NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
15 reportsClear category filter76,000 miles · May 6, 2019
EngineService BrakesStructureCrash
I WAS COMING OUT OF MY MECHANIC DRIVEWAY AND I LET CARS GO BY DOWN A BUSY STREET> MY FOOT WAS CLEARLY ON THE BRAKE AND SUDDENLY I HEARD A WINING NOISE AND MY THE ACCELERATED ON IT'S OWN AND WENT ACROSS THE ROAD AND HIT A CAR IN THE MIDDLE OF THE STREET. I SAID TO MYSELF THIS CAR IS CAUSING ME TO HAVE AN ACCIDENT. I HAD MY MEC…
Read full complaint
I WAS COMING OUT OF MY MECHANIC DRIVEWAY AND I LET CARS GO BY DOWN A BUSY STREET> MY FOOT WAS CLEARLY ON THE BRAKE AND SUDDENLY I HEARD A WINING NOISE AND MY THE ACCELERATED ON IT'S OWN AND WENT ACROSS THE ROAD AND HIT A CAR IN THE MIDDLE OF THE STREET. I SAID TO MYSELF THIS CAR IS CAUSING ME TO HAVE AN ACCIDENT. I HAD MY MECHANIC CHECK THE BRAKES ABS AND TRANSMISSION NO PROBLEM WITH THAT.
NHTSA ODI #11205684
154,200 miles · Mar 14, 2018
Service BrakesUnknown Or OtherVehicle Speed ControlCrashFireInjury
DRIVING ON THE FREEWAY, CHECK ENGINE LIGHT CAME ON, SMOKE COMING OUT OF THE HOOD, BRAKES AND EMERGENCY BRAKE FAILED, VEHICLE ACCELERATED ON ITS OWN (NO PEDALS WERE WORKING), CAR CRASHED AND FIRE ENGULFED THE VEHICLE
NHTSA ODI #11079137
Mileage unknown · Feb 14, 2018
Service Brakes
THE BRAKE SYSTEM IN THIS KIND OF VEHICLE ARE DEFECTIVE. I ALMOST CRASHED ANOTHER CARS BY REAR ENDING THEM WHEN THE BRAKES DID NOT RESPONDED AND WENT ALL THE WAY WITHOUT THE CAR STOPPING. I TOOK THE CAR TO A MECHANIC AND HE REPLACED THE MASTER CYLINDER AND PURGED THE LINES BUT THE PROBLEM PERSISTS; BY THE WAY THE PADS ARE IN MORE…
Read full complaint
THE BRAKE SYSTEM IN THIS KIND OF VEHICLE ARE DEFECTIVE. I ALMOST CRASHED ANOTHER CARS BY REAR ENDING THEM WHEN THE BRAKES DID NOT RESPONDED AND WENT ALL THE WAY WITHOUT THE CAR STOPPING. I TOOK THE CAR TO A MECHANIC AND HE REPLACED THE MASTER CYLINDER AND PURGED THE LINES BUT THE PROBLEM PERSISTS; BY THE WAY THE PADS ARE IN MORE THAN 60% LIFE. TOYOTA NEEDS TO DO SOMETHING TO FIX THIS PROBLEM ONCE AND FOR ALL. IT HAS BEEN TOO MUCH LENIENCY FOR THIS MANUFACTURER AND LOTS OF ACCIDENTS DUE TO THIS MANUFACTURER'S DEFECT.
