NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
89 reportsClear category filter160,000 miles · Aug 10, 2015
Air Bags
WHILE DRIVING ON THE FREEWAY THE PASSENGER SIDE AIR BAG STARTED TO PULSATE AND STARTED TO RIP THE AIR BAG COVER OPEN, PULLED THE CAR OVER TO THE BRAKE DOWN LANE AND CALLED A TOYOTA DEALERSHIP. ALL THEY SAID WAS THER IS NO RECALL ON THAT VIN # THANKS FOR THE CONCERN TOYOTA! I AM AFRAID THAT AIR BAG WILL DEPLOY WILE CAR IS IN OPER…
Read full complaint
WHILE DRIVING ON THE FREEWAY THE PASSENGER SIDE AIR BAG STARTED TO PULSATE AND STARTED TO RIP THE AIR BAG COVER OPEN, PULLED THE CAR OVER TO THE BRAKE DOWN LANE AND CALLED A TOYOTA DEALERSHIP. ALL THEY SAID WAS THER IS NO RECALL ON THAT VIN # THANKS FOR THE CONCERN TOYOTA! I AM AFRAID THAT AIR BAG WILL DEPLOY WILE CAR IS IN OPERATION.
NHTSA ODI #10747638
155,000 miles · May 24, 2015
Air BagsExterior LightingStructureCrashInjury
I HAD A WRECK IN JAN., 7TH, 2005. I WAS TRAVELING BELOW THE SPEED LIMIT AND THE LADY IN FRONT OF ME WAS DEAD STOPPED AND I COLD NOT STOP MY CAR. I HIT HER STOPPED CAR, DOING 45 MPH AND MY AIRBAGS DID NOT DEPLOY! NOW THE AIRBAG ON THE PASSENGER SIDE, IS NOT RIGHT. IT HAS MOVED AND SEPARATED AS IF IT IS ABOUT TO POP OPEN, SINCE …
Read full complaint
I HAD A WRECK IN JAN., 7TH, 2005. I WAS TRAVELING BELOW THE SPEED LIMIT AND THE LADY IN FRONT OF ME WAS DEAD STOPPED AND I COLD NOT STOP MY CAR. I HIT HER STOPPED CAR, DOING 45 MPH AND MY AIRBAGS DID NOT DEPLOY! NOW THE AIRBAG ON THE PASSENGER SIDE, IS NOT RIGHT. IT HAS MOVED AND SEPARATED AS IF IT IS ABOUT TO POP OPEN, SINCE THE WRECK AND THE PEOPLE THAT DID THE SERVICE ON MY CAR TO FIX THE FRONT END (VIA MY INSURANCE CO. - USAA) HAVE HAD IT LOOKED AT AND THEY WILL NOT DO ANYTHING ABOUT IT. THE COVER HAS MOVED EVEN MORE, SINCE MY WRECK IN JAN. 7TH, 2015 AND I AM REALLY SCARED. MY 84 YEAR OLD MOTHER AND MY SERVICE DOG RIDE IN THE PASSENGER SEAT. PLEASE HELP ME BEFORE IT DEPLOYS IN HER FACE!
