NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
29 reportsClear category filterMileage unknown · Dec 3, 2025
SteeringSuspension
The vehicle exhibits harmonic oscillation in the steering column since the day I drove the vehicle home on the interstate. Even though tires had been balanced out of pocket due to long service center wait times with a road force balancer, balanced again at the service center, match mounted and road force balanced again out of my…
Read full complaint
The vehicle exhibits harmonic oscillation in the steering column since the day I drove the vehicle home on the interstate. Even though tires had been balanced out of pocket due to long service center wait times with a road force balancer, balanced again at the service center, match mounted and road force balanced again out of my own pocket, noise reducing foam removed and balanced on an uncalibrated balancer that resulted in a same day bring back and final road force balance. Service center refused to troubleshoot further after lead tech drove vehicle after third attempt of repair. I asked whether the tech felt the vibration and the service advisors face turned red, and fed the line that it is normal NVH from the solid front drive unit mounts and that was Tesla's stance. This issue has been widely reported online to vehicles that are RWD as well. The bad wheel balance exacerbates the harmonic in the column. Exceptional wheel balancing with RVF down to 6lbs on the front wheels only made it less intense. When driving on any uneven road, or crossing bridge expansion gaps for example, the steering oscillation gets worse, as the uneven roads make it worse. Reasonably assumed at this point it is not caused by just a balance issue. Tesla refused to try a set of known good wheels on the vehicle. This is not normal NVH or general road feel; something in the front end of the vehicle gets into harmonic oscillation. I asked if Tesla would like to keep the car for a proper diagnostic and whether they had looked into other components of the front end, and if they were not going to diagnose further I'd request a buyback. The simple response was that a buyback request would be initiated. It could be a myriad of issues, none of which should be my responsibility to try and track down or fix on a vehicle that exhibited the behavior since day one and still does after 1500 miles. I've passed the account to the service center manager and district manager yet to no reply.
NHTSA ODI #11702670
Mileage unknown · Dec 2, 2025
Suspension
Obviously Tesla accepts the very serious problem that it is presenting in the vast majority of Model Y juniper 2026 specifically in the RWD line, they are making deliveries of these vehicles without having gone through a rigorous quality control that determines that the noise actually exists and that over time they could affect …
Read full complaint
Obviously Tesla accepts the very serious problem that it is presenting in the vast majority of Model Y juniper 2026 specifically in the RWD line, they are making deliveries of these vehicles without having gone through a rigorous quality control that determines that the noise actually exists and that over time they could affect too many components of the suspension and end up compromising the stability of the vehicle, violating road safety issues, it is something unprecedented and absurd that they do not even take the task of checking the cars exhaustively and determining the root failure that this suspension problem implies, it is a noise as if the front shock absorbers did not work and were totally dislocated, out of their normal location.
NHTSA ODI #11702619
Mileage unknown · Dec 2, 2025
SteeringSuspension
Severe lateral swaying / side-to-side swaying (“boat-like” or “floaty” motion) at highway speeds (65–80 mph) on any concrete-surface interstate, especially grooved or slightly uneven concrete (typical on Illinois highways such as I-90, I-294, I-55, etc.). Description of safety concern: The vehicle continuously rocks side-to-side…
Read full complaint