NHTSA ODI #11072822
97,800 miles · Aug 9, 2016
Service BrakesVehicle Speed Control
I WAS BACKING INTO A PARKING SPACE WITH THE FOOT ON THE BREAK WHEN MY CAR SUDDENLY ACCELERATED BACK AND I HIT THE WALL. I LOOKED DOWN TO SEE IF MY FOOT WAS ON THE GAS BUT IT WAS ON THE BREAK. I GOT OUT AND LOOKED AT THE CAR BUT SINCE I WAS CLOSE TO THE WALL THERE WAS NO DAMAGE. THIS WAS TWO DAYS AGO. FORWARD TO TODAY, I PULLED O…
Read full complaint
I WAS BACKING INTO A PARKING SPACE WITH THE FOOT ON THE BREAK WHEN MY CAR SUDDENLY ACCELERATED BACK AND I HIT THE WALL. I LOOKED DOWN TO SEE IF MY FOOT WAS ON THE GAS BUT IT WAS ON THE BREAK. I GOT OUT AND LOOKED AT THE CAR BUT SINCE I WAS CLOSE TO THE WALL THERE WAS NO DAMAGE. THIS WAS TWO DAYS AGO. FORWARD TO TODAY, I PULLED OUT OF MY PARKING SPOT ON THE STREET. I PUT MY FOOT ON THE BRAKE AT THE INTERSECTION TO CHECK FOR TRAFFIC, WHEN I APPLIED THE BREAK, THE ENGINE REVVED AND THE CAR ACCELERATED ABOUT A FOOT AND STOPPED. SO WHILE GOING TO MY DESTINATION I HAD TO STOP SIGNIFICANTLY FAR AWAY FROM CARS, INTERSECTIONS OR ANYTHING ELSE BECAUSE WHEN I BREAK. THE CAR ACCELERATES 1-2 FEELS AT A VERY HIGH SPEED BEFORE JERKING TO A STOP. THE CAR IS NOW PARKED BECAUSE IT IS UNSAFE TO DRIVE.
NHTSA ODI #10894626
138,000 miles · Jun 8, 2016
Service Brakes
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. WHILE DRIVING AT AN UNKNOWN SPEED AND ATTEMPTING TO BRAKE, THE BRAKE PEDAL FAILED TO DEPRESS AND THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. WHILE DRIVING AT AN UNKNOWN SPEED AND ATTEMPTING TO BRAKE, THE BRAKE PEDAL FAILED TO DEPRESS AND THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,000. ...UPDATED 09/14/16 *BF *CN
NHTSA ODI #10873229
168,000 miles · Apr 10, 2016
EngineService Brakes
THE EXHAUST MANIFOLD ON MY 2002 TOYOTA CAMRY WITH 2.4L CRACKED. IT SEEMS TO BE A COMMON PROBLEM ON THESE CARS. MY CAMRY ONLY HAD A LITTLE OVER 60,000 MILES WHEN IT HAPPENED. OTHER TOYOTA CARS HAVE BEEN RECALLED FOR THE SAME PROBLEMS. BRAKE NEED LONG DISTANCE.
NHTSA ODI #10854622
145,000 miles · Feb 16, 2016
Service BrakesCrash
BRAKE FAILED WHILE ON THE ROAD, CAR CRASHED. ABNORMAL LONG DISTANCE BRAKE. COULD'VE DIED
NHTSA ODI #10836309
125,000 miles · Jan 27, 2016
Electrical SystemService BrakesUnknown Or Other
PLEASE HELP ME. I PURCHASED MY CAR FROM TOYOTA SUPERSTORE IN HARTFORD CT FEBRUARY 9,2005 NEW. THE CAR SHUTS OFF WHILE IN DRIVE.THERE ARE 3 LIGHT THAT COMES ON; CHECK ENGINE LIGHT, THE BATTERY AND THE GAS LIGHT . THIS PROBLEM HAS BEEN GOING ON SINCE THE FIRST WEDNESDAY OF 2013. TI WAS AN INTERMITTENT PROBLEM . NOW IT 21016 AND I…
Read full complaint
