IllustrationCHECK VSC SYSTEM ERROR, TRACTION CONTROL LIGHT, ABS LIGHT AND EMERGENCY "!" LIGHT ILLUMINATED WHEN CAR WAS IDLE. BRAKES BECAME "SOFT". NEXT DAY, LIGHT WAS OFF UNTIL AFTER DRIVING A FEW MILES, AGAIN SAME LIGHTS CAME ON AND BRAKES BECAME SOFT AGAIN AT A STOP LIGHT
2008 Toyota Camry Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
2025–50K
3750–75K
3175–100K
23100–150K
13150K+
137 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports2 fire reports6 injury reports
Service Brakes complaints
61 reportsWAS DRIVING NEAR 10 MILES PER HOUR, CITY STREETS (ALL THREE TIMES) . I WENT TO BRAKE, THE CHECK VSC LIGHTS AND OTHERS WENT ON AND THE BRAKES FAILED. STEERING WAS DIFFICULT, CAR SEEMED TO SHUT DOWN. HAPPENED THREE TIMES IN THE LAST TWO WEEKS. *TR
LATE EVENING 1/10/17, WHILE MOVING AT 65MPH ON I-95, IN MODERATE TRAFFIC, MY DASH LIT UP AND BRIEF ALERT TONE SOUNDED. INDICATOR READ: "CHECK VSC," BRAKES PULSED & GOT HEAVY. LASTED 5 MINUTES, THEN ALERTS CLEARED. MADE A CALL TO HAVE A MECHANIC TAKE A LOOK ON 1/13, HOWEVER ON THE EVENING OF 1/12/17 WHILE MOVING AT LOW SPEED I…
Read full complaint
LATE EVENING 1/10/17, WHILE MOVING AT 65MPH ON I-95, IN MODERATE TRAFFIC, MY DASH LIT UP AND BRIEF ALERT TONE SOUNDED. INDICATOR READ: "CHECK VSC," BRAKES PULSED & GOT HEAVY. LASTED 5 MINUTES, THEN ALERTS CLEARED. MADE A CALL TO HAVE A MECHANIC TAKE A LOOK ON 1/13, HOWEVER ON THE EVENING OF 1/12/17 WHILE MOVING AT LOW SPEED IN A FLOW OF CARS, MY BRAKES BEGAN CLUTCHING UP & BECAME VERY HEAVY & UNRESPONSIVE, MY DASH LIT UP & A HIGH-PITCHED ALERT TONE SOUNDED. THE BRAKE LIGHT, MAINTENANCE LIGHT & OTHERS LIT UP & DASH INDICATOR SAID "CHECK VSC SYSTEM... MAINT REQUIRED." WHEN I STEPPED ON THE BRAKE, THE PEDAL PUSHED BACK, & AS I TRIED TO LIMP IT INTO THE PARKING LOT, THE BRAKES CONSTANTLY ENGAGED. I STOPPED TO WAIT FOR A FEW MINUTES, & TURNED THE CAR OFF BUT THE HIGH-PITCHED ALERT CONTINUED FOR SEVERAL MINUTES. FROM INSIDE THE CAR I COULD HEAR A WHIRRING NOISE IN THE FRONT END, IN THE AREA OF THE TIRES. I LET THE VEHICLE SIT FOR AN HOUR OR TWO, AT WHICH POINT, THE ALERT TONE HAD STOPPED BUT THE WHIRRING NOISE CONTINUED. I GOT INSIDE & FOUND THE ELECTRONICS WERE DIM, MOST WERE NOT WORKING. I STEPPED ON THE BRAKE & THE HIGH-PITCHED ALERT TONE RESUMED. RESISTANT FORCE CONTINUED IN THE BRAKE. I PUSHED THE START BUTTON A FEW TIMES, & EVENTUALLY THE DASH LIT BACK UP WITH ALL OF THE WARNING INDICATORS. THE CAR STARTED, BUT THE BRAKES PULSED AS IF CONSTANTLY ENGAGED & OCCASIONALLY BEING SLAMMED. IN GEAR, THE PROBLEMS PERSISTED, SO I GOT THE CAR OUT OF THE WAY & TURNED IT OFF. ALERT TONE & WHIR CONTINUED, ALONG WITH A BURNING KIND OF SMELL FROM THE AREA OF THE FRONT TIRES (RIGHT FRONT TIRE WELL FELT WARM). IT WAS DARK, SO I DIDN'T NOTICE IF THERE WAS SMOKE OF ANY COLOR. BECAUSE I WORRIED THAT THE WHIRRING MOTOR WAS GOING TO BURN UP & POSSIBLY EXACERBATE MATTERS, I DISCONNECTED THE BATTERY & HAD THE CAR TOWED TO A DEALER. I HAVE SOME VIDEOS IF THEY ARE HELPFUL.