Severe lateral swaying / side-to-side swaying (“boat-like” or “floaty” motion) at highway speeds (65–80 mph) on any concrete-surface interstate, especially grooved or slightly uneven concrete (typical on Illinois highways such as I-90, I-294, I-55, etc.). Description of safety concern: The vehicle continuously rocks side-to-side in a pronounced, pendulum-like motion that requires constant steering corrections to stay in the lane. The motion is severe enough to cause motion sickness in passengers within minutes and makes the driver tense and fatigued. In crosswinds or when passing trucks the swaying becomes even worse and feels unstable. I no amount of lane centering or driver input fully eliminates the sensation. Service history: December 2025 – Schaumburg, IL Tesla Service Center • Technician test-drove with me on I-90 and immediately felt the exact swaying I described. • Service advisor and service manager both stated this is a “normal characteristic of the 2025 Model Y Juniper” and that no repair or adjustment is possible. • Loaner 2025 Model Y Juniper provided exhibited identical swaying behavior. I do not believe constant, pronounced lateral instability at normal highway speeds is an acceptable “characteristic” in any passenger vehicle. It impairs control, increases driver fatigue, and creates a legitimate safety risk, especially in adverse weather or emergency maneuvers. Tesla refuses to acknowledge this as a defect. I am therefore requesting NHTSA investigate whether the 2025 Tesla Model Y suspension calibration and/or damper tuning creates an unreasonable safety risk due to excessive lateral instability on typical U.S. concrete highways
NHTSA ODI #11702553
Mileage unknown · Nov 25, 2025
SteeringSuspension
Hi, its not really an incident but I found what have happened suspicious. I got my tesla from the delivery zone at the Giga factory in Austin, TX last Wednesday. Right after the delivery i found an issue with steering wheel alignment. Steering wheel was tilted right and car was pulling right in the road. I addressed this issue t…
Read full complaint
Hi, its not really an incident but I found what have happened suspicious. I got my tesla from the delivery zone at the Giga factory in Austin, TX last Wednesday. Right after the delivery i found an issue with steering wheel alignment. Steering wheel was tilted right and car was pulling right in the road. I addressed this issue to Tesla and visited service center last Saturday Nov-22nd. Technician confirmed an issue. Wheels alignment was performed on the vehicle and it was returned to me on the same day. As soon as I got the the road I found that issue wasn't fixed. It went better but not fully fixed. I came to the service center again. Senior technician took a ride with me and confirmed the issue again. She also told me that they will probably will have to look into suspension because alignment didnt help last time and it could be more serious issue. The car was taken care of and returned to me in 90 min or so. Service advisor told me that suspension and steering were torqued and another alignment performed. When I took it to the road and I found that issue was fixed and I'm happy now but ifter that i recieved a message from the Service Center that I found suspicious. Despite the communication in person in the message afterwards was stating that no issues were found (See attach). I found this suspicious and decided to let you know as that may look like an attempt to hide some serious safety concern with steering. Please find screenshot in the attachment
NHTSA ODI #11701417
Mileage unknown · Oct 28, 2025
Suspension
I recently purchased a new Tesla Model Y (Juniper refresh). The vehicle has a loud clunking/creaking noise coming from the front suspension at low speeds, especially when driving over small bumps, turning into driveways, or when the road surface is uneven. The noise is noticeable inside the cabin and feels like a mechanical comp…
Read full complaint
I recently purchased a new Tesla Model Y (Juniper refresh). The vehicle has a loud clunking/creaking noise coming from the front suspension at low speeds, especially when driving over small bumps, turning into driveways, or when the road surface is uneven. The noise is noticeable inside the cabin and feels like a mechanical component is shifting. I brought the vehicle to Tesla Service. They confirmed the noise and told me it is not caused by the damper assembly but is a known issue that Tesla’s engineering team is currently investigating. However, no permanent fix is currently available, and the issue has not been resolved. I am concerned that this may be related to a suspension component failure or premature wear that could impact steering stability or control over time. Since this affects a brand-new vehicle and others have reported similar symptoms online, I believe this should be monitored as a potential safety defect. I am requesting that NHTSA track this issue to ensure Tesla provides a proper correction and repair campaign if necessary.
