Illustration2004 TOYOTA 4RUNNER WITH SIGNIFICANT RUST ON THE UNDERBODY INCLUDING FRAME. THE VEHICLE IS STATIONARY BUT WAS DEEMED UNSAFE TO DRIVE DUE TO FRAME DAMAGE. IT HAS BEEN WELL MAINTAINED AND THERE ARE NO OTHER ISSUES ASIDE FROM SIGNIFICANT RUST DAMAGE.
2004 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 2004 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
2825–50K
5150–75K
6275–100K
132100–150K
129150K+
418 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 309 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports3 fire reports14 injury reports
What owners actually said
612 reportsTHE 4RUNNER WAS WELL CARED FOR AND THE FRAME HAS ROTTED TO NOTHING IN UNDER 15 YEARS. IT IS EXTREMELY UNSAFE AND IS THE SAME ISSUE PRESENT IN THE TACOMA'S AND OTHER TOYOTA FULL FRAME VEHICLES. THE RUST DEVELOPS EARLY AND IN THE SAME SPOTS ON ALL MODELS. IT SPREADS RAPIDLY AND COMPROMISES THE ENTIRE FRAME MAKING HE VEHICLE UNSAF…
Read full complaint
THE 4RUNNER WAS WELL CARED FOR AND THE FRAME HAS ROTTED TO NOTHING IN UNDER 15 YEARS. IT IS EXTREMELY UNSAFE AND IS THE SAME ISSUE PRESENT IN THE TACOMA'S AND OTHER TOYOTA FULL FRAME VEHICLES. THE RUST DEVELOPS EARLY AND IN THE SAME SPOTS ON ALL MODELS. IT SPREADS RAPIDLY AND COMPROMISES THE ENTIRE FRAME MAKING HE VEHICLE UNSAFE TO DRIVE. I BELIEVE TOYOTA HAS SHOWN A PATTERN OF NEGLECT REGUARDING THE MANUFACTURE OF THEIR VEHICLE FRAMES AND THE 4RUNNER IS NO EXCEPTION.
MY 2004 TOYOTA 4 RUNNER HAS SERIOUS SAFETY ISSUES WITH THE FRAME RUSTING. I HAVE ROUTINELY MAINTAINED THE VEHICLE, INCLUDING ROUTINE WASHING UNDERNEATH ON THE FRAME. I TOOK MY VEHICLE INTO THE TOYOTA DEALER FOR SERVICE AND THEY DECLARED THE VEHICLE IS UNSAFE TO DRIVE DUE TO RUST ON THE FRAME. THERE IS NOTHING WRONG WITH THE…
Read full complaint
MY 2004 TOYOTA 4 RUNNER HAS SERIOUS SAFETY ISSUES WITH THE FRAME RUSTING. I HAVE ROUTINELY MAINTAINED THE VEHICLE, INCLUDING ROUTINE WASHING UNDERNEATH ON THE FRAME. I TOOK MY VEHICLE INTO THE TOYOTA DEALER FOR SERVICE AND THEY DECLARED THE VEHICLE IS UNSAFE TO DRIVE DUE TO RUST ON THE FRAME. THERE IS NOTHING WRONG WITH THE BODY OF THE VEHICLE, NO RUST. THE ENGINE WORKS PERFECTLY. THE TOYOTA DEALER KEPT PICTURES OF THE FRAME. THEY STATED THAT TOYOTA HAD RECALLED TACOMA, TUNDRA, SEQUOIA FRAMES FOR THE SAME REASON.
I AM THE ORIGINAL OWNER OF 04 V8 4RUNNER SPORT AND IT JUST PASSED THE 200,000 MILE MARK. THE SUV RUNS GREAT STILL, BUT THE FRAME IS RUSTING OUT SO BAD THAT IT IS BECOMING DANGEROUS TO DRIVE. WE HAD TO WELD A PATCH FOR THE RADIATOR SUPPORT AND THE FRONT TOW/TIE DOWN HOOK BROKE OFF, THE ENTIRE FRAME IS ROTTING OUT FROM THE INSIDE …
Read full complaint
I AM THE ORIGINAL OWNER OF 04 V8 4RUNNER SPORT AND IT JUST PASSED THE 200,000 MILE MARK. THE SUV RUNS GREAT STILL, BUT THE FRAME IS RUSTING OUT SO BAD THAT IT IS BECOMING DANGEROUS TO DRIVE. WE HAD TO WELD A PATCH FOR THE RADIATOR SUPPORT AND THE FRONT TOW/TIE DOWN HOOK BROKE OFF, THE ENTIRE FRAME IS ROTTING OUT FROM THE INSIDE OUT. THERE ARE HOLES IN THE FRAME.THIS IS AN KNOWN ISSUE FOR TOYOTA AND DON'T KNOW WHY THEY DIDN'T RECALL THE 4RUNNER WHEN THEY RECALLED THE OTHER TOYOTAS OF THE SAME YEAR. I WOULD LIKE TO BE PART OF A CLASS ACTION LAWSUIT. I HAVE 2 OTHER TRUCKS 1988 F250 AND 2004 F550 THAT HAVE NO RUSTED OUT HOLES IN THE FRAMES ONLY SURFACE RUST. SO IT ISN'T JUST BECAUSE I LIVE IN NY.
