Structure. Review the 309 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports3 fire reports14 injury reports

Electrical System complaints

20 reports

Clear category filter

Mileage unknown · Oct 20, 2024

Electrical SystemStructureSuspension

Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.

NHTSA ODI #11620842

Mileage unknown · Feb 19, 2024

Electrical SystemStructure

Read full complaint

The rear tailgate window shattered while vehicle was in driveway as soon as it was turned off. Before it shattered there was an odor of something like plastic burning. Fortunately no one was hurt by the exploding bits of glass. The sound the breaking glass make was loud and startled the passengers. Good thing the vehicle was not in motion on the street or highway. On the internet I saw where other people shared the same problem on their Toyota 4Runner. Then I saw that Toyota had put out, TSB-0189-17, which stated exactly what happened to my 4Runner. Due to this possibly dangerous incident this should be upgraded to a vehicle safety recall.

NHTSA ODI #11572821

Mileage unknown · Nov 22, 2023

Electrical SystemSteering

Read full complaint

I have taken my car to Mountain states Toyota as well as corwin toyota for a tripped light it has to do with vehicle stability system it trips leaving the vehicle stability option not usable. I have told both dealers not to just reset the code however this is what’s happening and they don’t seem to know why it’s doing this. we have repaired the knock sensors and speed sensors. It feels unsafe driving when this trips when road conditions call for all wheel drive. the technician can’t figure it out why. their only solution is to keep resetting. This is not the option I want I need it repaired and they don’t seem to want to do it or figure out and give us options on repair.

NHTSA ODI #11556430

155,000 miles · Jan 4, 2020

Electrical SystemService Brakes

Read full complaint

I WAS DRIVING MY CAR ON POOLER PARKWAY IN POOLER, GA ON A CITY STREET IN HEAVY TRAFFIC WHEN ALL OF A SUDDEN A BUZZER GOES OFF AND MY DASHBOARD IMMEDIATELY GIVES OFF MULTIPLE WARNING SIGNALS. VASC TRAC, TRAC OFF, ABS (I) BRAKE. I IMMEDIATELY PULL OFF TO THE SIDE OF THE ROAD AND TRY TO STOP THE CAR, BUT THE BRAKES FAIL. THIS INCIDENT COULD HAVE KILLED MY WHOLE FAMILY. I HAD TO HAVE THE CAR TOWED. CHATHAM TOYOTA IN SAVANNAH GA INFORMED ME THAT I WAS VERY LUCKY THAT I NOR MY FAMILY MEMBERS WERE HURT OR KILLED. THEY ALSO STATED TO REPAIR THIS WOULD BE $4,000.00 UNBELIEVABLE! TOYOTA SHOULD WARN AND INFORM ALL BUYERS OF THIS!!!!

NHTSA ODI #11297113

155,000 miles · Jan 4, 2020

Electrical SystemService Brakes

I WAS DRIVING AT A SPEED OF 50 MPH ON POOLER PARKWAY IN HEAVY TRAFFIC AND A BUZZER WENT OFF. ALL OF A SUDDEN MY DASHBOARD GIVES OFF MULTIPLE WARNING SIGNALS: VASC TRAC, TRAC OFF, ABS (I) BRAKE. I DO NOT KNOW WHAT THE PROBLEM IS SO I PULL OFF THE ROAD AND TRY TO STOP THE CAR, BUT THE BRAKES FAIL. I HAD TO HAVE THE CAR TOWED. CHA…

Read full complaint

NHTSA ODI #11297112

158,000 miles · Oct 20, 2017

Electrical SystemElectronic Stability Control (esc)Service Brakes

Read full complaint

ABS, VSB TRAC ON/OFF, AND BRAKE LIGHTS COME ON SUDDENLY ALONG WITH CONTINUOUS HIGH-PITCHED ALERT. BRAKES EVENTUALLY BECOME DIFFICULT TO WORK. HAD TOWED TO DEALER, BY THE TIME DEALER LOOKED AT, IT WASN'T HAPPENING AND THEY COULD FIND NOTHING WRONG. PICKED UP CAR, HAPPENED AGAIN ON WAY HOME (BOTH TIMES MAKING RIGHT HAND TURNS). I AM TOLD THIS MAY BE AN ELECTRONIC PROBLEM BUT REGARDLESS, TO FIX IT, IT WILL COST THOUSANDS OF DOLLARS ($4500 FIRST QUOTE) AND REQUIRING REPLACEMENT OF A NUMBER OF PARTS/AN ENTIRE ASSEMBLY: BRAKE BOOSTER/ACCUMULATOR/MASTER CYLINDER ASSEMBLY. BESIDES THE DANGEROUS CONDITION, DON'T UNDERSTAND WHY IS BUILT SUCH THAT SO MUCH WOULD HAVE TO BE REPLACED AND COST SO MUCH. PRIOR TO THIS, SEEMED TO HAVE HAD MORE THAN USUAL PROBLEM WITH BRAKES, WITH MULTIPLE FROZEN CALIPERS FOR EXAMPLE.