NHTSA ODI #11696007
Mileage unknown · Oct 22, 2025
Service BrakesSuspensionUnknown Or Other
Since I purchased my 2026 Tesla Model Y RWD, the vehicle has had a persistent mechanical noise and vibration issue coming from the front suspension and brake area. This issue has been ongoing since the first weeks of ownership and has not been repaired or properly diagnosed after multiple service visits. Details -Component/Syste…
Read full complaint
Since I purchased my 2026 Tesla Model Y RWD, the vehicle has had a persistent mechanical noise and vibration issue coming from the front suspension and brake area. This issue has been ongoing since the first weeks of ownership and has not been repaired or properly diagnosed after multiple service visits. Details -Component/System Failed: Front suspension/brake assembly (unknown exact component; may involve control arms, bushings, or brake rotors). -Availability for Inspection: Yes, the vehicle and recorded videos are available for inspection upon request. -Safety Risk: The vehicle produces loud clunking or popping noises when driving between 10–20 mph or when turning and braking. It feels unstable and unsafe at times, especially on wet roads. This raises concern about potential front-end component failure while driving. -Reproduction and Confirmation: The issue has been reproduced and confirmed multiple times by Tesla Service in Vancouver, WA and Portland, OR. Tesla’s internal system shows that the issue was escalated for “in-car investigation by engineering,” but no permanent repair was completed. -Inspection History: Tesla technicians and engineers have inspected the vehicle several times. I also recorded multiple videos with cameras mounted inside the fender to document the sound and provide visual proof of the problem. -Warning Lamps or Messages: No warning lights appear. The issue is purely mechanical but noticeable during low-speed operation. The first symptoms appeared within the first month of delivery. -Manufacturer Contact: Tesla Service Centers in Vancouver and Portland are aware of the issue and have escalated it, but no resolution has been provided. This problem has continued for months despite repeated service visits. The vehicle was identified as needing further “factory-level investigation,” but I was told the local service centers cannot fix it. I believe the issue may be a manufacturing or design defect affecting suspension safety. My life is risk
NHTSA ODI #11694900
10 miles · Sep 11, 2025
SteeringSuspension
The contact owns a 2026 Tesla Model Y. The contact stated while driving and exceeding 70 MPH, the vehicle drifted to the right. The contact stated that the vehicle was vibrating abnormally. The vehicle was taken to the local dealer who was unable to identify the cause of the failure. The vehicle was not diagnosed or repaired. T…
Read full complaint
The contact owns a 2026 Tesla Model Y. The contact stated while driving and exceeding 70 MPH, the vehicle drifted to the right. The contact stated that the vehicle was vibrating abnormally. The vehicle was taken to the local dealer who was unable to identify the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 10.
NHTSA ODI #11686667
Mileage unknown · Jul 21, 2025
SuspensionUnknown Or OtherWheels
Issue: A consistent rattling noise, noticeable while driving at speeds of 10-40 mph over bumpy roads or pot holes.
NHTSA ODI #11675071
Mileage unknown · Jul 1, 2025
SteeringSuspensionWheels
After doing multiple search online came across multiple user complaints about new Tesla model y juniper 2026 Lr awd you can feel vibration from steering wheel at highway speeds it is really specific at 80mph this is not a normal behavior especially vibrations took it to the service center and was told it was the wheels are not b…
Read full complaint
After doing multiple search online came across multiple user complaints about new Tesla model y juniper 2026 Lr awd you can feel vibration from steering wheel at highway speeds it is really specific at 80mph this is not a normal behavior especially vibrations took it to the service center and was told it was the wheels are not balanced properly so they fixed it apparently but is still doing it. I truly believe there is something Tesla knows but is not acknowledging it.
NHTSA ODI #11670595
Official recalls
8Aug 31, 2026
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence & remedy
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Additional source detail variants (2)
Suspension:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Suspension:front
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Jul 7, 2026
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence & remedy
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
Additional source detail variants (2)
Structure:body:bumpers
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
Air Bags:knee Bolster
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
May 18, 2026
Tesla, Inc. (Tesla) is recalling certain 2025-2026 Model Y vehicles. The certification label may not have been installed. As such, these vehicles fail to comply with the requirements of 49 C.F.R. Part 567, "Certification."
Consequence & remedy
Consequence: Missing weight information provided by the label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: Tesla Service will inspect and install a certification label as necessary, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-19-002.
Oct 10, 2025
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-16-005.
Oct 1, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Additional source detail variants (2)
Electrical System:wiring
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Exterior Lighting:back Up Lights
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Jul 28, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The ring terminal of the horn ground wire may be improperly secured, allowing the circuit to open and preventing the horn from sounding.