THE FRAME HAS RUSTED ON THE PASSENGER SIDE WHERE THE FRAME IS WELDED TOGETHER. THE CHICAGO NORTHSIDE TOYOTA DEALER FOUND IT WHILE DOING WORK ON MY VEHICLE. IT IS ABOUT A 3 INCH HOLE ON THE OUTSIDE OF THE FRAME AND THERE IS ALSO A RUSTED HOLE ON THE OPPOSITE SIDE NEAR THE BRACKETS. PLEASE SEE PICTURES ATTACHED. THEY TOLD ME I…
Read full complaint
THE FRAME HAS RUSTED ON THE PASSENGER SIDE WHERE THE FRAME IS WELDED TOGETHER. THE CHICAGO NORTHSIDE TOYOTA DEALER FOUND IT WHILE DOING WORK ON MY VEHICLE. IT IS ABOUT A 3 INCH HOLE ON THE OUTSIDE OF THE FRAME AND THERE IS ALSO A RUSTED HOLE ON THE OPPOSITE SIDE NEAR THE BRACKETS. PLEASE SEE PICTURES ATTACHED. THEY TOLD ME IT IS UNSAFE TO DRIVE. THEY TRIED TO GET TOYOTA TO FIX IT BECAUSE THE SEQUOIA AND TUNDRA HAVE SIMILAR PROBLEMS AND WERE RECALLED. HOWEVER TOYOTA DECLINED.
TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS PARKED, CRACKS WERE SEEN IN THE DASHBOARD. THE DEALER (ZT MOTORS OF FORT WALTON BEACH, 1000 N BEAL PKWY NW, FORT WALTON BEACH, FL 32547, (850) 863-2167) WAS CONTACTED, BUT THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AN…
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS PARKED, CRACKS WERE SEEN IN THE DASHBOARD. THE DEALER (ZT MOTORS OF FORT WALTON BEACH, 1000 N BEAL PKWY NW, FORT WALTON BEACH, FL 32547, (850) 863-2167) WAS CONTACTED, BUT THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 22,000. *TT UPDATED 9/26/18*JB
TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN TOYOTA DEALER LOCATED IN UPATOI, GA WAS …
Read full complaint
TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN TOYOTA DEALER LOCATED IN UPATOI, GA WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
2004 V8 4 RUNNER WITH ONLY 62,000 MI.,FRAME FRACTURE RIGHT REAR @ LOWER CONTROL ARM ATTACHMENT POINT. LEFT REAR OF FRAME MISSING TWO SIDES @ WHEEL WELL AND LARGE HOLE AT LOWER CONTROL ARM ATTACHMENT. ADVISED BY MECHANIC NOT TO DRIVE THE TRUCK. THIS IS THE SAME ISSUE TOYOTA HAD WITH THE TACOMA AND TUNDRA TRUCKS OF THE SAME YEARS.…
Read full complaint
2004 V8 4 RUNNER WITH ONLY 62,000 MI.,FRAME FRACTURE RIGHT REAR @ LOWER CONTROL ARM ATTACHMENT POINT. LEFT REAR OF FRAME MISSING TWO SIDES @ WHEEL WELL AND LARGE HOLE AT LOWER CONTROL ARM ATTACHMENT. ADVISED BY MECHANIC NOT TO DRIVE THE TRUCK. THIS IS THE SAME ISSUE TOYOTA HAD WITH THE TACOMA AND TUNDRA TRUCKS OF THE SAME YEARS. THE FRAME IS RUSTED TO THE POINT THAT THE SUSPENSION THAT ATTACHES TO IT WILL FALL OFF. THE REST OF THE VEHICLE HAS NO RUST AND RUNS PERFECTLY.. IT WAS NEVER IN ANY ACCIDENT AND THE PAINT AND BODY ARE LIKE NEW, BUT THE FRAME MEMBERS ARE COMPLETELY RUSTED OUT. I WOULD HAVE NEVER KNOWN ABOUT THIS DANGEROUS CONDITION IF WASN'T FOR MY MECHANIC FINDING THIS DURING A ROUTINE MAINTENANCE.VISIT.
