGHT CAME ON. TOYOTA SAID THAT MEANT THE AIR BAG WAS INACTIVE AND FIXED IT. WHILE THE CONSUMER WAS DRIVING OUT OF A PARKING LOT THE LIGHT CAME BACK ON. HE TOOK IT BACK, AND THEY REPLACED THE AIR BAG IN THE STEERING COLUMN BUT THE LIGHT CAME BACK ON. *AK
NHTSA ODI #10127469
4,086 miles · Jul 4, 2005
Vehicle Speed ControlCrashInjury
WAS SITTING IN MY 2005 TOYOTA CAMRY XLE IN PARK IDLING WHEN I PLACED IT IN DRIVE IT SURGED QUICKLY FORWARD AND HIT MY BRICK GARAGE WALL
NHTSA ODI #10127402
Mileage unknown · Jul 3, 2005
Service Brakes, HydraulicCrashInjury
ON A CLEAR DAY THE MORNING OF JUNE 14, 2005, I WAS DRIVING SOUTH IN THE SLOW LANE OF HIGHWAY 95 IN FLORIDA. ALL OF A SUDDEN I HEARD THE DRIVER IN THE MIDDLE LANE BLOW HIS HORN. AT THIS MOMENT I FELT THAT THE CAR WAS DRAGGING ME ON ONE SIDE TO THE LEFT. I TRIED TO STOP THE CAR BY PRESSING ON THE BRAKES. THE BRAKES WERE NON EXIS…
Read full complaint
ON A CLEAR DAY THE MORNING OF JUNE 14, 2005, I WAS DRIVING SOUTH IN THE SLOW LANE OF HIGHWAY 95 IN FLORIDA. ALL OF A SUDDEN I HEARD THE DRIVER IN THE MIDDLE LANE BLOW HIS HORN. AT THIS MOMENT I FELT THAT THE CAR WAS DRAGGING ME ON ONE SIDE TO THE LEFT. I TRIED TO STOP THE CAR BY PRESSING ON THE BRAKES. THE BRAKES WERE NON EXISTENT AND THE CAR KEPT GOING LEFT, HIT A PICK UP TRUCK IN THE MIDDLE LANE (TRUCK TURNED UPSIDE DOWN, DRIVER ON THE PAVEMENT); PASSED THE FAST LANE AND THROUGH THE MEDIAN; FINALLY GOT STUCK IN THE MUD (THANK GOD IT RAINED THE NIGHT BEFORE) NEAR THE NORTHBOUND LANE. MY CAR WAS TOWED TO THE NEAREST DEALER WITH $4,000 WORTH OF DAMAGES. MY INSURANCE HAS TO REPLACE THE OTHER DRIVER'S CAR. BOTH DRIVERS WERE INJURED IN THE CRASH.
NHTSA ODI #10127357
7,100 miles · Jun 28, 2005
Service Brakes, HydraulicCrash
DT: CONTACT STATES: SHE WENT TO PARK THE CAR, WAS APPLYING THE BRAKE AND THE BRAKE WOULD NOT HOLD. THEN, CONSUMER'S VEHICLE HIT ANOTHER CAR, AND BRAKES DID NOT HOLD. IT ALSO HIT ANOTHER CAR, AND THE BRAKES STILL DID NOT WORK. . SHE WAS TRAVELING AT A VERY LOW SPEED. *AK DEALERSHIP CHECKED ALL RELATED COMPONENTS, BUT NO…
Read full complaint
DT: CONTACT STATES: SHE WENT TO PARK THE CAR, WAS APPLYING THE BRAKE AND THE BRAKE WOULD NOT HOLD. THEN, CONSUMER'S VEHICLE HIT ANOTHER CAR, AND BRAKES DID NOT HOLD. IT ALSO HIT ANOTHER CAR, AND THE BRAKES STILL DID NOT WORK. . SHE WAS TRAVELING AT A VERY LOW SPEED. *AK DEALERSHIP CHECKED ALL RELATED COMPONENTS, BUT NOTHING WAS FOUND. *TT *NM
NHTSA ODI #10125383
10,160 miles · Jun 27, 2005
Power Train
TRAVELING DOWN HILL AT APPROXIMATELY 45 MPH JUST SLIGHTLY PRESSING THE BRAKE PEDAL VEHICLE WILL DOWN SHIFT AND JURK STEERING WHEEL. IF CONDITIONS WHERE RIGHT I MAY LOOSE CONTROL. THIS HAS HAPPENED NUMEROUS TIMES. SPOKE TO SEVERAL DEALERS AND THEY SAY IT IS NORMAL.