Consequence & remedy
Consequence: An inoperable horn may prevent the driver from alerting other drivers as needed, increasing the risk of a crash.
Remedy: Tesla service will replace the steering wheel, free of charge. Owner notification letters were be mailed September 23, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-009.
Jun 18, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model 3 and Model Y vehicles. The fasteners attaching the seat back to the seat bottom may have been improperly tightened.
Consequence & remedy
Consequence: The seat may not properly restrain the occupant, increasing the risk of injury during a crash.
Remedy: Tesla Service Centers will inspect and tighten or replace the seat assembly fasteners as necessary, free of charge. Owner notification letters were mailed August 16, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-13-003.
May 29, 2025
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The hose connector may block the windshield washer nozzles, preventing washer fluid from reaching the windshield. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 104, "Windshield Wiping and Washing Systems."
Consequence & remedy
Consequence: The inability to clean the windshield reduces the driver’s visibility and increases the risk of a crash.
Remedy: Tesla service will inspect and replace the wiper arm elbow connector as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-20-001.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26002 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Mar 18, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and capabilities of the updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI discussed individual incidents and its initial findings during the PE phase of its investigation with Tesla. As part of those discussions, Tesla’s post-incident analysis indicated that the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s degradation detection system, both as originally deployed and later updated, fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants. In the crashes that ODI has reviewed, the system did not detect common roadway conditions that impaired camera visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. In upgrading PE24031 to an Engineering Analysis (EA), ODI will gather further information on the updated degradation detection system, including the status of updating vehicles and scope of compatible vehicles, the system’s visibility degradation detection capability, and alerts or warnings to the driver. Lastly, ODI will conduct analysis on six recent potentially related incidents. These incidents can be found at NHTSA.gov under the following SGO report identification numbers: 13781-11937, 13781-13211, 13781-13569, 13781-13633, 13781-13693, 13781-13788. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
PE25012 · Traffic Safety Violations While Full Self Driving ("fsd") Is Engaged
Opened Oct 7, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects of the driving task, requiring a driver to supervise and intervene as necessary. The driver remains fully responsible at all times for driving the vehicle, including complying with applicable traffic laws. ODI’s investigation will therefore focus, in particular, on whether certain driving inputs within the control authority of FSD forestall the driver’s supervision when they are unexpectedly performed. ODI has identified a number of incidents in which the inputs to the dynamic driving task commanded by FSD induced vehicle behavior that violated traffic safety laws. Although reports of this nature span a variety of behaviors, the reports appear to most commonly involve two types of scenarios. The first type of scenario involves a vehicle operating with FSD proceeding into an intersection in violation of a red traffic signal. The second type of scenario involves FSD commanding a lane change into an opposing lane of traffic. With respect to the first type of scenario, ODI has identified 18 complaints and 1 media report alleging that a Tesla vehicle, operating at an intersection with FSD engaged, failed to remain stopped for the duration of a red traffic signal, failed to stop fully, or failed to accurately detect and display the correct traffic signal state in the vehicle interface. Some complainants also alleged that FSD did not provide warnings of the system's intended behavior as the vehicle was approaching a red traffic signal. ODI has identified six Standing General Order ("SGO") reports in which a Tesla vehicle, operating with FSD engaged, approached an intersection with a red traffic signal, continued to travel into the intersection against the red light and was subsequently involved in a crash with other motor