WARNING BUZZER, BRAKE, CHECK ENGINE, NO CRUISE CONTROL, HARD BRAKE PEDAL TO STOP. I PAID TO THE DEALER TO DIAGNOSTIC, AND THE ABS ACTUATOR ASSEMBLY WITH LABOR IS ALMOST US$1,700. ONLY SOMETHING THE SOUND OF THE BUZZER AND THE LIGHTS TURN OFF, AND BRAKE PERFECT. BUT MUST OF THE TIME, PERMANENT NOISE AND LIGHTS ARE ON. TO…
Read full complaint
WARNING BUZZER, BRAKE, CHECK ENGINE, NO CRUISE CONTROL, HARD BRAKE PEDAL TO STOP. I PAID TO THE DEALER TO DIAGNOSTIC, AND THE ABS ACTUATOR ASSEMBLY WITH LABOR IS ALMOST US$1,700. ONLY SOMETHING THE SOUND OF THE BUZZER AND THE LIGHTS TURN OFF, AND BRAKE PERFECT. BUT MUST OF THE TIME, PERMANENT NOISE AND LIGHTS ARE ON. TO USE THE CAR IS DANGEROUS AND NOISE NO GOOD FOR PASSENGERS. THE PROBLEM START WITH VEHICLE IN MOTION, IN THE CITY.
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, ALL THE WARNING INDICATORS ILLUMINATED AND THE BRAKES FAILED TO RESPOND. THE CONTACT ALSO STATED THAT THE POWER STEERING FAILED AND THE A/C EMITTED HOT AIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE …
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA CAMRY HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, ALL THE WARNING INDICATORS ILLUMINATED AND THE BRAKES FAILED TO RESPOND. THE CONTACT ALSO STATED THAT THE POWER STEERING FAILED AND THE A/C EMITTED HOT AIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
UPON STARTING VEHICLE A "CHECK VSC SYSTEM" WARNING MESSAGE WAS DISPLAYED. THE MAINTENANCE "!", "BRAKE DRUM", "TRAC" AND "ABS" WARNING LIGHTS ILLUMINATED. AN OBD2 CODE CHECK WAS PERFORMED AND A DIAGNOSTIC CODE "C0210 RH REAR SPEED SENSOR CIRCUIT" WAS RETURNED. AUTHORIZED TOYOTA DEALER/SERVICE REPLACED THE RIGHT REAR SPEED SENSO…
Read full complaint
UPON STARTING VEHICLE A "CHECK VSC SYSTEM" WARNING MESSAGE WAS DISPLAYED. THE MAINTENANCE "!", "BRAKE DRUM", "TRAC" AND "ABS" WARNING LIGHTS ILLUMINATED. AN OBD2 CODE CHECK WAS PERFORMED AND A DIAGNOSTIC CODE "C0210 RH REAR SPEED SENSOR CIRCUIT" WAS RETURNED. AUTHORIZED TOYOTA DEALER/SERVICE REPLACED THE RIGHT REAR SPEED SENSOR AND HUB. WARNING SIGNALS RESET WAS ATTEMPTED, BUT FAILED. DIAGNOSTIC CODE REMAINED. DEALER PROPOSED TO BEGIN REPLACING DOWN-STREAM PARTS UNTIL CODE WOULD BE ABLE TO BE RESET. THERE WAS NO GUARANTEE THAT ANY OF THE REPLACEMENTS WOULD CORRECT THE CODE OR RESET THE ABS & STABILITY SYSTEMS. AGGRESSIVE CONVERSATION BETWEEN THE DEALERSHIP AND TOYOTA COULD NOT RESOLVE THE ISSUE. THE VEHICLE IS WITHOUT THE