PLEASE HELP ME. I PURCHASED MY CAR FROM TOYOTA SUPERSTORE IN HARTFORD CT FEBRUARY 9,2005 NEW. THE CAR SHUTS OFF WHILE IN DRIVE.THERE ARE 3 LIGHT THAT COMES ON; CHECK ENGINE LIGHT, THE BATTERY AND THE GAS LIGHT . THIS PROBLEM HAS BEEN GOING ON SINCE THE FIRST WEDNESDAY OF 2013. TI WAS AN INTERMITTENT PROBLEM . NOW IT 21016 AND IT A FREQUENT ANNOYANCE. THEY DID NOT TRY TO HELP ME WITH ANY RECALL ISSUES. MY CAR HAS 5 RECALLED ITEMS ON THIS VEHICLE BUT ALL OF THESE WERE ISSUES THAT I ADDRESS OUT OF MY POCKET. YOU ISSUED THOSE RECALL AFTER MY MONIES WERE SPENT TO CARRY ON DIAGNOSTICS, AND THE CHANGING OF PARTS THAT HAD NO BEARING ON THE PROBLEM. WHILE CUSTOMER LIKE MYSELF SPEND AND SPEND AND SPEND.THIS CAR WAS $30,000 AND BECAUSE I HAD DONE A TRADE IN UNFAIRLY GOOD CONDITION. I WAS ABLE TO TO GET IT FOR $2000 LESS. I NEED YOUR INTERVENTION IN THE MATTER. I AM CERTAIN I AM NOT THE ONLY ONE IN AMERICA WITH THIS ISSUE. IT IS APPALLING THAT TOYOTA MAKE THESE DEFECTIVE VEHICLES AND SELL THEM WITH THE HOPES THAT AT 100,00 MILES YOU ARE GOING TO HAVE TO GET RID OF THE VEHICLE BECAUSE IT BEGINS TO BREAK ON YOU. NO ONE IN AMERICA IS WILLING TO DRIVE A CAR LIKE MINE, BUT I CANNOT DO ANY BETTER. MY FAMILY KEEPS SAYING I SHOULD GET RID OF THE CAR BECAUSE THE MONEY I AM SPENDING ON IT COME BUY A NEW ONE BUT I CANNOT AFFORD CAR PAYMENT RIGHT NOW. MY ECONOMICS IS NOT THE BEST. WHEN I PURCHASED THIS VEHICLE I DID SO BELIEVING THAT THIS VEHICLE WOULD LAST A CONSIDERABLY LONG TIME. MY CONFIDENCE WAS BASED ON THE REPUTATION OF A COMPANY THAT HAD INTEGRITY AND WHOLESOME FAMILY VALUES. I AM RELIANT ON A CAR TO GET ME FROM POINT A TO B. I TAKE MY CLIENT TO SEE HOUSES AND I NEED A GOOD FUNCTIONING CAR TO CONDUCT BUSINESS. I NEED A GOOD FUNCTIONING CAR TO MAKE MONEY. I NEED A WELL FUNCTIONING CAR TO TAKE CARE OF MY SAFETY ON THE ROADWAY AT NIGHTS. PLEASE INTERVENE IN THIS MATTER.
NHTSA ODI #10822704
118 miles · Mar 13, 2015
Service BrakesSteeringVehicle Speed Control
WHILE DRIVING ON HIGHWAY CAR RIDE IS JERKY . AT ANY LEFT EXIT THE CAR SHUTS OFF ON EXIT RAMP ON LEFT TURN. STEERING TIGHTENS AND LOCK-UP. THE CAR SHUTS DONE WHILE STILL IN DRIVE MODE. THE ENGINE GOES QUITE AND DIES.THE GAS PEDAL STOP PRODUCING POWER. THE CAR SHUTS OFF COMPLETELY WITH KEY IN IGNITION AND STILL IN DRIVE . ALSO GO…
Read full complaint
WHILE DRIVING ON HIGHWAY CAR RIDE IS JERKY . AT ANY LEFT EXIT THE CAR SHUTS OFF ON EXIT RAMP ON LEFT TURN. STEERING TIGHTENS AND LOCK-UP. THE CAR SHUTS DONE WHILE STILL IN DRIVE MODE. THE ENGINE GOES QUITE AND DIES.THE GAS PEDAL STOP PRODUCING POWER. THE CAR SHUTS OFF COMPLETELY WITH KEY IN IGNITION AND STILL IN DRIVE . ALSO GOING DOWN HILL THE CAR BECOMES IMMOBILE AND STALL. ON OTHER OCCASIONS CAR STALL AT LIGHTS ON LOCAL ROADS SHORTLY AFTER MAKING LEFT TURNS AND STOP LIGHT. I TOOK THE VEHICLE