NHTSA ODI #10721251
230,000 miles · Jan 4, 2015
Air Bags
APROX. TWO YEARS AFTER PURCHASING THE VEHICLE NEW..A SMALL TEAR...STARTED ON THE PASSENGER FRONT AIRBAG..PRESENTLY IT HAS INCREASED IN SIZE OF THE TEAR.. A LOT WORSE..I'M CONCERNED FOR THE SAFTEY OF OCCUPANTS. *TR
NHTSA ODI #10670001
52,000 miles · Dec 23, 2014
Air BagsStructureCrashInjury
I WAS DRIVING SOUTHBOUND ON LAKESHORE DR WHEN WITH NO WARNING OF A TURN SIGNAL A TOW TRUCK DRIVER CUT ME OFF AND SLOWED ALMOST TO A COMPLETE STOP. I HAD NO CHOICE BUT TO BRACE FOR IMPACT AS I STOMPED DOWN ON MY BRAKES. THE ENTIRE FRONT END OF MY CAR WAS TOTALED AS THE FRONT RIGHT END OF MY CAR MADE IMPACT WITH THE LEFT REAR END …
Read full complaint
I WAS DRIVING SOUTHBOUND ON LAKESHORE DR WHEN WITH NO WARNING OF A TURN SIGNAL A TOW TRUCK DRIVER CUT ME OFF AND SLOWED ALMOST TO A COMPLETE STOP. I HAD NO CHOICE BUT TO BRACE FOR IMPACT AS I STOMPED DOWN ON MY BRAKES. THE ENTIRE FRONT END OF MY CAR WAS TOTALED AS THE FRONT RIGHT END OF MY CAR MADE IMPACT WITH THE LEFT REAR END OF HIS TOW TRUCK. AFTER THE DIST SETTLED I LOOKED AROUND AND REALIZED THAT NO AIRBAGS DEPLOYED. I FOUND THIS REALIZATION EXTREMELY ALARMING, NOT ONLY FOR THE CHEST PAIN THAT I WAS EXPERIENCING ON MY RIGHT SIDE WHICH I FELT WAS FROM MY CHEST HITTING THE STEERING WHEEL (EVEN THOUGHT I WAS INDEED WEARING MY SEATBELT) BUT BECAUSE EARLIER THIS YEAR TOYOTA HAD COME OUT WITH A RECALL LIST, AND WHEN I CALLED TO FIND OUT IF MY CAR WAS ON THE RECALL LIST I WAS TOLD NO. I DON'T KNOW HOW MY CAR WAS LOOKED OVER BUT THIS IS A SITUATION THAT SHOULD BE IMMEDIATELY RECTIFIED. THANK GOD MY SITUATION WASN'T WORSE THAN IT WAS AND MY 5 YEAR OLD SON WAS NOT IN THE CAR, BUT THERE ARE OTHERS ON THE ROAD WHO MAY NOT MEET THE SAME OUTCOME. *TR
NHTSA ODI #10668032
Mileage unknown · Dec 11, 2014
Air BagsStructure
PASSENGER AIRBAG IS SEPARATING FROM DASHBOARD. IT'S APPROXIMATELY 3" LONG. BROUGHT VEHICLE INTO DEALERSHIP BUT IT'S NOT CURRENTLY LISTED ON THE RECALL LIST. INSURANCE COMPANY INSPECTED AND VERIFIED THAT IT IS A SAFETY ISSUE. *TR
NHTSA ODI #10663560
Mileage unknown · Nov 16, 2014
Air BagsElectronic Stability Control (esc)WheelsCrash
I WAS ON A RAMP TO I-520 AT A SPEED BETWEEN 45-50 MILES.HR AND THE RAMP IS STRAIGHT. SUDDENLY THE CAR LOST CONTROL AND SPINNING - FINALLY, I NOTICED THE FRONT PASSENGER SIDE TIRE IS FLAT. THE PROBLEM IS THE AIRBAGS WERE NOT DEPLOYED THOUGH THE FRONT (BOTH LEFT AND RIGHT) HIT THE CONCRETE WALL BADLY AND DAMAGED BADLY. ALSO THE AB…
Read full complaint
I WAS ON A RAMP TO I-520 AT A SPEED BETWEEN 45-50 MILES.HR AND THE RAMP IS STRAIGHT. SUDDENLY THE CAR LOST CONTROL AND SPINNING - FINALLY, I NOTICED THE FRONT PASSENGER SIDE TIRE IS FLAT. THE PROBLEM IS THE AIRBAGS WERE NOT DEPLOYED THOUGH THE FRONT (BOTH LEFT AND RIGHT) HIT THE CONCRETE WALL BADLY AND DAMAGED BADLY. ALSO THE ABS WAS NOT ENGAGED. *TR
