IllustrationABS WARNING LITE STAYS ON, BRAKE LITE IS ON, VSC TRAC LITE ON. GOES ON & OFF INTERMITTENTLY. MOSTLY STAYS ON. BRAKES OCCASIONALLY FEEL CRUNCHY AND DO NOT STOP PROPERLY. AM CALLING FOR SERVICE TODAY. VEHICLE WILL BE PARKED UNTIL PROBLEM CAN BE RESOLVED. *TR
2003 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 2003 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1425–50K
3750–75K
5075–100K
125100–150K
136150K+
382 reports with mileage · 145 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 278 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports0 fire reports8 injury reports
What owners actually said
527 reports1. RIGHT FRONT BRAKE CALIPER FROZE. TOYOTA REPLACED FREE OF CHARGE. 2. LEFT REAR BRAKE CALIPER FROZE ON 05/05/2010 AT 95, 988 MILES. MY COST $490.73. LEFT FRONT BRAKE CALIPER FROZE ON 11/22/10 AT 102,712 MILES. MY COST $470.40. TOYOTA CLAIMED NO RESPONSIBILITY AS THERE WAS NO REQUIRED RECALL ON THAT PART. THEY TREAT BRAKE CALIPE…
Read full complaint
1. RIGHT FRONT BRAKE CALIPER FROZE. TOYOTA REPLACED FREE OF CHARGE. 2. LEFT REAR BRAKE CALIPER FROZE ON 05/05/2010 AT 95, 988 MILES. MY COST $490.73. LEFT FRONT BRAKE CALIPER FROZE ON 11/22/10 AT 102,712 MILES. MY COST $470.40. TOYOTA CLAIMED NO RESPONSIBILITY AS THERE WAS NO REQUIRED RECALL ON THAT PART. THEY TREAT BRAKE CALIPERS LIKE TIRES AND BRAKE PADS. I KNOW THAT CALIPERS SHOULD NOT FAIL. A FROZEN CALIPER CAN REDUCE BRAKING EFFICIENCY BY 25 % PLUS CAUSE INSTABILITY DURING BRAKING. I BELIEVE THE AVERAGE OWNER DOES NOT KNOW THAT CALIPERS SHOULD NOT FREEZE UP, SO THEY ARE BUYING TOYOTA'S DENIAL AS APPROPRIATE. UPDATED 01/20/11 *BF
THIS VEHICLE HAS A ROTTED FRAME WHICH IS PERFORATED IN AT LEAST 3 PLACES
DASH CRACKING IN 2003 TOYOTA 4 RUNNER. CRACKS MATERIALIZED FROM DRIVERS SIDE TO PASSENGER SIDE. NUMEROUS. EXACT DEALER RECOMMENDATIONS TO NOT USE ANYTHING OTHER THAN A DAMP CLOTH TO CLEAN THE DASH BOARD. THIS SUV IS GARAGED AND NORMALLY NOT OUT IN DIRECT SUNLIGHT. I HAVEN'T SEEN A DASH CRACK LIKE THIS SINCE THE OLD ONES BAC…
Read full complaint
DASH CRACKING IN 2003 TOYOTA 4 RUNNER. CRACKS MATERIALIZED FROM DRIVERS SIDE TO PASSENGER SIDE. NUMEROUS. EXACT DEALER RECOMMENDATIONS TO NOT USE ANYTHING OTHER THAN A DAMP CLOTH TO CLEAN THE DASH BOARD. THIS SUV IS GARAGED AND NORMALLY NOT OUT IN DIRECT SUNLIGHT. I HAVEN'T SEEN A DASH CRACK LIKE THIS SINCE THE OLD ONES BACK IN THE LATE 70'S. TOYOTA NEEDS TO STEP UP TO THE PLATE AND FIX THIS OBVIOUS FLAW IN THEIR DASH DESIGN. *TR
2003 TOYOTA 4RUNNER AWD V8 WITH ~99,990 MILEAGE. FRONT BRAKE CALIPER INNER PISTONS SEIZED AND INNER FRONT BRAKE PADS FAILED TO APPLY FOR INDETERMINATE TIME PERIOD (APPROXIMATELY 3 YEARS AND 30,000 MILES). HEAVY CORROSION OF CALIPER CONTACT SURFACES ALSO PREVENTED NORMAL TRAVEL OF OEM REPLACEMENT INNER BRAKE PADS. RESULTED IN …
Read full complaint
2003 TOYOTA 4RUNNER AWD V8 WITH ~99,990 MILEAGE. FRONT BRAKE CALIPER INNER PISTONS SEIZED AND INNER FRONT BRAKE PADS FAILED TO APPLY FOR INDETERMINATE TIME PERIOD (APPROXIMATELY 3 YEARS AND 30,000 MILES). HEAVY CORROSION OF CALIPER CONTACT SURFACES ALSO PREVENTED NORMAL TRAVEL OF OEM REPLACEMENT INNER BRAKE PADS. RESULTED IN REDUCED BRAKING FORCE AND INTERMITTENT BRAKE PEDAL PULSATION DUE TO THERMAL IMBALANCE OF THE ROTORS. PASSENGER SIDE INNER ROTOR SURFACE CORRODED BECAUSE NO BRAKE PAD CONTACT WAS OCCURRING. PROBABLY CONTRIBUTED TO FRONT WHEEL BEARING PREMATURE FAILURE DUE TO UNBALANCED BRAKING FORCE ON THE BRAKE ROTORS AND INORDINATE TORQUE ON THE BEARING ASSEMBLY. THIS VEHICLE HAS THE ORIGINAL FACTORY BRAKE FLUID (I.E., THE HYDRAULIC BRAKE SYSTEM HAS NEVER BEEN FLUSHED.) THIS IS A PERMANENT FAILURE OF THE BRAKING SYSTEM IN THIS VEHICLE. REPLACEMENT OF CALIPERS IS ANTICIPATED. FAILED CALIPERS COULD BE MADE AVAILABLE FOR INSPECTION BUT WILL ULTIMATELY BE RETURNED FOR CORE CHARGE. *TR
TL*THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 25-30 MPH, THE CONTACT APPLIED THE BRAKES AND HEARD A SQUEAKING NOISE. THE CONTACT STOPPED THE VEHICLE AND INSPECTED IT; HE COULD FIND NOTHING WRONG. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE BOTTOM TWO FLOATING CALI…
Read full complaint
TL*THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 25-30 MPH, THE CONTACT APPLIED THE BRAKES AND HEARD A SQUEAKING NOISE. THE CONTACT STOPPED THE VEHICLE AND INSPECTED IT; HE COULD FIND NOTHING WRONG. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE BOTTOM TWO FLOATING CALIPER PISTONS WERE LOCKED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 41,000. UPDATED 1/21/11 *CN UPDATED 02/07/11
SAFETY RELATED TO 2003 TOYOTA 4RUNNER SPORT EDITION SUV. DRIVER'S DOOR LOCKING MECHANISM FROZE UP FOR THE THIRD TIME IN TWO YEARS. THIS TIME, COULD NOT OPEN DRIVER SIDE DOOR BY ANY MEANS. 63-YEAR OLD DRIVER HAD TO EXIT OVER CONSOLE, THEN THROUGH PASSENGER DOOR. DRIVER LATER HAD TO RE-ENTER FROM PASSENGER SIDE, OVER THE CONSOLE I…
Read full complaint
SAFETY RELATED TO 2003 TOYOTA 4RUNNER SPORT EDITION SUV. DRIVER'S DOOR LOCKING MECHANISM FROZE UP FOR THE THIRD TIME IN TWO YEARS. THIS TIME, COULD NOT OPEN DRIVER SIDE DOOR BY ANY MEANS. 63-YEAR OLD DRIVER HAD TO EXIT OVER CONSOLE, THEN THROUGH PASSENGER DOOR. DRIVER LATER HAD TO RE-ENTER FROM PASSENGER SIDE, OVER THE CONSOLE IN ORDER TO DRIVE VEHICLE TO DEALERSHIP. TOOK IT TO THE DEALER AND WAS CHARGED OVER $500 FOR REPAIRS. POTENTIAL OF NOT BEING ABLE TO EXIT VEHICLE. THIS IS A FLAW OR DEFECT IS COMMONLY NOTED ON THE WORLD-WIDE WEB. THIS SHOULD HAVE BEEN A SAFETY RECALL ISSUE WITHOUT CHARGE FOR REPAIRS. *TR
2003 TOYTOA 4-RUNNER THAT HAS A 5 TO 6 IN CRACK IN THE PASENGER SIDE DASH THAT COULD CAUSE HUGE PROBLEMS WITH THE AIRBAG IF IT WERE TO DEPLOY. WITH THIS CRACK II THE DASH IT COULD CAUSE THE AIRBAG TO NOT DEPLOY, NOT DEPLOY PROPERLY OR POP WHEN DEPLOYING. IN ALL OF THESE SITUATIONS A PASSENGER COULD BE SEVERLY INJURED OR KILLED B…
Read full complaint
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
2003 TOYOTA 4RUNNER (V6-4WD) HAD 2 FROZEN FRONT BRAKE CALIPERS. HAD THE BRAKES CHECKED BC INTERMITTENT SQUEALING NOISE AND INCREASED BRAKING DISTANCES. ON EACH SIDE: OUTER BRAKE PAD BARELY HAD ANYTHING LEFT (LITERALLY LESS THAN PAPER THIN) + INNER BRAKE PAD LOOKED GREAT BC NEVER REALLY USED SINCE CALIPERS FROZEN. NEEDED BOTH FRO…
Read full complaint
2003 TOYOTA 4RUNNER (V6-4WD) HAD 2 FROZEN FRONT BRAKE CALIPERS. HAD THE BRAKES CHECKED BC INTERMITTENT SQUEALING NOISE AND INCREASED BRAKING DISTANCES. ON EACH SIDE: OUTER BRAKE PAD BARELY HAD ANYTHING LEFT (LITERALLY LESS THAN PAPER THIN) + INNER BRAKE PAD LOOKED GREAT BC NEVER REALLY USED SINCE CALIPERS FROZEN. NEEDED BOTH FRONT BRAKE PADS AND ROTORS REPLACED, ALONG WITH 2 CALIPERS (1 EACH SIDE). SO I BASICALLY HAD NO FRONT BRAKES FOR MONTHS AND NO WAY TO TELL UNLESS SOMEONE NOTICES THE OUTER PADS ARE WORN AND GOES TO REPLACE THEM. POOR DESIGN LEADING TO SAFETY ISSUE. *TR
I HAVE A CRACK IN THE DASH 1 FOOT LONG ABOVE THE PASSENGER AIRBAG ONLY 15000 MILES ON TRUCK. ALOT OF OTHER POST ARE ON THE INTERNET WITH SAME CRACK OR MORE. IT HAS ALWAYS BEEN GARAGED. I AM WORRIED THAT SOMETHING WILL SPILL AND SHORT THE AIRBAG. FOR A TRUCK DROVE SO LITTLE AND ALWAYS IN THE DARK THIS SHOULD NOT HAPPEN. TOYO…
Read full complaint
I HAVE A CRACK IN THE DASH 1 FOOT LONG ABOVE THE PASSENGER AIRBAG ONLY 15000 MILES ON TRUCK. ALOT OF OTHER POST ARE ON THE INTERNET WITH SAME CRACK OR MORE. IT HAS ALWAYS BEEN GARAGED. I AM WORRIED THAT SOMETHING WILL SPILL AND SHORT THE AIRBAG. FOR A TRUCK DROVE SO LITTLE AND ALWAYS IN THE DARK THIS SHOULD NOT HAPPEN. TOYOTA PLACE 9670 TRASK AV GARDEN GROVE CA ASKED TOYOTA TO REPLACE IT THEY SAID IT WAS A DEFECT. ANIKA FROM TOYOTA CAME TO LOOK AT A SHOWROOM CONDITION TRUCK AND SAID NO IT IS OUT OF WARRANTY. I WOULD HAVE TO PAY TO REPLACE IT IF I AM WORRIED ABOUT IT. IT WOULD BE $1000.00. I DO NOT HAVE THE MONEY AT THIS TIME. THEY DO NOT CARE. CALLED TOYOTA ON SAME DAY THEY SAID ANIKA SAID NO SO THAT IS AS GOOD AS IN STONE NOTHING MORE TO TALK ABOUT. THIS IS THE NEW TOYOTA MONEY OVER SAFETY. *TR
Official recalls
311V113000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
03V146000 · Fuel System, Gasoline
Apr 14, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH V6 ENGINES, THE FUEL PULSATION DAMPER, LOCATED ON THE FUEL RAIL, MAY HAVE BEEN IMPROPERLY ASSEMBLED, CAUSING A DIAPHRAGM IN THE PULSATION DAMPER TO BE DAMAGED. IF THE DIAPHRAGM FAILS, FUEL MAY LEAK.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN ENGINE COMPARTMENT FIRE IF A HEAT SOURCE OR AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE PULSATION DAMPER. OWNER NOTIFICATION BEGAN MAY 5, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
02V339000 · Wheels
Dec 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
Consequence & remedy
Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP18002 · Frame Corrosion
Opened Aug 17, 2018 · Closed Mar 18, 2022
Status: closed (inferred from source dates) · Structure:frame And Members