INTO TOYOTA SUPERSTORE WESTON ST HARTFORD CT. ON THREE OCCASIONS. THEY KEPT IT FOR A DAY, TWO DAYS, A WEEK AND THERE IS STILL NO SOLUTION. . NOTHING HAS BEEN DONE TO STOP THE CONDITION. I TOOK IT TO LOCAL MECHANICS, AUTO ZONE. THEY SEE THE CAR ACT UP BUT THERE ARE NO CODES AND NO SYSTEM ERROR ACTIVITY SUMMARY. DEALERSHIP OFFER NO SOLUTION . ALWAYS THERE ARE 3 LIGHT THAT COMES ON. CHECK ENGINE LIGHT, CHECK BATTERY LIGHT AND CHECK FUEL LIGHT . TRIPLE A TOLL THIS CAT ON 3 OCCASIONS. ON ONE OCCASION DURING THE SNOW IT HAD CHECK TRACTION LIGHT CAME ON. PLEASE SOMEONE HELP ME. I TOOK MY CAR IN TO THE DEALERSHIP ALWAYS TO GET THE NECESSARY OIL CHANGE BECAUSE I HAVE LIFETIME OIL AND LUBE. THEY ARE THE ONES SERVICING THE CAR SO IF ANY PARTS GO WRONG THEY ARE THE ONES CHANGING THEM.. THEY WANT ME TO BUY A NEW CAR. I TOLD THEM I CANNOT AFFORD ONE. I WONDER IF THEY ARE SABOTAGING MY CAR. IN HOPES THAT I WILL PURCHASE A NEW ONE. PLEASE HELP ME! I LEARNED THAT THE CAR STOPS AND STARTS UP AGAIN AFTER YOU SHUT IT DOWN TAKE THE KEY OUT OF THE IGNITION FOR A WHILE SO THIS IS HOW I AM SURVIVING. THIS IS VERY SCARY! HELP! *TR
NHTSA ODI #10694025
Mileage unknown · Sep 16, 2013
Service BrakesVehicle Speed ControlCrash
ON THE EVENING ON AUGUST 30, 2013, MY WIFE AND I WERE INVOLVED IN AN AUTO ACCIDENT DUE TO A SUDDEN UNINTENDED ACCELERATION PROBLEM WITH OUR 2002 TOYOTA CAMRY. I WAS DRIVING AT A LOW SPEED AROUND A CUL-DE-SAC WHEN THE CAR ACCELERATED OUT OF MY CONTROL AND CRASHED INTO A TREE. I PRESSED THE BRAKE A FEW TIMES BUT IT WAS INEFFECTI…
Read full complaint
ON THE EVENING ON AUGUST 30, 2013, MY WIFE AND I WERE INVOLVED IN AN AUTO ACCIDENT DUE TO A SUDDEN UNINTENDED ACCELERATION PROBLEM WITH OUR 2002 TOYOTA CAMRY. I WAS DRIVING AT A LOW SPEED AROUND A CUL-DE-SAC WHEN THE CAR ACCELERATED OUT OF MY CONTROL AND CRASHED INTO A TREE. I PRESSED THE BRAKE A FEW TIMES BUT IT WAS INEFFECTIVE. THE CRASH DESTROYED THE CAR AND IS DETERMINED TO BE A "TOTAL LOSS." *TR
NHTSA ODI #10543880
Official recalls
4Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Dec 11, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE.
Consequence & remedy
Consequence: IF THIS SHOULD OCCUR, THERE IS A POSSIBILITY THAT THE DETACHED BOTTOM PORTION MAY STRIKE THE DRIVER CAUSING PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE AIR BAG MODULE. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-888-333-9376.
Oct 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES. THE TIRES WERE DAMAGED DURING A PORT UPGRADE TO ALUMINUM WHEELS.
Consequence & remedy
Consequence: THE TIRES DO NOT CONFORM TO THE SPEED RATING FOR THE VEHICLE. IF THE VEHICLE EXCEEDED THE MAXIMUM SPEED RATING (112 MPH), POSSIBLE TIRE FAILURE COULD OCCUR.