NHTSA ODI #10126763
7,200 miles · Jun 27, 2005
Service Brakes, HydraulicVehicle Speed ControlInjury
DT: PULLING OUT OF A MALL HAD MY FOOT ON THE BRAKE INSTEAD OF IT SLOWING DOWN THE VEHICLE SURGED FORWARD. THIS HAPPENED BEFORE, AT FIRST JUST THOUGHT IT WAS CONSUMER BUT THIS WAS THE SECOND TIME THIS HAPPENED. VEHICLE WAS REPAIRED. *AK
NHTSA ODI #10126649
108 miles · Jun 22, 2005
Vehicle Speed ControlCrashInjury
NEW VEHICLE DRIVEN 108 MILES. THE ONLY PROBLENS NOTICES WAS THE RADIO WOULD TURN ITSELF ON WHEN HITTING A SLIGHT BUMP IN THE ROAD. CRUISE CONTROL LIGHT DID NOT GO OFF WHEN BRAKES WERE ENGAGED, BUT WOULD DISCONNECT CRUISE CONTROL. WAS PARKING IN A MALL PARKING LOT PARRALL TO ACCESS ROAD. SPEED NO MORE THAN 1 OR 2 MPH. FRON…
Read full complaint
NEW VEHICLE DRIVEN 108 MILES. THE ONLY PROBLENS NOTICES WAS THE RADIO WOULD TURN ITSELF ON WHEN HITTING A SLIGHT BUMP IN THE ROAD. CRUISE CONTROL LIGHT DID NOT GO OFF WHEN BRAKES WERE ENGAGED, BUT WOULD DISCONNECT CRUISE CONTROL. WAS PARKING IN A MALL PARKING LOT PARRALL TO ACCESS ROAD. SPEED NO MORE THAN 1 OR 2 MPH. FRONT WHEEL DROPPED INTO HOLE. THE ACCELORATOR CAUSED THE CAR TO LURCH FORWARD. APPLIED BRAKES BUT WAS UNABLE TO KEEP CAR FROM MOVING FORWARD AT A SLOW SPEED OF 5 MPH. TURNED RIGHT, TO AVOID STRIKING HANDICAP PARKING SIGN, INTO THE PATH OF A PICKUP TRUCK TRAVELING ON MALL ACCESS ROAD. STRUCK TRUCK AND CONTINUED FORWARD TOWARD PEDESTRIANS ON SIDEWALK. MANAGED TO AVOID THEM AND THE ENGINED STOPPED AT THAT POINT. I APPLIED THE BRAKE SO HARD I INJURED MY RIGHT HAMSTRING MUSCLE AND WAS UNABLE TO WALK. TOYOTA SEIZED VEHICLE FOR INSPECTION AND HAS NOT RELEASED OR INSPECTED IT AS OF THIS DATE.
NHTSA ODI #10126249
9,800 miles · Jun 19, 2005
Power Train
WHEN THE OVERDRIVE IS ACTIVATED, THE RPM'S SPIKE BETWEEN THREE AND SIX THOUSAND RPM'S. THIS HAPPENS DURING NORMAL DRIVING CONDITIONS. IT IS AN INTERMITTENT PROBLEM. WE HAVE CONTACTED THE DEALER ON TWO SEPARATE OCCASIONS AND THEY ARE UNABLE TO FIND THE PROBLEM. IT STARTED AROUND THE BEGINNING OF APRIL, FIVE MONTHS AFTER PURCHA…
Read full complaint
WHEN THE OVERDRIVE IS ACTIVATED, THE RPM'S SPIKE BETWEEN THREE AND SIX THOUSAND RPM'S. THIS HAPPENS DURING NORMAL DRIVING CONDITIONS. IT IS AN INTERMITTENT PROBLEM. WE HAVE CONTACTED THE DEALER ON TWO SEPARATE OCCASIONS AND THEY ARE UNABLE TO FIND THE PROBLEM. IT STARTED AROUND THE BEGINNING OF APRIL, FIVE MONTHS AFTER PURCHASING THE VEHICLE. MY CONCERN WITH THIS PROBLEM IS THAT IT MAY SPIKE AT AN INOPPORTUNE TIME CAUSING AN ACCIDENT. WHEN THE RPM'S SPIKE I LOSE ACCELORATOR CONTROL. THE VEHICLE MILAGE IS 14697.
NHTSA ODI #10125727
Official recalls
5Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A FRONT PASSENGER POWER SEAT, WHEN INSTALLING CERTAIN REAR-FACING INFANT CHILD SEAT BASES ONTO THE SEAT WITH AN EXCESSIVELY HIGH SEATBELT TENSION, IT MAY BE POSSIBLE TO UNSEAT A COMPONENT CALLED THE BUCKLE STATUS SWITCH FROM THE SEAT BELT BUCKLE.
Consequence & remedy
Consequence: IF THE SWITCH BECOMES UNSEATED, THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM MAY MISTAKE THE REAR-FACING CHILD RESTRAINT FOR AN UNBELTED ADULT OCCUPANT, AND MAY NOT SUPPRESS THE DEPLOYMENT OF THE FRONT PASSENGER AIRBAG.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SEATBELT BUCKLE STATUS SWITCH. THIS SAFETY IMPROVEMENT CAMPAIGN (SSC 40M) BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987..
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
Illustration