NHTSA ODI #11035217

Mileage unknown · Mar 10, 2016

Electrical SystemElectronic Stability Control (esc)Engine

LOSS OF COOLANT WITH NO VISIBLE SIGNS OF LEAKING. REPLACED SO MANY THINGS AND KEEP GETTING MISFIRES AND VSC LIGHTS ON CONSTANTLY. ROUGH START UP FOR ABOUT 30 SECONDS EVERY TIME STARTED. SLIGHT OVER HEATING IF IDLING ... ALL POINTS NOW LEAD TO BLOWN HEAD GASKET IN WHICH I READ MORE AND MORE AND COMMON WITH 04 V6S.

NHTSA ODI #10845999

79,000 miles · Feb 23, 2016

Electrical SystemElectronic Stability Control (esc)Power Train

Read full complaint

I HAVE AN ONGOING PROBLEM WITH OUR 2004 TOYOTA 4RUNNER. IT STARTED ABOUT 4 YEARS AGO WHEN THE MARYLAND STATE EMMISSION TEST FACILITY PLUGGED INTO MY ODBI2 PORT. ALL THE DASH LIGHTS WERE ON AND I WENT IN TO THE OFFICE AND COMPLAINED. I FILED A FORM WITH EMISSIONS. I WORK OUT OF TOWN, MY WIFE IS A TEACHER AND WE HAVE TWO SMALL KIDS. GOING TO THE DEALER WAS NOT AN OPTION UNTIL SCHOOL WAS OUR. IN THE MEAN TIME THE TRUCK DROVE FINE OTHER THAN NO FOUR WHEEL DRIVE AND THE TIRES SPINNING IF YOU HIT THE PEDDLE TO HARD (NO TRACTION CONTROL OR STABILITY CONTROL. TOOK THE TRUCK TO THE DEALER OVER THE SUMMER AND THEY HAD TO RESET THE VALUES FOR $110.00 THE FOUR WHEEL DRIVE WOULD NO LONGER ENGAGE. TOYOTA DEALER SAID ALL THE VALUES BEING ERASED WAS A COMMON PROBLEM WITH THAT YEAR AND MVA CHEEP SCANNERS. MARYLAND SAID THEY CALLED TOYOTA AND NO ONE HAD EVER HAD THAT PROBLEM. HAVE HAD THIS HAPPEN AGAIN LAST EMISSION TEST. BIGGEST PROBLEM IS THAT THE 4 WHEEL DRIVE NO LONGER FUNCTIONS. THE ACTUATOR DOESN'T ENGAGE THE 4 WHEEL DRIVE. THIS WAS APPARENT WHEN MY WIFE LOST CONTROL AND NEARLY FLIPPED THE TRICK OVER AFTER PICKING UP THE KIDS IN A SNOW STORM. I CLIMBED UNDER THE TRUCK IN THE SNOW AND PULLED THE COVER OFF THE ACTUATOR, PULLED OUT THE PLASTIC GEARS AND MANUALLY SHIFTED IT INTO 4 WHEEL DRIVE TO GET IT HOME. THE FOUR WHEEL DRIVE SYSTEM WAS ALWAYS USED AT LEAST EVERY MONTH UNTIL THE EMISSION TEST PROBLEMS JUST TO KEEP IT LUBERICATED. THE 4 WHEEL DRIVE OR LACK THERE OF, COULD HAVE CAUSED DEATH OR SERIOUS INJURY TO MY WIFE AND KIDS. THIS ACTUATOR IS A SERIOUS PROBLEM, IF THEY CAN'T DESIGN A ACTUATOR THAT OPERATES WHEN YOU NEED FOUR WHEEL DRIVE, ESPECIALLY IN AN EMERGENCY THAN GO BACK TO THE OLD STICK AND LINKAGE. 55 PEOPLE DIED IN THE BLIZZARD OF 2016 AND THERE COULD HAVE BEEN 3 MORE JUST BECAUSE OF A DESIGN FLAW! P.S. MY WIFE AND I BOUGHT IT NEW, NEVER OFF ROAD!

