IllustrationWHEN READYING TO STOP, LIFTED FOOT FROM ACCELERATOR AND REACHED FOR BRAKE. WHEN PRESSURE APPLIED, BRAKE PEDAL DROPPED 1 - 2 INCHES BEFORE BRAKES TOOK HOLD. THIS WAS THE FOURTH OR FIFTH TIME THAT THIS TYPE OF BRAKING RESPONSE OCCURRED OVER THE LIFE OF THE CAR. I TOOK DELIVERY OF THE CAR IN JUNE 2006. *TR
2007 Toyota Camry Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
5325–50K
8650–75K
11975–100K
169100–150K
81150K+
543 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 391 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports7 fire reports14 injury reports
What owners actually said
602 reportsTHE CHECK VSC LIGHT CAME ON IN DECEMBER. THE DEALER COULD NOT FIND ANYTHING WRONG. THE WARNING LIGHT CAME ON AGAIN ON 1/21/14. THE DEALER SAID THAT THE BRAKE ACCUMULATOR WAS DEFECTIVE AND COULD RESULT IN A FAILURE OF THE ABS. IT WAS REPLACED AT A COST OF MORE THAN $3000. I AM A CAREFUL DRIVER AND HAVE NEVER HAD THE ABS ENGA…
Read full complaint
THE CHECK VSC LIGHT CAME ON IN DECEMBER. THE DEALER COULD NOT FIND ANYTHING WRONG. THE WARNING LIGHT CAME ON AGAIN ON 1/21/14. THE DEALER SAID THAT THE BRAKE ACCUMULATOR WAS DEFECTIVE AND COULD RESULT IN A FAILURE OF THE ABS. IT WAS REPLACED AT A COST OF MORE THAN $3000. I AM A CAREFUL DRIVER AND HAVE NEVER HAD THE ABS ENGAGE ON THIS CAR, SO SOMETHING IS NOT RIGHT WHEN SUCH A KEY (AND EXPENSIVE) PART FAILS. THIS SHOULD BE RECALLED. *TR
THE BRAKE ACCUMULATOR CYCLES CONTINUOUSLY AND PULSES WHEN DEPRESSED MAKING A DISTINCT HOWLING NOISE EVEN WHEN STOPPED. THE BRAKE ASSIST INTERMITTENTLY PULSES AND MAKES BRAKING MORE DIFFICULT AND INCREASING STOPPING DISTANCE. THIS PART IS SPECIFIC TO THE REGENERATIVE BRAKING AS PART OF THE HYBRID SYSTEM. *TR
TL* THE CONTACT OWNS A 2007 CAMERA HYBRID. THE CONTACT STATED WHILE DRIVING 30 MPH THE BRAKES WERE APPLIED AND THEY MALFUNCTIONED. THE BRAKE LIGHTS ILLUMINATED BUT THE BRAKES WAS SLOW TO APPLY. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST BUT DID NOT FIND ANY DEFECT CODES. THE DEALER REPLACED THE REAR BRAKE BUT…
Read full complaint
TL* THE CONTACT OWNS A 2007 CAMERA HYBRID. THE CONTACT STATED WHILE DRIVING 30 MPH THE BRAKES WERE APPLIED AND THEY MALFUNCTIONED. THE BRAKE LIGHTS ILLUMINATED BUT THE BRAKES WAS SLOW TO APPLY. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST BUT DID NOT FIND ANY DEFECT CODES. THE DEALER REPLACED THE REAR BRAKE BUT THAT DID NOT REMEDY THE BRAKING DEFECT. THE FAILURE MILEAGE WAS 73,305. UPDATED 03/05/14*LJ
WHEN I WENT TO START MY CAR WHICH WAS STILL IN MY GARAGE, I PRESSED MY FOOT ON THE BRAKE AND PUSHED THE "ON" BUTTON. IMMEDIATELY I FELT THE BRAKE "PUSH BACK" AND HAD TO PUMP IT ONCE OR TWICE TO BRING IT BACK TO NORMAL. OVER THE COURSE OF THE NEXT SIX WEEKS, THIS WOULD OCCASIONALLY HAPPEN AGAIN. IN ADDITION, AND MORE TROUBLING,…
Read full complaint
