Illustration2003 4RUNNER. CONSUMER STATES FRONT END COLLISION IN WHICH AIRBAGS DID NOT DEPLOY. *TGW THE CONSUMER STATED HIS WIFE HAS A PERMANENT NECK INJURY. *JB
2003 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 2003 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1425–50K
3750–75K
5075–100K
125100–150K
136150K+
382 reports with mileage · 145 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 278 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports0 fire reports8 injury reports
What owners actually said
527 reportsTL*-THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. A POLICE REPORT WAS FILED FOR THE INCIDENT. UPDATED 6/1/10 *CN THE CONSUMER STATED AS SHE REACHED FROM THE PASSENGERS SIDE OF THE VEHICLE TO TURN THE MOTOR OFF, THE VEHICLE SUDDENLY ACCELERATED BACKWARDS. THE CONSUMER STATED SHE TRIED TO RUN WITH THE VEHICLE, BUT IT WAS MOVING TOO FA…
Read full complaint
TL*-THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. A POLICE REPORT WAS FILED FOR THE INCIDENT. UPDATED 6/1/10 *CN THE CONSUMER STATED AS SHE REACHED FROM THE PASSENGERS SIDE OF THE VEHICLE TO TURN THE MOTOR OFF, THE VEHICLE SUDDENLY ACCELERATED BACKWARDS. THE CONSUMER STATED SHE TRIED TO RUN WITH THE VEHICLE, BUT IT WAS MOVING TOO FAST. THE PASSENGER DOOR WAS OPEN AND IT KNOCKED HER DOWN AND SHE HIT HER HEAD. THE VEHICLE THEN WENT INTO THE STREET AND THEN BEGAN TO ACCELERATE FORWARD AND THEN THE FRONT WHEEL OF THE VEHICLE RAN OVER HER. UPDATED 06/15/10.*JP
TOYOTA 4-RUNNER 2003 SIX CYLINDER. EXCESSIVE SULFUR DIOXIDE ODOR. NO EVENTS LEADING UP TO FAILURE. SPORADIC. DEALERSHIPS GAVE ME A HARD TIME, WANTED $150.00 TO RUN TEST EVEN THOUGH TOYOTA HEADQUARTERS INFORMED ME THAT THE DEALER SHOULD JUST REPLACE PARTS, SO I NEVER HAVE HAD IT FIXED BUT I AM CONCERNED. I CHANGED GAS STATI…
Read full complaint
TOYOTA 4-RUNNER 2003 SIX CYLINDER. EXCESSIVE SULFUR DIOXIDE ODOR. NO EVENTS LEADING UP TO FAILURE. SPORADIC. DEALERSHIPS GAVE ME A HARD TIME, WANTED $150.00 TO RUN TEST EVEN THOUGH TOYOTA HEADQUARTERS INFORMED ME THAT THE DEALER SHOULD JUST REPLACE PARTS, SO I NEVER HAVE HAD IT FIXED BUT I AM CONCERNED. I CHANGED GAS STATIONS NUMEROUS TIMES AND STILL RECEIVE THE ODOR. ODOR COMES AND GOES AND CAN BE STRONG AT TIMES ESPECIALLY IN COLD MONTHS. CONCERNS ARE THAT IT WILL BECOME WORSE AND THE SMELL IS TOXIC. *TR
2003 TOYOTA 4RUNNER WITH 57,000 MILES ACCELERATED FROM 5 MPH AFTER TAKING A TURN, TO 50 MPH. I PUMPED THE BRAKES BUT THE CAR DID NOT SLOW DOWN. I PUT ALL OF MY WEIGHT (I WEIGH 230 LBS.) ON THE BRAKE PEDAL AND AFTER 3 OR 4 SECONDS THE CAR STOPPED ACCELERATING. THE 4RUNNER IS NOT ON THE RECALL LIST BUT THERE ARE MANY SIMILAR …
Read full complaint
2003 TOYOTA 4RUNNER WITH 57,000 MILES ACCELERATED FROM 5 MPH AFTER TAKING A TURN, TO 50 MPH. I PUMPED THE BRAKES BUT THE CAR DID NOT SLOW DOWN. I PUT ALL OF MY WEIGHT (I WEIGH 230 LBS.) ON THE BRAKE PEDAL AND AFTER 3 OR 4 SECONDS THE CAR STOPPED ACCELERATING. THE 4RUNNER IS NOT ON THE RECALL LIST BUT THERE ARE MANY SIMILAR COMPLAINTS ON BOTH THE 4RUNNER AND OTHER TOYOTA MODELS THAT ARE NOT ON THE RECALL LIST. TOYOTA CANNOT BE TRUSTED. IF YOU OWN ONE, SELL IT. IF YOU DON'T THEN DON'T BUY ANY TOYOTA. THEY CONTINUE TO TRY TO HIDE THE TRUTH. *TR
TL*THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT HE WAS INVOLVED IN A FRONT END CRASH WHILE DRIVING APPROXIMATELY 50 MPH. THERE WERE NO INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE BEGAN PULLING TO THE LEFT WHEN THE LEFT TIRE LOCKED OR TO THE RIGHT WHEN THE RIGHT TIRE LOCKED. BOTH TIRES NEVER LOCKED AT …
Read full complaint
TL*THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT HE WAS INVOLVED IN A FRONT END CRASH WHILE DRIVING APPROXIMATELY 50 MPH. THERE WERE NO INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE BEGAN PULLING TO THE LEFT WHEN THE LEFT TIRE LOCKED OR TO THE RIGHT WHEN THE RIGHT TIRE LOCKED. BOTH TIRES NEVER LOCKED AT THE SAME TIME. THE ANTI-SKID LIGHT AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE DASHBOARD. THE FAILURE OCCURRED 5 TIMES IN A 4 MILE TRIP. THE FRONT END DAMAGE WAS REPAIRED AT A BODY SHOP. HE TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE YAW RATE SENSOR (IN THE BRAKE SYSTEM) NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER BUT WAS OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 124,000. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000.