vehicles in the intersection. Of these incidents, four crashes resulted in one or more reported injuries. At least some of the incidents appeared to involve FSD proceeding into the intersection after coming to a complete stop. ODI's pre-investigative work, including coordination with the Maryland Transportation Authority and State Police, indicated that the problem may be repeatable, given that multiple subject incidents occurred at the same intersection in Joppa, Maryland. NHTSA understands that Tesla has since taken action to address the issue at this intersection. With respect to the second type of scenario, ODI has identified 2 SGO reports, 18 complaints, and 2 media reports alleging that a Tesla vehicle, operating with FSD engaged, entered opposing lanes of travel during or following a turn, crossed double-yellow lane markings while proceeding straight, or attempted to turn onto a road in the wrong direction despite the presence of wrong-way road signs. Likewise, ODI has identified 4 SGO reports, 6 complaints, and 1 media report alleging that a Tesla vehicle, operating with FSD engaged, proceeded straight through an intersection in a turn-only lane or executed a turn at an intersection in a through lane despite the presence of lane markings or signals. Complaints also alleged that FSD did not provide warnings of the system's intended behavior. Some complaints alleged that more than one of these failures occurred and, as such, the numbers are not cumulative. Some of the reported incidents appeared to involve FSD executing a lane change into an opposing lane of travel with little notice to a driver or opportunity to intervene. ODI’s review will assess whether there was prior warning or adequate time for the driver to respond to the unexpected behavior or to safely supervise the automated driving task. This review will assess any warnings to the driver about the system's impending behavior; the time given to drivers to respond; the capability of FSD to detect, display to the driver, and respond appropriately to traffic signals; and the capability of FSD to detect and respond to lane markings and wrong-way signage. NHTSA's review will also consider any updates or modifications to the system(s) that may affect the performance of FSD with respect to obeying traffic safety laws and signals. This assessment will focus, in particular, on the types of traffic safety violations described above, as most reports identified thus far have centered around those behaviors. While the behaviors under investigation appear to occur most frequently at intersections, NHTSA’s investigation will encompass any other types of situations in which this behavior may arise, such as when traveling adjacent to a lane of opposing traffic or when approaching railroad crossings. If other evidence received during this investigation involve other types of traffic safety violations, those may be considered as part of this assessment as well. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov. The SGO reports cited in this Resume are listed below by report ID and are available for download at NHTSA.gov/laws-regulations/standing-general-order-crash-reporting. 13781-8739-1, 13781-8995-1, 13781-9623-1, 13781-10333-1, 13781-10872-1, 13781-10930-1, 13781-10939-1, 13781-10941-1, 13781-11069-1, 13781-11305-1, 13781-11579-1 Media reported allegations included as a separate attachment.
AQ25002 · Compliance With Standing General Order 2021-01 Reporting Requirements
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a single batch, while others were submitted on a rolling basis. Preliminary engagement between ODI and Tesla on the issue indicates that the timing of the reports was due to an issue with Tesla’s data collection, which, according to Tesla, has now been fixed. NHTSA is opening this Audit Query, a standard process for reviewing compliance with legal requirements, to evaluate the cause of the potential delays in reporting, the scope of any such delays, and the mitigations that Tesla has developed to address them. As part of this review, NHTSA will assess whether any reports of prior incidents remain outstanding and whether the reports that were submitted include all of the required and available data. The SGO reports cited in the Opening Resume, can be found at NHTSA.gov/SGOCrashReporting under the following SGO 2021-01 report IDs: 13781-11020-1 13781-10844-1 13781-10843-1 13781-10530-1 13781-10160-1 13781-10159-1 13781-10157-1 13781-10146-1 13781-10122-1 13781-10098-1 13781-10097-1 13781-10096-1 13781-10095-1 13781-10094-1 13781-10093-1 13781-10023-1 13781-10022-1 13781-10021-1 13781-10020-1 13781-10017-1 13781-10016-1 13781-10015-1 13781-10014-1 13781-10013-1 13781-10012-1 13781-6047-1 