IllustrationVEHICLE DIES IN MIDDLE OF THE ROAD WHEN IDLING. THIS ALMOST CAUSED AN ACCIDENT A FEW DAYS BACK. I AM TOLD THIS IS THE FAILED THROTTLE BODY (APPARENTLY A DEFECTIVE PART) WHICH HAS ALREADY BEEN REPLACED ONCE ON MY VEHICLE. *TR
2002 Toyota Camry
Owner reports · Recalls · Investigations
More warning signs than most Camry years
Owner complaints for the 2002 Toyota Camry are substantially higher than the model-year median of 295.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1860–25K
11025–50K
8750–75K
8175–100K
96100–150K
50150K+
610 reports with mileage · 343 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
252 crash reports20 fire reports94 injury reports
Fuel System, Other complaints
7 reportsI HAVE A 2002 TOYOTA CAMRY. UPON PULLING INTO A PARKING STALL I APPLIED THE BRAKES TO SLOW DOWN AS NORMALLY DONE WHEN PARKING. AT THIS TIME THE CAR LURCHED FORWARD, THE ENGINE RACED, THE CAR HOPPED THE CURB AND HIT A BUILDING. I BELIEVE THIS COULD BE TIED TO THE CURRENT GAS PEDAL RECALL. I HAVE A WITNESSES THAT WILL ATTEST …
Read full complaint
I HAVE A 2002 TOYOTA CAMRY. UPON PULLING INTO A PARKING STALL I APPLIED THE BRAKES TO SLOW DOWN AS NORMALLY DONE WHEN PARKING. AT THIS TIME THE CAR LURCHED FORWARD, THE ENGINE RACED, THE CAR HOPPED THE CURB AND HIT A BUILDING. I BELIEVE THIS COULD BE TIED TO THE CURRENT GAS PEDAL RECALL. I HAVE A WITNESSES THAT WILL ATTEST TO THE FACT THAT DURING THIS WHOLE SCENERIO MY BRAKE LIGHTS WERE ON THE WHOLE TIME. *TR
2002 TOYOTA CAMRY EMISSIONS CONTROL SYSTEM FAILURE. CAMRY WITH 128,000 MILES WITH CHECK ENGINE LIGHT ON. DEALER SAID IT WILL COST ABOUT $1000 TO REPAIR. CHARCOAL CANNISTER FAILURE, EMISSION VALVES AND FUEL FILLER NECK FAILURE. *TR
THIS ACCIDENT OCCURRED IN MY GARAGE. I HAD BACKED THE CAR OUT OF THE GARAGE AND LEFT THE ENGINE RUNNING WITH THE CAR IN PARK WHILE I REMOVED THE GARBAGE CONTAINER AND UPON RETURNING TO MY CAR ABOUT 1 MINUTE LATER, I PLACED MY FOOT ON THE BRAKE PEDAL AND SHIFTED THE CAR INTO DRIVE. IMMEDIATELY, THE CAR ACCELERATED FORWARD AT A VE…
Read full complaint
THIS ACCIDENT OCCURRED IN MY GARAGE. I HAD BACKED THE CAR OUT OF THE GARAGE AND LEFT THE ENGINE RUNNING WITH THE CAR IN PARK WHILE I REMOVED THE GARBAGE CONTAINER AND UPON RETURNING TO MY CAR ABOUT 1 MINUTE LATER, I PLACED MY FOOT ON THE BRAKE PEDAL AND SHIFTED THE CAR INTO DRIVE. IMMEDIATELY, THE CAR ACCELERATED FORWARD AT A VERY HIGH SPEED AND DESPITE THE FACT