SAFETY OF THE ABS OR TRACTION CONTROL SYSTEMS AS LONG AS THE WARNING LIGHTS ARE ON. REVIEWING MULTIPLE INTERNET SITES CONCERNING THIS TOYOTA VEHICLE RELATED PROBLEM REVEALS NUMEROUS COMPLAINTS AND TEMPORARY SOLUTIONS, WHICH ULTIMATELY FAIL. IT IS SURPRISING WITH THE VOLUMINOUS CUSTOMER-LOGGED COMPLAINTS ON THIS ISSUE THAT TOYOTA HAS NOT DEEPENED ITS INVESTIGATION ON HOW TO CORRECT THE PROBLEM. IT APPEARS THAT THEY HAVE DETERMINED THAT EACH COMPLAINT IS IN INDIVIDUAL PROBLEM AND THEREFORE EASILY IGNORED.
THE COMPLIANT IS NOT THE RESULT OF A DIRECT ISSUE, BUT UPON VISITING THE DEALER, WAS INFORMED OF A BRAKE ACTUATOR REPLACEMENT THAT NEEDED TO BE DONE AT OVER $1700 IN PARTS ALONE - LOOKING ON THE INTERNET IS APPEARS AS IF TOYOTA HAD ISSUED AN EXTENDED WARRANTY ON THIS BUT I WAS NEVER NOTIFIED. WOULD HAVE HAD IT REPLACED EARLIE…
Read full complaint
THE COMPLIANT IS NOT THE RESULT OF A DIRECT ISSUE, BUT UPON VISITING THE DEALER, WAS INFORMED OF A BRAKE ACTUATOR REPLACEMENT THAT NEEDED TO BE DONE AT OVER $1700 IN PARTS ALONE - LOOKING ON THE INTERNET IS APPEARS AS IF TOYOTA HAD ISSUED AN EXTENDED WARRANTY ON THIS BUT I WAS NEVER NOTIFIED. WOULD HAVE HAD IT REPLACED EARLIER. NEED SOME HELP AND OPTIONS.
I WAS DRIVING ON THE FREEWAY ONE AFTERNOON WHEN ALL THE INDICATORS ON MY DASHBOARD TURNED ON AND STATED "CHECK VSC SYSTEM". I MADE AN APPOINTMENT WITH TOYOTA SCHEDULED FOR AUGUST 2, 2015. AFTER THE INDICATORS TURNED ON, I WAS REVERSING OUT OF A PARKING SPOT WHEN I NOTICED AN ONCOMING VEHICLE. I PRESSED THE BRAKES BUT MY CAR FAIL…
Read full complaint
I WAS DRIVING ON THE FREEWAY ONE AFTERNOON WHEN ALL THE INDICATORS ON MY DASHBOARD TURNED ON AND STATED "CHECK VSC SYSTEM". I MADE AN APPOINTMENT WITH TOYOTA SCHEDULED FOR AUGUST 2, 2015. AFTER THE INDICATORS TURNED ON, I WAS REVERSING OUT OF A PARKING SPOT WHEN I NOTICED AN ONCOMING VEHICLE. I PRESSED THE BRAKES BUT MY CAR FAILED TO STOP, AND I HAD TO SHIFT TO PARK TO PREVENT AN ACCIDENT. THE TOYOTA SERVICEMAN INFORMED ME THE BRAKE ACTUATOR WAS THE PROBLEM. HE FURTHER CLAIMED THAT THIS WAS NOT COVERED UNDER WARRANTY SINCE THE CAR HAD BEEN IN AN ACCIDENT 3 YEARS AGO AND WANTED TO CHARGE ME $1,500. HOW CAN AN ACCIDENT 3 YEARS AGO CAUSE MY BRAKE ACTUATOR TO SUDDENLY FAIL LAST MONTH? I AM UNABLE TO DRIVE MY CAR FOR FEAR OF AN ACCIDENT; DESPITE THE ACCIDENT TOYOTA SHOULD HONOR THE LSC AND FIX THE ACTUATOR INSTEAD OF TRYING TO CHARGE ME FOR A PROBLEM THEY CAUSED IN THE FIRST PLACE.