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Sep 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE AIR BAG ASSEMBLY. BOTH OWNERS WERE NOTIFIED BY TELEPHONE AND ARRANGEMENTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. THIS CAMPAIGN IS 100% COMPLETED. BOTH OWNERS HAVE BEEN NOTIFIED AND THEIR VEHICLES REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
PE04021 · Throttle Control System
Opened Mar 3, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control
THE LEXUS MODELS WERE THE SUBJECT OF DEFECT PETITION (DP) 04-003.TWELVE ODI COMPLAINTS ARE DUPLICATIVE TO TOYOTA REPORTS, INCLUDING THE TWO MINOR CRASHES.THE V6 EQUIPPED SOLARA MODELS HAVE BEEN EXCLUDED BECAUSE THEY DO NOT CONTAIN THE SUBJECT THROTTLE CONTROL SYSTEM.TOYOTA INTRODUCED ELECTRONIC THROTTLE CONTROL (ETC) ON THE SUBJECT VEHICLES BEGINNING IN MODEL YEAR (MY) 2002.ODI OPENED THE INVESTIGATION TO DETERMINE IF THE SYSTEM COULD BE THE CAUSE OF COMPLAINTS ALLEGING THE ENGINE SPEED INCREASED, OR FAILED TO DECREASE, (FOR A SHORT DURATION) WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED (THE ALLEGED DEFECT).DURING THE COURSE OF THE INVESTIGATION, ODI ANALYZED AGENCY DATA AND REVIEWED VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS, CONDUCTED INTERVIEWS INVOLVING 113 VOQ AND 36 TOYOTA REPORTS, INSPECTED TWO COMPLAINANT VEHICLES, REVIEWED RELEVANT TOYOTA SERVICE AND NEW CAR FEATURE DOCUMENTATION, REVIEWED AND ANALYZED TOYOTA?S RESPONSES TO ODI?S INFORMATION REQUEST LETTER, CONDUCTED A LIMITED CONTROL PEDAL ASSESSMENT, AND ATTENDED A TOYOTA TECHNICAL PRESENTATION THAT INCLUDED THE ASSESSMENT OF TWO DEMONSTRATION VEHICLES.THROUGH INTERVIEWS, ODI IDENTIFIED 14 VOQ AND 6 TOYOTA REPORTS (20 UNIQUE VEHICLES) WHERE COMPLAINANTS REPORT MULTIPLE OCCURRENCES OF THE ALLEGED DEFECT.IN SOME CASES THE CONDITION WAS EXPERIENCED BY DIFFERENT VEHICLE OPERATORS OR WAS WITNESSED BY OTHER OCCUPANTS.ODI WAS UNABLE TO MAKE A DETERMINATION AS TO THE CAUSE OF 9 TOYOTA AND AN ADDITIONAL 37 VOQ REPORTS (WHICH DESCRIBE 28 UNIQUE INCIDENTS) DUE TO INSUFFICIENT INFORMATION.THE REMAINING COMPLAINANTS INTERVIEWED (62 VOQ, 21 TOYOTA) DESCRIBED CONDITIONS NOT CAUSED BY A FAILURE OF THE THROTTLE CONTROL SYSTEM AND WERE THUS CONSIDERED UNRELATED TO THE INVESTIGATION.NONE OF THE COMPLAINANTS INTERVIEWED REPORTED A COMPONENT FAILURE (OR OTHER INDICATOR OF A SYSTEM FAILURE) AS THE POTENTIAL CAUSE OF INCIDENTS RELEVANT TO THIS INVESTIGATION.IN MANY CASES, THE COMPLAINT VEHICLES WERE SUBSEQUENTLY INSPECTED BY DEALERSHIP OR MANUFACTURER REPRESENTATIVES WHO ALSO FAILED TO IDENTIFY A FAULT WITHIN THE VEHICLE.TOYOTA IDENTIFIED 43 RELATED WARRANTY CLAIMS, 24 OF WHICH WERE FOR DIAGNOSTIC PURPOSES ONLY (NO REPAIRS PERFORMED).ODI FOUND NOTHING ABNORMAL IN THE CONTROL PEDAL CONFIGURATION OF THE SUBJECT VEHICLES.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ATTACHED SUMMARY FOR FURTHER DETAIL.
PE02079 · Engine Compartment Fire
Opened Oct 22, 2002 · Closed Mar 18, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI'S DATA ANALYSIS FOUND THE FIRES RATES TO BE CONSISTENTLY LOW AND EVENLY DISTRIBUTED AMONG SIX MODEL YEARS AND SIX DIFFERENT ENGINE CONFIGURATIONS.ODI EXAMINED A VARIETY OF ROOT CAUSES, THOSE BEING DETONATION (RESULTING IN OIL PAN PUNCTURE FROM CONNECTING ROD), STARTER FIRES, VARIOUS FUEL RELATED FIRES, LEAKING OIL FILTERS, WIRING ISSUES, IMPROPER REPAIRS AND BRAKE FLUID LEAKS.NONE OF THE ISSUES EXAMINED HAD REPORTS THAT INDICATED A TREND WHEN NORMALIZED FOR POPULATON AND EXPOSURE.SEE ATTACHED REPORT FOR FULL DETAILS.
Illustration