THAT MY FOOT REMAINED ON THE BRAKE PEDAL, IT DID NOT STOP AND CRASHED INTO THE CONCRETE WALL AT THE REAR OF MY GARAGE. THE AIR BAGS DEPLOYED MINIMIZING MY INJURIES. THE CAR WAS TOTALED BY MY INSURANCE COMPANY - THE FRONT END WAS BADLY SMASHED AND THE FRAME WAS BENT. THE TOTAL ESTIMATE TO REPAIR WAS IN EXCESS OF $9000. THE TOTAL TRAVEL OF THE CAR WAS 26 FEET. I HAVE NO IDEA HOW FAST THE CAR ACCELERATED TO, HOWEVER IN THE 60,000 MILES THAT WE HAD DRIVEN THE CAR, I HAD NEVER EXPERIENCED THIS HIGH DEGREE OF ACCELERATION. PLEASE NOTE THAT WHEN I HAD FIRST RE-ENTERED THE CAR JUST PRIOR TO THE CRASH, THERE WAS NO INDICATION OF A FAST ENGINE IDLE AT ALL. ALSO, I OBSERVED AFTER THE CRASH THAT MY FOOT WAS STILL ON THE BRAKE PEDAL AND THERE WAS NO INDICATION OF ANYTHING LODGED BENEATH THE BRAKE PEDAL. *TR
1. LOUD CREAKING AND RATTLES: AFTER MANY ATTEMPTS AT REPAIRS, THE PROBLEM FINALLY TURNED OUT TO BE A MANUFACTURING DEFECT. THEY LEFT PLASTIC ASSEMBLY GUIDES IN PLACE, WHICH THEY HAD TO REMOVE BY REMOVING THE WINDOW AGAIN (THIS WAS A SUPER SECRET SERVICE BULLETIN THAT WAS DIVULGED ONLY WHEN THE CUSTOMER ENGINEER FOR NEW ENGLAN…
Read full complaint
1. LOUD CREAKING AND RATTLES: AFTER MANY ATTEMPTS AT REPAIRS, THE PROBLEM FINALLY TURNED OUT TO BE A MANUFACTURING DEFECT. THEY LEFT PLASTIC ASSEMBLY GUIDES IN PLACE, WHICH THEY HAD TO REMOVE BY REMOVING THE WINDOW AGAIN (THIS WAS A SUPER SECRET SERVICE BULLETIN THAT WAS DIVULGED ONLY WHEN THE CUSTOMER ENGINEER FOR NEW ENGLAND SHOWED UP). BUT HE DEALERSHIP MANAGED TO CHIP THE PAINT IN THE PROCESS, REQUIRING THE ROOF TO BE REPAINTED. ONCE THE CREAK WAS GONE, THE INTERIOR RATTLES WERE UNBEARABLE FROM ALL THE QUALITY WORK COMPLETED. 2. TRANSMISSION ISSUE: I'VE BEEN ASSURED BY THE SERVICE MANAGER AT ME DEALERSHIP THAT IT IS NORMAL THE TRANSMISSION TAKE AT LEAST A MILE SHIFT OUT OF SECOND GEAR WHEN BELOW 30F AND TO A LESSER DEGREE DURING WARM WEATHER. THE CAR WON'T SHIFT INTO THIRD OR OVERDRIVEN UNTIL AFTER LEAST 1-2 MINUTE OF DRIVING, NO MATTER WHAT SPEED. 3. TRANSMISSION ISSUE: WHEN LIFTING OFF THE THROTTLE FROM 60 TO 55MPH ON A DOWNHILL, THERE'S A "HITCH" OR BUCKING WHERE THE TRANSMISSION ABRUPTLY CATCHES, THEN RELEASES. ALMOST LIKE IT DOWN SHIFTING, BUT IT STOPS HALF WAY. THIS HAS BEEN AN ANNOYING PROBLEM SINCE DAY ONE. THE BUCKING PROBLEM IS ANNOYING AND PROBLEMATIC. IT WAS SOLVED BY RESET THE COMPUTER AND SHOWED UP AGAIN AT 42,000 MILES. THEY ARE BLAMING IT ON THE ADAPTIVE MICRO-PROCESSOR AND MY DRIVING STYLE. (WARRANTY) 4. DOOR RATTLES: DRIVER'S SIDE AND PASSENGER SIDE DOORS RATTLE/TICK WHEN GOING OVER BUMPS. I ASKED THE SERVICE MANAGER THAT WAS LET GO ABOUT THE RATTLE, AND HE EXPLAINED IT'S NORMAL FOR NEW CAMRY'S TO HAVE THE DOORS MAKE THAT MAKE NOISE. CONSTANT USE OF SILICONE WAS ADVISED BY THE DEALERSHIP. 