NHTSA ODI #10655299
Mileage unknown · Nov 3, 2014
Air BagsCrashInjury
DRIVER OF TOYOTA CAMRY 2002 HAD 3 SPOKE STEERING WHEEL AIR BAG WHICH HAD BEEN SUBJECT OF RECALL. FAILED TO INFLATE PROPERLY AND FACE AND NECK OF DRIVER SPRAYED WITH METAL FRAGMENTS ON FACE AND ALL AROUND EYES. DRIVER WAS ON NON-IMPACT SIDE OF RIGHT FRONT IMPACT. DRIVER HOWEVER SUFFERED FAR WORSE FACIAL INJURIES FROM EXPLODING…
Read full complaint
DRIVER OF TOYOTA CAMRY 2002 HAD 3 SPOKE STEERING WHEEL AIR BAG WHICH HAD BEEN SUBJECT OF RECALL. FAILED TO INFLATE PROPERLY AND FACE AND NECK OF DRIVER SPRAYED WITH METAL FRAGMENTS ON FACE AND ALL AROUND EYES. DRIVER WAS ON NON-IMPACT SIDE OF RIGHT FRONT IMPACT. DRIVER HOWEVER SUFFERED FAR WORSE FACIAL INJURIES FROM EXPLODING AIR BAG CANISTER THAN PASSENGER THAT WAS KILLED ON IMPACT SIDE OF CAR FROM OTHER INJURIES. PLASTIC SURGEON PICKED METAL FRAGMENTS OF ALL SIZES OUT OF FACE OF TOYOTA DRIVER FOR OVER 8 HOURS AND SAID IT WAS IMPOSSIBLE TO GET IT ALL. HE COMPARED HER FACE TO BEING SHOT BY A SHOTGUN SEVERAL TIMES FULL OF METAL FRAGMENTS. MRI AND CT SCAN CONFIRM EXTENSIVE METAL STILL LEFT IN FACE OF DRIVER-- ESPECIALLY ALL AROUND EYES, NOSE AND FOREHEAD AREA. PIECES OF METAL IN NECK AS WELL DUE TO THIS DRIVER CAN NEVER HAVE AN MRI AGAIN DUE TO THE METALLIC MAGNETIC DANGER. PLASTIC SURGEON COMMENTED-- WORST FACIAL DAMAGE HE HAD EVER SEEN ON NON IMPACT SIDE OF ACCIDENT. SUSPECTED AIR BAG DEFECT AND CANISTER OF CHARGE FOR AIR BAG EXPLODED DEFECTIVELY-- SENDING HUNDREDS OF METAL FRAGMENTS INTO FACE AND NECK OF DRIVER. ....UPDATED 01/12/15*BF..UPDATED 05-27-15 *BF...UPDATED 06-12-15 *BF UPDATED 6/11/2015 *JS UPDATED 09/01/2017*CN
NHTSA ODI #10651994
125,000 miles · Aug 27, 2013
Air BagsCrashInjury
BOTH FRONT AIR BAGS DID NOT DEPLOY IN A HEAD ON COLLISION. CAR WAS TOTALED AND BOTH PASSENGERS, BELTED IN FRONT SEAT WERE INJURED. *TR
NHTSA ODI #10537482
60,000 miles · May 28, 2013
Air BagsVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE ATTEMPTING A TURN, THE VEHICLE SUDDENLY ACCELERATED AND CAUSED THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT CRASHED INTO THE CURB AND THEN A TREE. THE VEHICLE ROLLED OVER AND THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. THE CON…
Read full complaint
TL* THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT WHILE ATTEMPTING A TURN, THE VEHICLE SUDDENLY ACCELERATED AND CAUSED THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT CRASHED INTO THE CURB AND THEN A TREE. THE VEHICLE ROLLED OVER AND THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED SEVERE INJURIES TO THE LEFT ARM, WHICH WAS PARTIALLY SEPARATED. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 60,000.
