IllustrationNOTICED FLUID LEAKING FROM RACK AND PINION STEERING BOOT, DEALER REPLACED ASSEMBLY, PARTS HAD TO BE BACK ORDERED BECAUSE OF FREQUENCY OF PROBLEM, ALSO RIGHT SRTUT MOUNT HAD TO BE REPLACED,AND BACK ORDERED .*AK
1997 Toyota Avalon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1997 Toyota Avalon do not stand out strongly from the model-year median of 101.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avalon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 25 of 125 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports0 fire reports6 injury reports
Steering complaints
40 reportsUPPER AND LOWER TIE RODS SEVERED AT LOW SPEED (PULLING INTO PARKING SPACE). IF FAILURE HAD OCCURRED AT HIGHER SPEED, A SERIOUS ACCIDENT WOULD HAVE ENSUED.*AK
SEAL ON RACK STEERING WENT BAD AND STARTED LEAKING FLUID. DEALER REPLACED RACK, BUT CONSUMER WAITED A MONTH BEFORE PART WAS AVAILABLE.*AK
AFTER NOTICING OIL SPOTS ON PAVEMENT HAD MECHANIC CHECK VEHICLE. FOUND RACK AND PINION STEERING NEEDED TO BE REPLACED/ DRIVER'S SEAT BELT HAD TO BE REPLACED DUE TO TENSIONER TIGHTENING UP WITH TOO MUCH FORCE/ TIRES WERE WEARING OUT PREMATURELY DUE TO BAD SUSPENSION/VEHICLE HAD ROUGH RIDE, AND STRUTS WERE LEAKING. *AK
RACK AND PINION STARTED LEAKING FLUID AND WITHIN 2 WEEKS NO LONGER HELD ANY FLUID AND THE RACK AND PINION NEEDED REPLACED. CONTACTED TOYOTA AND THEY FILED THE COMPLAINT, BUT OFFERED NO REMEDY AND WOULD NOT ACKNOWLEDGE ANY OTHER COMPLAINTS ON THE SAME ISSUE. FROM OTHER RESEARCH THIS APPEARS TO BE A VERY COSTLY PROBLEM ON MANY OF…
Read full complaint
RACK AND PINION STARTED LEAKING FLUID AND WITHIN 2 WEEKS NO LONGER HELD ANY FLUID AND THE RACK AND PINION NEEDED REPLACED. CONTACTED TOYOTA AND THEY FILED THE COMPLAINT, BUT OFFERED NO REMEDY AND WOULD NOT ACKNOWLEDGE ANY OTHER COMPLAINTS ON THE SAME ISSUE. FROM OTHER RESEARCH THIS APPEARS TO BE A VERY COSTLY PROBLEM ON MANY OF THE '97 AVALONS. *AK
STEERING RACK FAILED RIGHT AFTER WARRANTY EXPIRED. *SLC
POWER STEERING RACK LEAKING AT 58,000 MILES. DEALER ESTIMATE TO REPAIR IS $1,370. CONTACTED TOYOTA - UNWILLING TO PROVIDE ASSISTANCE. APPEARS TO BE A COMMON PROBLEM FOR AVALONS. CONFIRMED THIS WITH FORMER TOYOTA MECHANICS WHO SAID THEY SAW A LOT OF 1997 AVALONS AND CAMRYS WITH LEAKING STEERING RACKS. ALSO, NEED FRONT STRUT …
Read full complaint
POWER STEERING RACK LEAKING AT 58,000 MILES. DEALER ESTIMATE TO REPAIR IS $1,370. CONTACTED TOYOTA - UNWILLING TO PROVIDE ASSISTANCE. APPEARS TO BE A COMMON PROBLEM FOR AVALONS. CONFIRMED THIS WITH FORMER TOYOTA MECHANICS WHO SAID THEY SAW A LOT OF 1997 AVALONS AND CAMRYS WITH LEAKING STEERING RACKS. ALSO, NEED FRONT STRUT MOUNTS REPLACED, ANOTHER APPARENTLY DEFECTIVE PART IN 1997 AVALONS.
VEHICLE LEAKING EXCESSIVE AMOUNTS OF POWER STEERING FLUID, PRIOR TO NOTICING THE LEAK THE CONSUMER WAS ACCELERATING FROM AN INTERSECTION AND VEHICLE PULLED TO THE LEFT ALMOST CAUSING A LOSS OF CONTROL AND GO INTO A CENTER MEDIAN, DEALER STATES THE STEERING RACK IS CAUSING THE PROBLEM AND NEEDS REPLACED. *SLC
RACK AND PINION ASSEMBY BEGAN LEAKING FROM SEAL FAILURES ON THE INSIDE OF THE UNIT. *AK
VEHICLE TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION, MECHANIC INFORMED CONSUMER THAT RACK AND PINION STEERING BROKE AND NEEDED REPLACEMENTEMENT/REPAIRS. DEALER NOTIFIED, AND INFORMED CONSUMER THAT VEHICLE WAS OUT OF ITS WARRANTY. ANY REPAIRS WOULD BE AT CONSUMER'S COST. *AK
Official recalls
197V156000 · Service Brakes, Hydraulic:power Assist
Sep 17, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN,MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NOTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. A CONDITION CAN OCCUR WHERE ACCUMULATED MOISTURE CAN TEMPORARILY FREEZE IN THE BRAKE VACUUM HOSE IF THE VEHICLE IS USED IN EXTREMELY COLD CLIMATES FOR AN EXTENDED PERIOD OF TIME.
Consequence & remedy
Consequence: THIS CAN RESULT IN THE ELIMINATION OF VACUUM ASSIST TO THE BRAKES THAT CAN INCREASE STOPPING DISTANCES AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DESIGN BRAKE VACUUM HOSE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP02004 · Engine Seizure
Opened Apr 30, 2002 · Closed Jun 20, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.