I PURCHASED A BRAND NEW 2003 TOYOTA 4RUNNER IN MAY 2003. IN ONE COLD MORNING OF JAN. 2005, I WAS DRIVING IT IN HIGHWAY THAT WAS STILL COVERED WITH SOME SNOW. ALL OF SUDDEN, AN ENGINE CHECK LIGHT ON THE DASHBOARD WAS AUTOMATICALLY TURNED ON, FOLLOWED BY VSC LIGHTS, INDICATING THAT A VEHICLE SKID CONTROL FUNCTION WAS AUTOMATICAL…
Read full complaint
I PURCHASED A BRAND NEW 2003 TOYOTA 4RUNNER IN MAY 2003. IN ONE COLD MORNING OF JAN. 2005, I WAS DRIVING IT IN HIGHWAY THAT WAS STILL COVERED WITH SOME SNOW. ALL OF SUDDEN, AN ENGINE CHECK LIGHT ON THE DASHBOARD WAS AUTOMATICALLY TURNED ON, FOLLOWED BY VSC LIGHTS, INDICATING THAT A VEHICLE SKID CONTROL FUNCTION WAS AUTOMATICALLY TURNED OFF. AT THAT POINT, I COULD NOT DRIVE THE CAR BEYOND 50 MPH, NO MATTER HOW HARD OR FREQUENTLY I PUSHED THE ACCELERATOR PEDAL. I PULLED OVER, RESTARTED, AND RE-ENTERED THE HIGHWAY BUT HAD THE SAME RESULTS. I MANAGED TO DRIVE THE CAR TO A DEALER FOR INSPECTION THE SAME DAY. THE DEALER COULD NOT FIND A CAUSE AND SIMPLY RESET THE COMPUTER CONTROLLER. THIS SEEMED TO HAVE RESOLVED THE PROBLEM AT THAT TIME. HOWEVER, THE ENGINE CHECK AND VSC LIGHT ISSUES RESURFACED ABOUT TWO YEARS LATER. THE DIFFERENCE THIS TIME WAS THAT THERE WAS NO ACCELERATION ISSUE. NO INSPECTION WAS MADE. THE DASHBOARD LIGHTS WERE AUTOMATICALLY TURNED OFF AFTER DRIVING FOR ABOUT A MONTH. IN JAN. 2010, THOSE LIGHTS REAPPEARED AND HAVE REMAINED TURNED ON. NO IMPACT ON ACCELERATION HAS BEEN OBSERVED. *TR
ERRATIC THROTTLE RESPONSE AND ERRATIC/UNPREDICTABLE/DIFFICULT TO PREDICT BRAKE APPLICATION . *TR
I HAD ISSUES WITH THE BRAKE PEDALS EVER SINCE 2-3 YEARS INTO DRIVING THE VEHICLE. I HAVE A 2003 TOYOTA 4RUNNER AND THE BRAKE PEDAL IS NOT VERY RESPONSIVE. I HAD THE BRAKES, ROTORS AND BRAKE SYSTEM CHECKED AND THERE ARE NO ISSUES. MY BIGGEST ISSUE IS WITH THE BRAKE PEDAL ITSELF. I FEEL WHEN I HIT THE BRAKE, A GENTLE TAP DOESN…
Read full complaint
I HAD ISSUES WITH THE BRAKE PEDALS EVER SINCE 2-3 YEARS INTO DRIVING THE VEHICLE. I HAVE A 2003 TOYOTA 4RUNNER AND THE BRAKE PEDAL IS NOT VERY RESPONSIVE. I HAD THE BRAKES, ROTORS AND BRAKE SYSTEM CHECKED AND THERE ARE NO ISSUES. MY BIGGEST ISSUE IS WITH THE BRAKE PEDAL ITSELF. I FEEL WHEN I HIT THE BRAKE, A GENTLE TAP DOESN'T PRODUCE A RESPONSE. ONLY A MILD TO HARD STEP ON THE BRAKES WOULD CAUSE THE VEHICLE TO STOP. IM VERY WARY OF THIS B/C I ALWAYS HAVE TO HIT THE BRAKES HARD TO GET A RESPONSE. I FEEL THE BRAKE PEDAL IS LOOSE BECAUSE IT IS NOT VERY RESPONSIVE AND DOES NOT RESPOND TO TAPPING. IN FACT, IF I HIT THE BRAKES AND THE BRAKES DROP ONE INCH, THERE WOULD BE NO BRAKE RESPONSE. I HAD THE VEHICLE CHECKED BY TOYOTA DEALER AND THEY SAID ITS SOME SORT OF BRAKE