13781-9930-1 13781-9917-1 13781-9928-1 13781-9925-1 13781-9924-1 13781-9923-1 13781-9922-1 13781-9835-1 13781-9834-1 13781-9833-1 13781-9832-1 13781-9831-1 13781-9830-1 13781-9829-1 13781-9827-1 13781-9818-1 13781-9780-1 13781-9779-1 13781-9778-1 13781-9777-1 13781-9775-1 13781-9774-1 13781-9773-1 13781-9772-1 13781-9771-1 13781-9770-1 13781-9728-1 13781-9688-1 13781-9715-1 13781-9714-1 13781-9713-1 13781-9712-1 13781-9711-1 13781-9710-1 13781-9709-1 13781-9696-1 13781-9695-1 13781-9694-1 13781-9693-1 13781-9692-1 13781-9691-1 13781-9690-1 13781-9687-1 13781-9686-1 13781-9342-1 13781-9319-1 13781-9019-1 13781-8910-1 13781-8732-1 13781-8712-1 13781-8310-1 13781-7897-1 13781-7895-1 13781-7835-1 13781-7798-1 13781-7797-1 13781-7758-1 13781-7757-1 13781-7756-1 13781-7755-1 13781-7667-1 13781-7399-1 13781-7398-1 13781-7397-1 13781-7396-1 13781-7395-1 13781-7394-1 13781-7393-1 13781-7389-1 13781-7388-1 13781-7387-1 13781-7386-1 13781-7385-1 13781-7383-1 13781-7187-1 13781-7186-1 13781-7185-1 13781-7184-1 13781-7181-1 13781-7023-1 13781-6399-1 13781-6389-1 13781-6388-1 13781-6387-1 13781-6386-1 13781-6379-1 13781-6378-1 13781-6377-1 13781-6375-1 13781-6214-1 13781-6172-1 13781-6155-1 13781-6154-1 13781-6122-1 13781-6120-1 13781-6118-1 13781-5800-1
PE24033 · Actually Smart Summon Sessions Resulting In low-speed Impacts.
Opened Jan 6, 2025 · Closed Apr 3, 2026
Status: closed (inferred from source dates) · Electrical System:adas:autonomous/self Driving
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Summon reported crashes involved minor property damage claims with no reported incidents involving a vulnerable road user, injury, fatality, or major property damage as indicated by an air bag deployment or vehicle tow away. Out of millions of Summon sessions, a fraction of 1% resulted in an incident. Almost all those incidents took place where, typically early in a Summon session, the system or person using the app failed to fully detect or respond appropriately to vehicle surroundings resulting in minor impacts. Incidents took place when app users did not have a complete 360-degree view of the surroundings in the app to assess situational awareness. This limited the app user’s ability to determine whether an impact was imminent during initial vehicle maneuvers such as reversing in close proximity to an obstacle or a curb. ODI found that the impacts most often occurred with parking gates, adjacently parked vehicles, and short parking bollards. During this investigation, ODI identified two Summon crashes related to camera blockages. In both crashes, Summon attempted to navigate a snowy parking lot with snow partially or fully obstructing the forward-facing cameras. Summon did not detect the camera blockage and the vehicles collided with unoccupied parked vehicles while navigating the parking lot. App users in both instances did not command a vehicle stop or pause despite the obstructed camera visible in the camera stream in the app. On January 15, 2025, Tesla released Over-the-Air (OTA) Software (SW) Update Action numbers 578998 and 579185 for vehicles in service to implement a camera blockage detection condition. Both OTAs improve camera blockage detection mechanisms. Additionally, on January 20, 2025, and January 30, 2025, Tesla identified additional system requirements associated with camera visibility checks and released OTA SW-578752 and SW-580322, respectively. These firmware updates reduce false negative camera blockage detections due to snow or condensation. In its investigation, ODI identified one Summon incident where the vehicle did not yield for a gate arm blocking a garage exit lane and the app user did not command a vehicle stop or pause, resulting in an impact. On February 6, 2025, Tesla deployed OTA SW-578839 to improve vehicle reaction to dynamic gates. This OTA update upgraded vehicle perception systems through a high-fidelity occupancy determination network, which uses data from vehicle sensory systems to improve reconstruction of field objects with high accuracy. On November 20, 2025, Tesla further improved vehicle performance by adding object detections from a separate neural network through OTA SW-580514. Owners of the affected vehicles received all six OTA SW updates. Tesla also released these SW updates to production vehicles. See online public file for detailed descriptions of all six OTA SW updates. Due to low incident occurrence and low incident severity, this preliminary evaluation is closed. The closing of this investigation does not constitute a finding that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by future circumstances. For additional information regarding this investigation, see the complete online public file.
Illustration