5. AIRBAG RECALL 6. PASSENGER SEAT REPLACEMENT DUE TO POOR CONSTRUCTION AND SQUEAKING 7. CHECK ENGINE LIGHT FOR DEFECTIVE CHARCOAL CANISTER 8. WARPED FRONT BRAKE ROTORS 9. PEALING CHROME ON PASSENGER DOOR HANDLE. (WARRANTY) 10. FLAKING PAINT ON EXTERIOR DOOR HANDLES. * CB
CAR DIED WHILE TRAVELING APPROXIMATELY 40 MPH AROUND A CURVE. POWER STEERING WENT OUT AND CAR NEARLY HIT THE CURB AND SEVERAL PARKED CARS. TOOK VEHICLE TO TOYOTA WHO REFUSED TO FIX IT UNDER WARRANTY, BECAUSE THEY SAID IT WAS CONSUMER'S FAULT THAT IT HAPPENED. THEY SAID THAT FUEL GOT INTO THE CHARCOAL CANISTER, WHICH THEY CLAI…
Read full complaint
CAR DIED WHILE TRAVELING APPROXIMATELY 40 MPH AROUND A CURVE. POWER STEERING WENT OUT AND CAR NEARLY HIT THE CURB AND SEVERAL PARKED CARS. TOOK VEHICLE TO TOYOTA WHO REFUSED TO FIX IT UNDER WARRANTY, BECAUSE THEY SAID IT WAS CONSUMER'S FAULT THAT IT HAPPENED. THEY SAID THAT FUEL GOT INTO THE CHARCOAL CANISTER, WHICH THEY CLAIMED TO BE EVIDENCE THAT CONSUMER TOPPED OFF AT THE GAS PUMP. I TOLD THEM THAT I NEVER TOPPED OFF (FOR ENVIRONMENTAL REASONS AS WELL AS VEHICLE PROTECTION), AND THEY SAID IT ALSO COULD HAVE BEEN BECAUSE THE CAR SAT AT AN ANGLE IN THE DRIVE WAY BUT THAT THEY STILL WOULDN'T FIX IT. *TT
SULFUR ODOR INSIDE CAR
Official recalls
404V346000 · Air Bags:side/window
Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
01V372000 · Air Bags:frontal
Dec 11, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE.
Consequence & remedy
Consequence: IF THIS SHOULD OCCUR, THERE IS A POSSIBILITY THAT THE DETACHED BOTTOM PORTION MAY STRIKE THE DRIVER CAUSING PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE AIR BAG MODULE. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-888-333-9376.
01V302000 · Tires
Oct 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES. THE TIRES WERE DAMAGED DURING A PORT UPGRADE TO ALUMINUM WHEELS.
Consequence & remedy
Consequence: THE TIRES DO NOT CONFORM TO THE SPEED RATING FOR THE VEHICLE. IF THE VEHICLE EXCEEDED THE MAXIMUM SPEED RATING (112 MPH), POSSIBLE TIRE FAILURE COULD OCCUR.
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
01V306000 · Air Bags:frontal
Sep 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE AIR BAG ASSEMBLY. BOTH OWNERS WERE NOTIFIED BY TELEPHONE AND ARRANGEMENTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. THIS CAMPAIGN IS 100% COMPLETED. BOTH OWNERS HAVE BEEN NOTIFIED AND THEIR VEHICLES REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
PE04021 · Throttle Control System
Opened Mar 3, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control
THE LEXUS MODELS WERE THE SUBJECT OF DEFECT PETITION (DP) 04-003.TWELVE ODI COMPLAINTS ARE DUPLICATIVE TO TOYOTA REPORTS, INCLUDING THE TWO MINOR CRASHES.THE V6 EQUIPPED SOLARA MODELS HAVE BEEN EXCLUDED BECAUSE THEY DO NOT CONTAIN THE SUBJECT THROTTLE CONTROL SYSTEM.TOYOTA INTRODUCED ELECTRONIC THROTTLE CONTROL (ETC) ON THE SUBJECT VEHICLES BEGINNING IN MODEL YEAR (MY) 2002.ODI OPENED THE INVESTIGATION TO DETERMINE IF THE SYSTEM COULD BE THE CAUSE OF COMPLAINTS ALLEGING THE ENGINE SPEED INCREASED, OR FAILED TO DECREASE, (FOR A SHORT DURATION) WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED (THE ALLEGED DEFECT).DURING THE COURSE OF THE INVESTIGATION, ODI ANALYZED AGENCY DATA AND REVIEWED VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS, CONDUCTED INTERVIEWS INVOLVING 113 VOQ AND 36 TOYOTA REPORTS, INSPECTED TWO COMPLAINANT VEHICLES, REVIEWED RELEVANT TOYOTA SERVICE AND NEW CAR FEATURE DOCUMENTATION, REVIEWED AND ANALYZED TOYOTA?S RESPONSES TO ODI?S INFORMATION REQUEST LETTER, CONDUCTED A LIMITED CONTROL PEDAL ASSESSMENT, AND ATTENDED A TOYOTA TECHNICAL PRESENTATION THAT INCLUDED THE ASSESSMENT OF TWO DEMONSTRATION VEHICLES.THROUGH INTERVIEWS, ODI IDENTIFIED 14 VOQ AND 6 TOYOTA REPORTS (20 UNIQUE VEHICLES) WHERE COMPLAINANTS REPORT MULTIPLE OCCURRENCES OF THE ALLEGED DEFECT.IN SOME CASES THE CONDITION WAS EXPERIENCED BY DIFFERENT VEHICLE OPERATORS OR WAS WITNESSED BY OTHER OCCUPANTS.ODI WAS UNABLE TO MAKE A DETERMINATION AS TO THE CAUSE OF 9 TOYOTA AND AN ADDITIONAL 37 VOQ REPORTS (WHICH DESCRIBE 28 UNIQUE INCIDENTS) DUE TO INSUFFICIENT INFORMATION.THE REMAINING COMPLAINANTS INTERVIEWED (62 VOQ, 21 TOYOTA) DESCRIBED CONDITIONS NOT CAUSED BY A FAILURE OF THE THROTTLE CONTROL SYSTEM AND WERE THUS CONSIDERED UNRELATED TO THE INVESTIGATION.NONE OF THE COMPLAINANTS INTERVIEWED REPORTED A COMPONENT FAILURE (OR OTHER INDICATOR OF A SYSTEM FAILURE) AS THE POTENTIAL CAUSE OF INCIDENTS RELEVANT TO THIS INVESTIGATION.IN MANY CASES, THE COMPLAINT VEHICLES WERE SUBSEQUENTLY INSPECTED BY DEALERSHIP OR MANUFACTURER REPRESENTATIVES WHO ALSO FAILED TO IDENTIFY A FAULT WITHIN THE VEHICLE.TOYOTA IDENTIFIED 43 RELATED WARRANTY CLAIMS, 24 OF WHICH WERE FOR DIAGNOSTIC PURPOSES ONLY (NO REPAIRS PERFORMED).ODI FOUND NOTHING ABNORMAL IN THE CONTROL PEDAL CONFIGURATION OF THE SUBJECT VEHICLES.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ATTACHED SUMMARY FOR FURTHER DETAIL.
PE02079 · Engine Compartment Fire
Opened Oct 22, 2002 · Closed Mar 18, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI'S DATA ANALYSIS FOUND THE FIRES RATES TO BE CONSISTENTLY LOW AND EVENLY DISTRIBUTED AMONG SIX MODEL YEARS AND SIX DIFFERENT ENGINE CONFIGURATIONS.ODI EXAMINED A VARIETY OF ROOT CAUSES, THOSE BEING DETONATION (RESULTING IN OIL PAN PUNCTURE FROM CONNECTING ROD), STARTER FIRES, VARIOUS FUEL RELATED FIRES, LEAKING OIL FILTERS, WIRING ISSUES, IMPROPER REPAIRS AND BRAKE FLUID LEAKS.NONE OF THE ISSUES EXAMINED HAD REPORTS THAT INDICATED A TREND WHEN NORMALIZED FOR POPULATON AND EXPOSURE.SEE ATTACHED REPORT FOR FULL DETAILS.