WHEN I WENT TO START MY CAR WHICH WAS STILL IN MY GARAGE, I PRESSED MY FOOT ON THE BRAKE AND PUSHED THE "ON" BUTTON. IMMEDIATELY I FELT THE BRAKE "PUSH BACK" AND HAD TO PUMP IT ONCE OR TWICE TO BRING IT BACK TO NORMAL. OVER THE COURSE OF THE NEXT SIX WEEKS, THIS WOULD OCCASIONALLY HAPPEN AGAIN. IN ADDITION, AND MORE TROUBLING, WAS THAT SOMETIMES, WHEN I WAS PARKED IN A PARKING LOT, AND THEN STARTED THE CAR, SOMETHING SLIGHTLY DIFFERENT HAPPENED. WHEN I PRESSED ON THE BRAKE AND STARTED THE CAR, INSTEAD OF FEELING RESISTANCE IT SEEMED THAT THE BRAKE WAS GOING ALL THE WAY TO THE FLOOR BUT MY CAR WAS SLOWLY ROLLING BACKWARDS. AFTER PUMPING THE BRAKE A COUPLE OF TIMES, IT REVERTED TO NORMAL. FINALLY, ON 1/22/2014, THE "CHECK VSC SYSTEM" WARNING SUDDENLY CAME ON AS I WAS DRIVING, AS WELL AS THE ANTILOCK BRAKE LIGHT, THE REGULAR BRAKE LIGHT, THE ENGINE LIGHT, AND THE TRIANGULAR HYBRID WARNING LIGHT. THE CAR WAS DRIVING OKAY, BUT THE LIGHTS ALL REMAINED ON UNTIL I BROUGHT MY CAR INTO THE DEALER A FEW DAYS LATER. THE SERVICE DEPARTMENT INFORMED ME THAT MY BRAKE ACCUMULATOR HAD BLOWN A FUSE AND HAD TO BE REPLACED. THEY STATED THEY HAD NO KNOWLEDGE OF THIS TYPE OF PROBLEM OCCURRING IN THE CAMRY HYBRIDS. I PAID $3400 TO HAVE THE ACCUMULATOR REPLACED. THE NEXT MORNING I READ A NEWS BLURB IN THE NEWSPAPER ABOUT THE INVESTIGATION INTO THE EARLY CAMRY HYBRID MODELS' BRAKE PROBLEMS AND RESEARCHED IT FURTHER AND ENDED UP AT THIS NHTSA SITE. MY CONCERN IS THAT EVEN THOUGH MY ACCUMULATOR HAS BEEN REPLACED, HAS THE ROOT OF THE PROBLEM BEEN ADDRESSED, OR DO I HAVE TO WORRY ABOUT THE SAME THING HAPPENING AGAIN? I FEEL THAT THIS IS A DANGEROUS DEFECT THAT COULD CAUSE ACCIDENTS, AND I FEEL LUCKY THAT I HAD MY PROBLEM ADDRESSED BEFORE ANYTHING MORE HARMFUL OCCURRED. *TR
MY 2007 TOYOTA CAMRY HYBRID BEGAN TO CONSISTENTLY MAKE NOISES AS I DEPRESSED THE BRAKE PEDAL (WITH THE VEHICLE IN THE STOPPED POSITION) FOR A FEW MONTHS BEFORE THE VSC SYSTEM FAILED. LUCKILY, THE FAILURE OCCURRED AS I WAS BACKING OUT OF THE DRIVEWAY AND WAS ABLE TO STOP. I HAD THE VEHICLE TOWED TO THE DEALER AND PROCEEDED TO PAY…
Read full complaint
MY 2007 TOYOTA CAMRY HYBRID BEGAN TO CONSISTENTLY MAKE NOISES AS I DEPRESSED THE BRAKE PEDAL (WITH THE VEHICLE IN THE STOPPED POSITION) FOR A FEW MONTHS BEFORE THE VSC SYSTEM FAILED. LUCKILY, THE FAILURE OCCURRED AS I WAS BACKING OUT OF THE DRIVEWAY AND WAS ABLE TO STOP. I HAD THE VEHICLE TOWED TO THE DEALER AND PROCEEDED TO PAY $2200 TO HAVE THE ABS ACTUATOR REPLACED. I HAVE ANOTHER 2007 TOYOTA CAMRY HYBRID WITH JUST OVER 60,000 MILES AND IT IS BEGINNING TO MAKE THE SAME BRAKE NOISE AS THE OTHER VEHICLE. THE DEALER HAS SAID IT IS NOT A PROBLEM. I CAN ONLY HOPE THAT WHEN THE BRAKES GO OUT AGAIN I WILL NOT BE TRAVELING AT A HIGH RATE OF SPEED, OR NEGOTIATING THE MOUNTAIN ROADS I USE TO COMMUTE DAILY. I HEARD YESTERDAY ON THE NEWS THAT THIS PROBLEM IS BEING INVESTIGATED. I HOPE THEY RECALL THIS VEHICLE SOON AND HAVE THIS REPAIRED BEFORE ANYONE IS KILLED OR INJURED. *TR
DRIVING DOWN THE ROAD AND NOTICED THE BRAKES DID NOT FEEL RIGHT. IT WAS MUCH HARDER TO PRESS THE BRAKE PEDAL THAN NORMAL APPROACHING A STOP SIGN. WHEN STOPPED, THERE WAS A STRANGE PULSING SENSATION COMING FROM THE PEDAL. I KEPT DRIVING AND THE PROBLEM CONTINUED, BUT SEEMED TO GET WORSE AS I DROVE MORE. AT ONE POINT, THERE WE…
Read full complaint
