1997 Toyota 4RUNNER

1997 TOYOTA 4 RUNNER FRAME ROT AND RUST: I NOTICED RUST DEBRIS IN MY DRIVEWAY. I INSPECTED UNDER THE VEHICLE AND FOUND THAT THE INSIDE OF DRIVER-SIDE FRAME WAS COMPLETELY ROTTED WITH EXTENSIVE RUST ALONG ENTIRE LENGTH OF ADJACENT FUEL TANK. HOLES LARGE ENOUGH TO PUT FOUR FINGERS IN AND CRUMBLE. IT IS CLEAR THAT THE ROT HAS ALMOST GONE ENTIRELY THROUGH THE FRAME AS THERE ARE SEVERAL SMALL HOLES ON OUTSIDE OF FRAME AS WELL. THE RUST HAS ALSO SERIOUSLY COMPROMISED THE WELD SEAM ON THE SUSPENSION COMPONENT ATTACHED TO THE FRAME. RUST AND ROT OF THIS SEVERITY ON THIS VEHICLE IS ISOLATED ONLY TO THIS AREA OF THE FRAME. THE REST OF VEHICLE FRAME SHOWS TYPICAL SURFACE RUST AS EXPECTED WITH AGE OF VEHICLE. *TR

ORIGINAL OWNER, BOUGHT NEW. KEPT VEHICLE VERY WELL MAINTAINED WITH REGULAR INSPECTIONS ON A LIFT AND NO EVIDENCE OF FRAME RUST OR OTHER PROBLEMS. THEN ON ABOVE DATE AN INSPECTION SHOWED MANY SPOTS OF RUST ON THE FRAME - IT HAD BEEN ROTTING FROM THE INSIDE OUT. MULTIPLE BODY EXPERTS SAID IT WAS TOO FAR GONE TO REPAIR AND NOT SAFE TO DRIVE. FORTUNATELY IT DID NOT FAIL WHEN MY FAMILY AND I WERE ON THE HIGHWAY, POTENTIALLY KILLING US AND ANYONE AROUND US. TOYOTA CUSTOMER "EXPERIENCE" REPS REFUSED EVEN TO ACKNOWLEDGE A PROBLEM - AND I ESCALATED THIS AS FAR AS I COULD. THEY HAD NO ANSWER FOR WHY THEY BOUGHT BACK TACOMAS, TUNDRAS AND SEQUOIAS (WHICH HAVE THE SAME FRAME) BUT DID NOT EVEN ISSUE A MAINTENANCE ADVISORY FOR THE 4RUNNERS. IF THEY WON'T PAY ATTENTION TO THIS, THE GOVERNMENT SHOULD FORCE A RECALL. THE REST OF THESE VEHICLES ARE BUILT WELL AND THE FRAME MAY WELL FAIL FIRST, WHICH NO ONE EXPECTS. *TR

HAVING COMPLAINED ABOUT A CLUNKING NOISE IN THE REAR OF THE VEHICLE FOR QUITE SOME TIME TO THE TOYOTA DEALER, I WAS SOLD A NUMBER OF REPAIRS OVER THE LAST 15,000 MILES, INCLUDING REAR STABILIZER LINKS AND REAR SHOCKS. HOWEVER, THE NOISE PERSISTED. AFTER SPENDING HUNDREDS AND HUNDREDS OF DOLLARS ON REPAIRS, I HAVE NOW DISCOVERED THE REAR DRIVERS SIDE PORTION OF THE FRAME IN THE AREA UNDER THE REAR SEAT HAS TOTALLY ROTTED AWAY AND THE LOWER REAR CONTROL ARM WELDMENT IS NO LONGER ATTACHED TO THE FRAME, LEAVING THE VEHICLE UNSTABLE (SWAYING SIDE TO SIDE) AND UNSAFE. THE DEALERSHIP NEVER ADVISED ME OF ANY PROBLEM, LEADING ME TO SPEND THE MONEY ON THESE OTHER REPAIRS. THIS FRAME DESIGN HAS BEEN RECOGNIZED AS A PROBLEM BY TOYOTA A FEW YEARS BACK. TOYOTA PROVIDED RELIEF FOR THE SAME ISSUE ON THE TACOMA. OBVIOUSLY THE 4RUNNER SUFFERS THE SAME PROBLEM AND SHOULD BE EVALUATED AS THIS IS A VERY SERIOUS SAFETY ISSUE. *TR

THE VEHICLE HAD A BAD MUFFLER IN IT SO I TOOK INTO TO THE MUFFLER SHOP AND AS THEY FIXED THE MUFFLER THEY FOUND THAT THE ENTIRE FRAME OF THE CAR IS RUSTED OUT. THERE ARE SEVERAL HOLES IN THE FRAME. I DRIVE MY CHILDREN IN THIS CAR EVERYDAY ( 4 YEARS OLD AND 1 YEAR OLD) CAR IS NOT SAFE AND I AM CURRENTLY OUT A VEHICLE AND CANNOT AFFORD ANOTHER ONE. STILL TRYING TO FIGURE OUT A SOLUTION. THE ENTIRE FRAME IS DAMAGED. *TR