NHTSA ODI #10513893
114,000 miles · May 31, 2012
Air Bags
I PURCHASE A 2002 TOYOTA CAMRY IN AUGUST 2003 FROM REINHART TOYOTA IN MONTGOMERY, ALABAMA. THE VEHICLE WAS CERTIFIED USED WITH ONLY ABOUT 19000 ON THE ODOMETER. BECAUSE IT WAS CERTIFIED USED I ASSUMED THAT THE VEHICLE HAD BEEN REVIEWED TO ENSURE THAT IT HAD ALL OF ITS PARTS AND THEY OPERATED PROPERLY. I HAVE DRIVEN THE VEHI…
Read full complaint
I PURCHASE A 2002 TOYOTA CAMRY IN AUGUST 2003 FROM REINHART TOYOTA IN MONTGOMERY, ALABAMA. THE VEHICLE WAS CERTIFIED USED WITH ONLY ABOUT 19000 ON THE ODOMETER. BECAUSE IT WAS CERTIFIED USED I ASSUMED THAT THE VEHICLE HAD BEEN REVIEWED TO ENSURE THAT IT HAD ALL OF ITS PARTS AND THEY OPERATED PROPERLY. I HAVE DRIVEN THE VEHICLE FOR ALMOST NINE YEARS WITHOUT ANY MAJOR ISSUES. ABOUT A YEAR OR TWO AGO, THE AIRBAG LIGHT WOULD COME ON AND STAY ON IN THE VEHICLE WHEN THE CABIN OF THE VEHICLE GOT HOT BUT I DID NOT TAKE IN TO HAVE IT LOOKED AT THAT TIME. UNTIL RECENTLY WHEN I TOOK THE VEHICLE TO BOB HOWARD TOYOTA IN EDMOND, OKLAHOMA TO REPLACE THE DRIVER SIDE DOOR HANDLE (WHICH WAS MY THIRD TIME REPLACING IT) DURING THIS TIME I THOUGHT IT WAS GOOD IDEA TO HAVE THE TECHNICIAN CHECK OUT THE AIRBAG LIGHT ALSO. AFTER THE TECHNICIAN CONDUCTED THEIR REVIEW THEY INFORMED ME THAT MY VEHICLE DID NOT HAVE A PASSENGER SIDE AIRBAG. THEY INSTALLED RESISTORS TO KEEP THE AIRBAG LIGHT FROM COMING ON TO WARNING ME ABOUT THE ISSUE. THIS GAVE ME A FALSE SENSE OF SECURITY BY INTENTIONALLY FALSIFYING INFORMATION ABOUT THE VEHICLE IN ORDER TO EARN A PROFIT, THEREFORE ENDANGERING THE LIVES OF MY FAMILY MEMBERS. IF THE LIGHT WOULD HAVE COME ON BEFORE I BOUGHT THE VEHICLE I WOULD HAVE ASKED ABOUT IT BUT IT DID NOT. IF THEY SELL A CERTIFIED USED VEHICLE AND THEY MENTION THAT IT HAS DUAL-SIDE AIRBAGS, THE CONSUMER SHOULD NOT HAVE TO WORRY ABOUT THE COMPANY LYING TO THEM ABOUT IT. I HAVE DRIVEN THE VEHICLE FOR ABOUT NINE YEARS WITH THE ASSUMPTION I HAD DUAL AIRBAGS IN MY VEHICLE TO RECENTLY FIND OUT THAT I BEEN LIED TO FOR THE PAST NINE YEARS. NOW, I AM BEING HELD RESPONSIBLE FOR A DEFECT THAT SHOULD HAVE BEEN CORRECTED DURING THE CERTIFICATION OF THE VEHICLE. THIS IS UNFAIR HAVE THE CUSTOMER PAY FOR SOMEONE ELSES MISTAKE. THEY ARE NOW REFUSING TO CORRECT THE MISTAKE. *TR
NHTSA ODI #10460124
Official recalls
4Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Dec 11, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE.
Consequence & remedy
Consequence: IF THIS SHOULD OCCUR, THERE IS A POSSIBILITY THAT THE DETACHED BOTTOM PORTION MAY STRIKE THE DRIVER CAUSING PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE AIR BAG MODULE. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-888-333-9376.
Oct 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES. THE TIRES WERE DAMAGED DURING A PORT UPGRADE TO ALUMINUM WHEELS.
Consequence & remedy
Consequence: THE TIRES DO NOT CONFORM TO THE SPEED RATING FOR THE VEHICLE. IF THE VEHICLE EXCEEDED THE MAXIMUM SPEED RATING (112 MPH), POSSIBLE TIRE FAILURE COULD OCCUR.