DRIVING DOWN THE ROAD AND NOTICED THE BRAKES DID NOT FEEL RIGHT. IT WAS MUCH HARDER TO PRESS THE BRAKE PEDAL THAN NORMAL APPROACHING A STOP SIGN. WHEN STOPPED, THERE WAS A STRANGE PULSING SENSATION COMING FROM THE PEDAL. I KEPT DRIVING AND THE PROBLEM CONTINUED, BUT SEEMED TO GET WORSE AS I DROVE MORE. AT ONE POINT, THERE WERE LIGHTS AND WARNINGS GOING OFF, SO I EVENTUALLY PULLED OVER ON THE SIDE OF THE ROAD AND LET THE CAR SITE FOR A WHILE. AFTER TURNING THE CAR OFF AND ON A FEW TIMES, EVERYTHING APPEARED TO BE BACK IN WORKING ORDER. HOWEVER, SINCE THE FIRST INCIDENT, THE ISSUE HAS OCCURRED A FEW MORE TIMES. THE CAR IS NOT SAFE TO DRIVE; IT WILL DEFINITELY CAUSE AN ACCIDENT OR WORSE UNLESS SOMETHING IS FIXED. I CONTACTED THE LOCAL TOYOTA DEALERSHIP AND THEY TOLD ME IT WAS THE BRAKE ACTUATOR - AND IT WILL COST $2K-$3K!!! I WAS TOLD BY A SERVICE TECH THAT THEY SEE THIS ISSUE ALL THE TIME AND THERE IS A NEW PART THAT REPLACES THE ORIGINAL ONE - WITH A DIFFERENT PART NUMBER... SO OBVIOUSLY TOYOTA KNOWS THERE IS AN ISSUE WITH THE ORIGINAL PART. WITH SUCH AN IMPORTANT PIECE OF THE CAR (BRAKES), THEY SHOULD STEP UP AND MAKE IT RIGHT. I'M PRETTY DISAPPOINTED IN TOYOTA FOR THIS SITUATION AND DON'T FEEL COMFORTABLE DRIVING THE CAR WITH ME OR MY FAMILY. *TR
I WAS DRIVING THE CAR AS USUALLY AND FIRST THE TURN ON THE VSS LIGHT AND WHEN A I TRY TO STOP THE CAR AND DIDNT STOP PROPERLY AND I ALMOST CRASH THE CAR A WENT TO THE SIDE OF THE ROAD FOR TRY TO SAVE MY LIFE AND THE OTHER CAR DRIVER FROM THAT DAY UNTIL NOW I HAVE THE PROBLEM WITH THA CAR AT THE OF BREAK .THE DEALERSHIP EMPLOYEE …
Read full complaint
I WAS DRIVING THE CAR AS USUALLY AND FIRST THE TURN ON THE VSS LIGHT AND WHEN A I TRY TO STOP THE CAR AND DIDNT STOP PROPERLY AND I ALMOST CRASH THE CAR A WENT TO THE SIDE OF THE ROAD FOR TRY TO SAVE MY LIFE AND THE OTHER CAR DRIVER FROM THAT DAY UNTIL NOW I HAVE THE PROBLEM WITH THA CAR AT THE OF BREAK .THE DEALERSHIP EMPLOYEE SAID THATS A PROBLEM OF EVERY CAMRY HYBRID AND I NEED TO CHAGE THE ABS SYSTEM BUT COST $3400.00 PLUS THE INSTALATION AND I JUST WANT IF EVERITHING IS OK WITH MY CAR OR IS A MANUFACTOR PROBLEM. *TR
THE PARKING BRAKE LIGHT COMES ON WHILE DRIVING , ABOUT A MINUTE LATER THE CHECK VSC LIGHT COMES ON AND THE POWER BRAKES FAIL, YOU CAN STILL STOP WITH THE BRAKE, BUT YOU HAVE TO REALLY PRESS HARD ON THE BRAKE, AFTER DRIVING A COUPLE MILES OR A FEW MINUTES THE BRAKES WILL RETURN TO NORMAL. VERY DISCONCERTING AND DANGEROUS, AFRAID …
Read full complaint
THE PARKING BRAKE LIGHT COMES ON WHILE DRIVING , ABOUT A MINUTE LATER THE CHECK VSC LIGHT COMES ON AND THE POWER BRAKES FAIL, YOU CAN STILL STOP WITH THE BRAKE, BUT YOU HAVE TO REALLY PRESS HARD ON THE BRAKE, AFTER DRIVING A COUPLE MILES OR A FEW MINUTES THE BRAKES WILL RETURN TO NORMAL. VERY DISCONCERTING AND DANGEROUS, AFRAID TO DRIVE THIS CAR. *TR
BRAKES FAIL... THE PEDAL BRAKE IS PUT SO HARD TO PUSH WHEN COMING A LIGHT TO VSC CHECK SYSTEM...IM SO ANGRY TO TOYOTA ... BUT I STILL LOVE MY CAR ... I NO USE MY CAR BECAUSE IS NOT SECURE FOR MY FAMILY. *TR
Official recalls
315V689000 · Visibility:power Window Devices And Controls
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
12V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE14001 · Brake Actuator Malfunction
Opened Jan 23, 2014 · Closed Aug 22, 2014
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Additional source detail variants (4)
Service Brakes, Air:supply:reservoir/tank
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Electric
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.