VSC CHECK ENGINE ERROR CAME ON DISPLAY ALONG WITH CHECK ENGINE LIGHT, ABS, PARKING BRAKE, TRACTION CONTROL, AND SOMETHING ELSE. I WAS COMING OFF THE HIGHWAY AND EXITING THE OFF-RAMP WHEN THE CAR BINGED, ALL THE LIGHTS CAME ON, THE CHECK VSC CAME ON AND THE BRAKES HICCUPED. I WAS ALREADY PULLING OFF THE HIGHWAY, SO I TURNED ONT…
Read full complaint
VSC CHECK ENGINE ERROR CAME ON DISPLAY ALONG WITH CHECK ENGINE LIGHT, ABS, PARKING BRAKE, TRACTION CONTROL, AND SOMETHING ELSE. I WAS COMING OFF THE HIGHWAY AND EXITING THE OFF-RAMP WHEN THE CAR BINGED, ALL THE LIGHTS CAME ON, THE CHECK VSC CAME ON AND THE BRAKES HICCUPED. I WAS ALREADY PULLING OFF THE HIGHWAY, SO I TURNED ONTO A SIDE STREET. PARKED, AND THEN RESTARTED THE CAR. THE ERROR CAME ON AGAIN, BUT THEN WENT OUT.
2008 CAMRY HYBRID STOPPED AT A GAS STATION WITH CAR WAS IN PARK. NO ONE IN CAR, CAR CAME OUT OF PARK, ROLLED OUT OF STATION, ACROSS FIRST 2 LANES, THEN MEDIAN, THEN 2 ADDITIONAL LANES AND ENDED UP IN A TREE IN/NEAR A SCHOOL YARD/PROPERTY. TOYOTA HAD ENGINEER REVIEW IN EARLY SEPT. TOYOTA WROTE LETTER IN JANUARY THAT THEY REFUS…
Read full complaint
2008 CAMRY HYBRID STOPPED AT A GAS STATION WITH CAR WAS IN PARK. NO ONE IN CAR, CAR CAME OUT OF PARK, ROLLED OUT OF STATION, ACROSS FIRST 2 LANES, THEN MEDIAN, THEN 2 ADDITIONAL LANES AND ENDED UP IN A TREE IN/NEAR A SCHOOL YARD/PROPERTY. TOYOTA HAD ENGINEER REVIEW IN EARLY SEPT. TOYOTA WROTE LETTER IN JANUARY THAT THEY REFUSE TO FURTHER EVALUATE OR BE RESPONSIBLE FOR COLLISION. AN INSURANCE AGENT AT MY CARRIER HAD EXACTLY THE SAME ISSUE BUT HER DAMAGE WAS BELOW HER DEDUCTIBLE AND SHE JUST HAD IT REPAIRED WITHOUT TELLING TOYOTA. *TR
Official recalls
212V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE14001 · Brake Actuator Malfunction
Opened Jan 23, 2014 · Closed Aug 22, 2014
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Additional source detail variants (4)
Service Brakes, Air:supply:reservoir/tank
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Electric
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.