NHTSA ODI #10837656

121,000 miles · Aug 8, 2014

Electrical SystemService BrakesVehicle Speed Control

Read full complaint

8/6/14-STARTED MY 2004 4-RUNNER TO LEAVE WORK AND A HIGH-PITCHED ALARM SOUND STARTED AND THE VSC, ABS, AND OTHER DASH LIGHT SYMBOLS CAME ON. I REVERSED OUT OF MY PARKING SPOT, AND BRAKE, AND NOTHING OTHER THAN THOSE THINGS WAS OUT OF THE ORDINARY. I PULLED FORWARD AND PULLED INTO ANOTHER SPOT AND CALLED MY HUSBAND TO LET HIM HEAR WHAT WAS GOING ON TO SEE IF HE KNEW WHAT IT MAY BE. HE ASKED ME TO REVERSE, PULL FORWARD, AND SEE WHAT ELSE I HEARD/SAW, SO I DID SO DRIVING A SHORT DISTANCE (ABOUT 5 PARKING SPACES AWAY) ATTEMPTING TO EXIT THE 4TH LEVEL OF THE PARKING GARAGE I WAS IN. I STARTED TO BRAKE TO TURN LEFT AND NO BRAKES. I PUSHED THE BRAKE PETAL AS HARD AS I COULD WITH BOTH FEET AND NOTHING, SO I PUSHED THE PARKING BREAK AND AS IT CAME TO A STOP, I PANICKED AND THREW IT INTO PARK. I WAS WITHIN 1 FOOT OF THE CONCRETE WALL 4 STORIES OFF THE GROUND. GOT IT TO A LOCAL DEALER AND TOLD THEM I JUST GOT NEW BRAKES 6 WEEKS AGO, COULD THEY HAVE POSSIBLY GONE BAD? THEY CALLED AND SAID IT WAS THE ABS MODULE THAT NEEDED REPLACED AND THE USED PART AND LABOR IS $3000 AND THE NEW PART AND LABOR IS $5500.00. THIS IS NOT NORMAL WEAR AND TEAR. OTHERS HAVE HAD THIS ISSUE AND ARE BEING TOLD "RARE DEFECT". THIS "RARE DEFECT" COULD HAVE BARRELED ME THROUGH A CONCRETE WALL OR WORSE. THANKFULLY NO ONE WAS IN THE PARKING GARAGE WITH ME AT THE TIME AND I WAS AT A MINIMAL SPEED. I WAS LEAVING DURING A LUNCH BREAK. HAD I BEEN LEAVING AND THIS OCCURRED AFTER WORK, I WOULD HAVE HIT SOMEONE. WHAT WILL IT TAKE TO GET TOYOTA TO FIX THIS "RARE DEFECT"? I HAVE A CALL INTO THEM AND OF COURSE, NO CALL BACK YET. SO, I'M CURRENTLY STUCK WITH A VEHICLE THAT HAD A RECALL FOR AN ACCELERATION ISSUE AND A "RARE DEFECT" FOR A BRAKE ISSUE. *TR

NHTSA ODI #10620809

99,000 miles · Jul 2, 2014

Electrical SystemElectronic Stability Control (esc)Service Brakes

Read full complaint

SUFFERED SUDDEN, CATASTROPHIC FAILURE OF VSC/ABS BRAKE SYSTEM WHILE DRIVING. VSC, ABS, BRAKE DASH INDICATOR LIGHTS ILLUMINATED WITH AN AUDIBLE ALARM. VEHICLE OPERATED NORMALLY FOR ABOUT 1 MILE, THEN LOST MOST BRAKING CONTROL. NARROWLY AVOIDED COLLISION WITH ANOTHER VEHICLE DUE TO HAVING MINIMAL BRAKE SYSTEM. HAD TO USE EVASIVE STEERING AND EMERGENCY BRAKE MANEUVERS TO SLOW AND STOP VEHICLE. AFTER RESEARCHING THIS ISSUE ON AUTO REPAIR BLOGS THERE SEEMS TO BE A COMMON ISSUE WITH THE VSC/ABS SYSTEM IN MOST TOYOTA VEHICLES, ESPECIALLY CAMRY'S. REPLACEMENT OF THE DEFECTIVE PART COSTS $3200 AND TOYOTA REFUSES TO ACKNOWLEDGE THE PROBLEM OR HELP PAY FOR THE REPAIR SINCE MY VEHICLE IS OUT OF WARRANTY. CATASTROPHIC BRAKE FAILURE SHOULD NOT BE TOLERATED BY ANY MANUFACTURER. PERSONALLY, I BELIEVE A RECALL IS NEEDED ON ALL TOYOTA VEHICLES USING THE VSC/ABS SYSTEMS BEFORE MORE SERIOUS ACCIDENTS, INJURIES OR DEATHS OCCUR. *TR

NHTSA ODI #10607748

Official recalls

16V065000 · Air Bags:side/window

Feb 5, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.

Consequence & remedy

Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.

Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.

11V113000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP18002 · Frame Corrosion

Opened Aug 17, 2018 · Closed Mar 18, 2022

Status: closed (inferred from source dates) · Structure:frame And Members

On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal