2001 Toyota 4RUNNER

FRAME RUST ISSUES. MY FRAME HAS BEEN RUSTING AWAY FOR THE ENTIRE TIME I'VE OWNED IT, AND IT ISN'T GETTING ANY BETTER. THE PASSENGER INSIDE FRAME RAIL IS RUSTED FROM THE REAR LOWER CONTROL ARM MOUNT TO THE CROSS MEMBER MOUNT MIDWAY DOWN THE FRAME. THE DRIVER INSIDE FRAME RAIL IS RUSTED AT THE LOWER CONTROL ARM MOUNT AS WELL, AND SLIGHTLY IN FRONT OF IT. WHEN I PURCHASED THE VEHICLE I NOTICED A SLIGHT PIT, AND DIDN'T THINK ANYTHING OF IT. OVER THE NEXT YEAR THAT PIT GOT BIGGER UNTIL THERE WAS A LARGE OPENING THAT YOU COULD FIT TWO HANDS INSIDE OF.

EXCESSIVE CORROSION TO FRAME AND RELATED CHASSIS COMPONENTS. THIS VEHICLE WAS BOUGHT IN 2001 AND SERVICED AT OUR LOCAL TOYOTA DEALER FOR ROUTINE SERVICE ALL THESE YEARS AND NEVER MENTIONED FRAME RUST,UNTIL WE HAD IT SERVICED AT A LOCAL MUFFLER REPAIR SHOP TO REPLACE THE EXHAUST SYSTEM. WE HAVE CONTACTED TOYOTA AND THEY INFORMED US THAT THE TRUCK IS OFF WARRANTY AND THAT THERE IS NOTHING THEY CAN DO FOR US, THIS IS WHY WE ARE CONTACTING NHTSA ,TO INFORM THE AGENCY OF THIS PROBLEM WHICH IS SIMILAR TO THE CASE CURRENTLY WITH THE TACOMA, SEQUOIA AND THE TUNDRA TUCKS MANUFACTURED BY TOYOTA

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE ENTIRE FRAME OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO NORTHWAY TOYOTA (727 NEW LOUDON RD, LATHAM, NY 12110, (888) 885-1583) AND THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL TO COVER THE REPAIR. THE MANUFACTURER ECHOED THE DEALER'S STATEMENT AND ISSUED CASE NUMBER: 1809211044. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 150,000.

THE FRAME ON MY 2001 ROTTED VERY QUICKLY FROM THE INSIDE OUT. IT IS THE SAME EXACT FRAME USED ON THE TACOMA (WHICH WAS RECALLED) AND ON THE 2002 4RUNNER, WHICH IS CURRENTLY UNDER INVESTIGATION. IF I DIDN'T GET THE NECESSARY FRAME REPAIRS IT EASILY COULD HAVE CRACKED IN HALF WHEN ON THE ROAD. THE MAIN AREAS OF ROT ARE LOCATED AT THE REAR CONTROL ARM (WHICH I HAD PROFESSIONALLY REPAIRED), AND UP FRONT NEAR THE SUSPENSION AND AXLE. MY BROTHERS 1997 4RUNNER AXLE AND SUSPENSION COMPLETELY FELL APART WHEN HE WAS DRIVING ON THE ROAD. HE WAS LUCKY TO NOT BE ON THE HIGHWAY. SOMEONE DEFINITELY NEEDS TO LOOK INTO THIS ISSUE. I PURCHASED THE VEHICLE FROM THE SOUTH FOUR YEARS AGO (2014) WITH A SPOTLESS ROCK HARD FRAME. FOUR YEARS LATER THE REAR CONTROL ARM AREAS MENTIONED ABOVE COMPLETELY ROTTED THROUGH. THIS SHOULD NOT HAPPEN! I LOVE MY 4RUNNER, BUT I CAN'T BELIEVE HOW THESE TRUCK FRAMES WEREN'T RECALLED ALONG WITH THE TACOMA FRAMES. IT IS THE SAME EXACT FRAME...

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. WHILE THE CONTACT WAS AT AN INDEPENDENT MECHANIC FOR A MUFFLER REPLACEMENT, HE WAS INFORMED THAT THE VEHICLE FRAME WAS SEVERELY RUSTED. THE MECHANIC STATED THAT THE MUFFLER COULD NOT BE REPLACED AND A LEAK WAS PRESENT. THE DEALER (MCGEE TOYOTA OF HANOVER, 860 WASHINGTON ST, HANOVER, MA 02339, (866) 942-1756) INFORMED THE CONTACT THAT THE FRAME AND DIFFERENTIAL HOUSING NEEDED TO BE REPLACED. THE DIFFERENTIAL HOUSING WAS REPAIRED, BUT THE FRAME WAS NOT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN INFORMED THE CONTACT THAT THE KNOCK SENSORS NEEDED TO BE REPLACED. THE TECHNICIAN ADVISED THE CONTACT NOT TO DRIVE THE VEHICLE BECAUSE THE FRAME WAS SEVERELY RUSTED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 256,518.