On August 7, 2018, the Office of Defects Investigation (ODI) received a defect petition from Mr. Gary Weinreich alleging premature frame corrosion failure in model year (MY) 2002 - 2006 Toyota 4Runner vehicles. The petitioner based his request upon a corrosion-related front suspension failure he experienced in his MY 2005 Toyota 4Runner, a class action lawsuit settlement involving other Toyota products, and other complaints of underbody corrosion in Toyota 4Runner vehicles that he found in NHTSA?s online complaint database. The petitioner submitted a complaint to NHTSA documenting his experience (NHTSA ID 11098055). On August 17, 2018, ODI opened DP18-002 to evaluate the petitioner?s request. ODI?s evaluation included information provided by the petitioner regarding his vehicle, facts related to the class action lawsuit cited by the petitioner, and consumer complaint data received by NHTSA regarding underbody corrosion in third and fourth-generation Toyota 4Runner vehicles.The undercarriage of the petitioner?s vehicle exhibited severe corrosion damage indicative of seawater immersion. The vehicle?s service history shows that concerns with underbody corrosion were first noted by a Toyota dealer in a multi-point vehicle inspection performed on April 28, 2011. The invoice for that inspection noted ?severe and excessive amount of rust on the undercarriage and on the drive shaft transmission.? Two years later, on October 21, 2013, another multi-point inspection by a Toyota dealer observed further progression of underbody corrosion damage, noting: ?rust on shocks/struts and other components,? ?rust on exhaust system,? ?both splash shields severely rusted,? and ?undercarriage very rusty.? On July 17, 2017, approximately 10 months prior to experiencing the suspension failure incident, an independent repair facility performing routine oil change and brake maintenance informed the Petitioner of a concern with ?excessive frame corrosion? on his vehicle. The service history, severe general corrosion damage, failure age, and environment do not support the petitioner?s allegation of premature corrosion failure.ODI?s analysis of NHTSA complaint data identified fifteen incidents of front lower control arm failure in fourth-generation Toyota 4Runner sport utility vehicles. Two of the failures, including the petitioner?s vehicle, involve vehicles operated in ocean front communities with continuous exposure to aerosolized marine salts and potential exposure to seawater immersion. The remaining thirteen failures all involved vehicles owned or previously registered in states with the greatest use of deicing salts to treat road surfaces in winter months (?Salt states?). On average, the front lower control arm failures occurred after 13.1 years in service in highly corrosive environments. The failure ages and environments do not support the petitioner?s allegation of premature corrosion failure. NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the p
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.