I'VE HAD THIS 2004 TOYOTA 4RUNNER SINCE 2004 I BOUGHT IT NEW AND HAVE TAKEN GOOD CARE OF IT. THE BODY STILL LOOKS GREAT, NO RUST ON BODY JUST HAS 94000 MILES ON IT. BUT THE UNDER SIDE IS AWFUL THE FRAME HAS HOLES RUSTED THROUGH AT HIGH PRESSURE POINTS LIKE SUSPENSION POINTS, CROSS MEMBERS FOR TRANSMISSION AND ENGINE RUSTED THROU…
Read full complaint
I'VE HAD THIS 2004 TOYOTA 4RUNNER SINCE 2004 I BOUGHT IT NEW AND HAVE TAKEN GOOD CARE OF IT. THE BODY STILL LOOKS GREAT, NO RUST ON BODY JUST HAS 94000 MILES ON IT. BUT THE UNDER SIDE IS AWFUL THE FRAME HAS HOLES RUSTED THROUGH AT HIGH PRESSURE POINTS LIKE SUSPENSION POINTS, CROSS MEMBERS FOR TRANSMISSION AND ENGINE RUSTED THROUGH, ITS TO POINT THAT ITS DANGEROUS TO DRIVE. I WAS TOLD BY TOYOTA SERVICE REP THAT THE FRAME HAS A FIFTEEN YEAR WARRANTY ON THEM BUT TOGETHER ARE SAYING THEY CAN'T FIX OR PLACE IT AND IT LOOKS LIKE I'M NOT ALONE ON THIS ISSUE. TOYOTA SHOULD STEP UP AND BACK THEIR PRODUCT ESPECIALLY IN SAFETY ISSUES. THEY WERE FORCED TO REPLACE FRAMES ON THE TACOMA'S. WHAT'S FUNNY I'VE BEEN TOLD BY TOYOTA REPS ALSO THAT THE 4RUNNER HAS THE VERY SAME FRAME AS THE TACOMA'S. SO IF THAT'S SO WHY CAN'T THEY REPLACE THESE ALSO? I THINK THIS IS REALLY BAD, YOU PAY A LOT FOR A VEHICLE AND IT STILL LOOKS LIKE NEW BUT HAVE TO CONSIDER PARKING IT BECAUSE YOU FEAR FOR YOUR FAMILIES LIVES. IT'S GETTING TO POINT YOU CAN'T TRUST IT ON THE ROAD. I THINK TOYOTA SHOULD BE HELD ACCOUNTABLE.
ON FEBRUARY 10, 2018, I WAS DRIVING MY 2004 4RUNNER IN A SNOWSTORM IN 4WD HIGH WHEN THE CHECK ENGINE LIGHT SUDDENLY CAME ON AND THE STABILITY CONTROL AND TRACTION CONTROL SYSTEMS IMMEDIATELY SHUT DOWN, CAUSING THE REAR OF THE VEHICLE TO START SLIDING AND PUTTING ME ON A COLLISION COURSE WITH ONCOMING TRAFFIC. I DON'T UNDERSTA…
Read full complaint
ON FEBRUARY 10, 2018, I WAS DRIVING MY 2004 4RUNNER IN A SNOWSTORM IN 4WD HIGH WHEN THE CHECK ENGINE LIGHT SUDDENLY CAME ON AND THE STABILITY CONTROL AND TRACTION CONTROL SYSTEMS IMMEDIATELY SHUT DOWN, CAUSING THE REAR OF THE VEHICLE TO START SLIDING AND PUTTING ME ON A COLLISION COURSE WITH ONCOMING TRAFFIC. I DON'T UNDERSTAND WHY TOYOTA DESIGNED ITS VEHICLES TO SHUT OFF THESE CRITICAL SAFETY FEATURES WHEN THE CHECK ENGINE LIGHT COMES ON. I SUGGEST THAT TOYOTA BE REQUIRED TO DEVELOP A SOFTWARE UPGRADE AND VOLUNTARILY RECALL THE AFFECTED VEHICLES TO INSTALL THE APPROPRIATE SOFTWARE FIX. I WROTE TO TOYOTA ON FEBRUARY 13, 2018 (SEE ATTACHMENT) EXPRESSING MY CONCERN. THREE AND A HALF MONTHS LATER, I HAVE YET TO RECEIVE EVEN A CURSORY RESPONSE FROM TOYOTA. THEREFORE, I FEEL I MUST NOW NOTIFY NHTSA OF MY CONCERNS.
Official recalls
216V065000 · Air Bags:side/window
Feb 5, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence & remedy
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
11V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP18002 · Frame Corrosion
Opened Aug 17, 2018 · Closed Mar 18, 2022
Status: closed (inferred from source dates) · Structure:frame And Members
On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.