PART THAT NEEDS TO BE REPLACED. UPON REPLACING THAT PART, I STILL FEEL THE SAME LOOSENESS IN THE BRAKE PEDAL. MY MOST SERIOUS CONCERN IS THAT WHEN I HIT THE BRAKES SOMETIMES B/C I HAVE TO HIT IT HARD, MY VEHICLE FEELS LIKE IT'S DRIFTING. THE WHEELS WOULD GO LEFT AND RIGHT AND THEN GO STRAIGHT. THIS DOES NOT HAPPEN OFTEN, BUT WHEN IT DOES, IT FREAKS ME OUT. AT FREEWAY SPEED, WHEN I HIT THE BRAKES, WHETHER ITS LIGHT OR SOFT, SOMETIMES, THE CAR JUST DOES THE RANDOM DRIFT. I FEEL ITS THE RESULT OF A LOOSE BRAKE PEDAL AND PERHAPS DELAYED RESPONSE TO THE TIRES. I CHANGED THE BRAKE PADS AND I HAD MY BRAKES INSPECTED OFTEN DUE TO THIS ISSUE. *TR
THE DRIVER'S SIDE SUN VISOR OF MY 2003 TOYOTA 4RUNNER BROKE AND HANGS DOWN, PARTIALLY BLOCKING MY VISIBILITY. THE PLASTIC PORTION OF THE SHAFT THE VISOR CONNECTS TO IS CHIPPED AND IS NOT HOLDING THE VISOR IN PLACE. *TR
WHILE DRIVING UPHILL IN THE SNOW, THE AUTOMATIC STABILITY CONTROL ON MY TOYOTA ENGAGED WITH A BEEPING SOUND AND A DASHBOARD INDICATOR LIGHT. ONCE THIS HAPPENED, SEVERAL OTHER LIGHTS ILLUMINATED ON THE DASHBOARD AND THE VEHICLE BEGAN TO ACCELERATE UP THE HILL. I ATTEMPTED TO BRAKE, BUT THE VEHICLE CONTINUED TO GAIN SPEED AND ST…
Read full complaint
WHILE DRIVING UPHILL IN THE SNOW, THE AUTOMATIC STABILITY CONTROL ON MY TOYOTA ENGAGED WITH A BEEPING SOUND AND A DASHBOARD INDICATOR LIGHT. ONCE THIS HAPPENED, SEVERAL OTHER LIGHTS ILLUMINATED ON THE DASHBOARD AND THE VEHICLE BEGAN TO ACCELERATE UP THE HILL. I ATTEMPTED TO BRAKE, BUT THE VEHICLE CONTINUED TO GAIN SPEED AND STRUCK THE BACK OF A PARKED PICKUP TRUCK ON THE SIDE OF THE ROAD. NO AIRBAG DEPLOYMENT OCCURRED. THE FRONT END DAMAGE WAS SIGNIFICANT, MAKING THE VEHICLE A TOTAL LOSS. *TR
Official recalls
311V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
03V146000 · Fuel System, Gasoline
Apr 14, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH V6 ENGINES, THE FUEL PULSATION DAMPER, LOCATED ON THE FUEL RAIL, MAY HAVE BEEN IMPROPERLY ASSEMBLED, CAUSING A DIAPHRAGM IN THE PULSATION DAMPER TO BE DAMAGED. IF THE DIAPHRAGM FAILS, FUEL MAY LEAK.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN ENGINE COMPARTMENT FIRE IF A HEAT SOURCE OR AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE PULSATION DAMPER. OWNER NOTIFICATION BEGAN MAY 5, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
02V339000 · Wheels
Dec 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
Consequence & remedy
Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP18002 · Frame Corrosion
Opened Aug 17, 2018 · Closed Mar 18, 2022
Status: closed (inferred from source dates) · Structure:frame And Members
On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.