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Sep 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE AIR BAG ASSEMBLY. BOTH OWNERS WERE NOTIFIED BY TELEPHONE AND ARRANGEMENTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. THIS CAMPAIGN IS 100% COMPLETED. BOTH OWNERS HAVE BEEN NOTIFIED AND THEIR VEHICLES REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
PE04021 · Throttle Control System
Opened Mar 3, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control
THE LEXUS MODELS WERE THE SUBJECT OF DEFECT PETITION (DP) 04-003.TWELVE ODI COMPLAINTS ARE DUPLICATIVE TO TOYOTA REPORTS, INCLUDING THE TWO MINOR CRASHES.THE V6 EQUIPPED SOLARA MODELS HAVE BEEN EXCLUDED BECAUSE THEY DO NOT CONTAIN THE SUBJECT THROTTLE CONTROL SYSTEM.TOYOTA INTRODUCED ELECTRONIC THROTTLE CONTROL (ETC) ON THE SUBJECT VEHICLES BEGINNING IN MODEL YEAR (MY) 2002.ODI OPENED THE INVESTIGATION TO DETERMINE IF THE SYSTEM COULD BE THE CAUSE OF COMPLAINTS ALLEGING THE ENGINE SPEED INCREASED, OR FAILED TO DECREASE, (FOR A SHORT DURATION) WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED (THE ALLEGED DEFECT).DURING THE COURSE OF THE INVESTIGATION, ODI ANALYZED AGENCY DATA AND REVIEWED VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS, CONDUCTED INTERVIEWS INVOLVING 113 VOQ AND 36 TOYOTA REPORTS, INSPECTED TWO COMPLAINANT VEHICLES, REVIEWED RELEVANT TOYOTA SERVICE AND NEW CAR FEATURE DOCUMENTATION, REVIEWED AND ANALYZED TOYOTA?S RESPONSES TO ODI?S INFORMATION REQUEST LETTER, CONDUCTED A LIMITED CONTROL PEDAL ASSESSMENT, AND ATTENDED A TOYOTA TECHNICAL PRESENTATION THAT INCLUDED THE ASSESSMENT OF TWO DEMONSTRATION VEHICLES.THROUGH INTERVIEWS, ODI IDENTIFIED 14 VOQ AND 6 TOYOTA REPORTS (20 UNIQUE VEHICLES) WHERE COMPLAINANTS REPORT MULTIPLE OCCURRENCES OF THE ALLEGED DEFECT.IN SOME CASES THE CONDITION WAS EXPERIENCED BY DIFFERENT VEHICLE OPERATORS OR WAS WITNESSED BY OTHER OCCUPANTS.ODI WAS UNABLE TO MAKE A DETERMINATION AS TO THE CAUSE OF 9 TOYOTA AND AN ADDITIONAL 37 VOQ REPORTS (WHICH DESCRIBE 28 UNIQUE INCIDENTS) DUE TO INSUFFICIENT INFORMATION.THE REMAINING COMPLAINANTS INTERVIEWED (62 VOQ, 21 TOYOTA) DESCRIBED CONDITIONS NOT CAUSED BY A FAILURE OF THE THROTTLE CONTROL SYSTEM AND WERE THUS CONSIDERED UNRELATED TO THE INVESTIGATION.NONE OF THE COMPLAINANTS INTERVIEWED REPORTED A COMPONENT FAILURE (OR OTHER INDICATOR OF A SYSTEM FAILURE) AS THE POTENTIAL CAUSE OF INCIDENTS RELEVANT TO THIS INVESTIGATION.IN MANY CASES, THE COMPLAINT VEHICLES WERE SUBSEQUENTLY INSPECTED BY DEALERSHIP OR MANUFACTURER REPRESENTATIVES WHO ALSO FAILED TO IDENTIFY A FAULT WITHIN THE VEHICLE.TOYOTA IDENTIFIED 43 RELATED WARRANTY CLAIMS, 24 OF WHICH WERE FOR DIAGNOSTIC PURPOSES ONLY (NO REPAIRS PERFORMED).ODI FOUND NOTHING ABNORMAL IN THE CONTROL PEDAL CONFIGURATION OF THE SUBJECT VEHICLES.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ATTACHED SUMMARY FOR FURTHER DETAIL.
PE02079 · Engine Compartment Fire
Opened Oct 22, 2002 · Closed Mar 18, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI'S DATA ANALYSIS FOUND THE FIRES RATES TO BE CONSISTENTLY LOW AND EVENLY DISTRIBUTED AMONG SIX MODEL YEARS AND SIX DIFFERENT ENGINE CONFIGURATIONS.ODI EXAMINED A VARIETY OF ROOT CAUSES, THOSE BEING DETONATION (RESULTING IN OIL PAN PUNCTURE FROM CONNECTING ROD), STARTER FIRES, VARIOUS FUEL RELATED FIRES, LEAKING OIL FILTERS, WIRING ISSUES, IMPROPER REPAIRS AND BRAKE FLUID LEAKS.NONE OF THE ISSUES EXAMINED HAD REPORTS THAT INDICATED A TREND WHEN NORMALIZED FOR POPULATON AND EXPOSURE.SEE ATTACHED REPORT FOR FULL DETAILS.
Illustration