NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
37 reportsClear category filterMileage unknown · Apr 25, 2025
Forward Collision AvoidanceVehicle Speed ControlCrash
On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into …
Read full complaint
On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11656833
Mileage unknown · Dec 30, 2024
Forward Collision AvoidanceVehicle Speed Control
On drives longer than 40 miles, camera faults cause cruise control systems to degrade in function and then when the faults are cleared, full functionality resumes without driver alerts. Side repeater camera feeds and rear camera feeds inconsistently load, or take an extended time period to load (10+ seconds). Tesla has confirmed…
Read full complaint
On drives longer than 40 miles, camera faults cause cruise control systems to degrade in function and then when the faults are cleared, full functionality resumes without driver alerts. Side repeater camera feeds and rear camera feeds inconsistently load, or take an extended time period to load (10+ seconds). Tesla has confirmed that the autopilot computer (HW3) likely needs to be replaced, but this error/messaging is not directly accessible to the customer. The inconsistent failure behavior of the vehicle could easily lead less technical owners/drivers to incorrectly interpret how the car is behaving. The only message you receive while driving could be that 'cruise control is not available', and 'automatic emergency braking unavailable' with a message that the features may be restored later in the drive. My coworker has a 2022 Model Y and the same component failed on his vehicle and needed to be replaced under an extended warranty that was purchased from Tesla. I'm unsure how widespread the failure of this critical safety system is; we both purchased FSD and both had the same component fail and need replaced. I don't personally know others who own this vehicle with the FSD package to know for sure.
NHTSA ODI #11633239
Mileage unknown · Oct 16, 2024
Forward Collision AvoidanceSteeringVehicle Speed Control
I own a 2020 Tesla Y with Hardware version 3 and after a few weeks of a free trial, purchased Tesla's Full Self-Driving Software (FSD) version 12.3.6. Since then, the FSD software was updated to version 12.5.4 and then 12.5.4.1. FSD version 12.3.6 had some safety issues. But version 12.5.4 and 12.5.4.1 has had more issues that …
Read full complaint
I own a 2020 Tesla Y with Hardware version 3 and after a few weeks of a free trial, purchased Tesla's Full Self-Driving Software (FSD) version 12.3.6. Since then, the FSD software was updated to version 12.5.4 and then 12.5.4.1. FSD version 12.3.6 had some safety issues. But version 12.5.4 and 12.5.4.1 has had more issues that have resulted in nearly having accidents that I have had to suddenly avoid. FSD version 12.3.6 issues: 1. Wandering outside of center yellow dividing stripes when on a curvy two-lane roadway 2. Failing to yield to oncoming traffic when making a left turn and oncoming traffic was not clearly in view due to a curvy two-lane road 3. Attempting to make a left turn into a busy intersection when the turn signal was still red FSD version 12.5.4 and 12.5.4.1 additional issues: 1. Attempting to enter a two-lane roadway from a stop sign, when the perpendicular traffic was active and they had no stop sign, requiring me to slam on the brakes. 2. Sudden and erratic braking on a two-lane roadway, including directly under a signal, when no objects, people or other vehicles were in front of me, which nearly resulted in the vehicle behind me hitting me in the rear 3. Software sending a tone and screen alert to grab the steering wheel immediately, due to a "System Failure." 4. Software sending a tone and screen alert that to grab the steering wheel immediately, due to "one or more cameras blocked," when no cameras were blocked.
NHTSA ODI #11620036
68,000 miles · Aug 27, 2024
Air BagsVehicle Speed ControlCrash
The contact owned a 2020 Tesla Model Y. The contact stated that while driving at 60 MPH in rainy weather, the vehicle inadvertently spun in circles, and he lost control of the vehicle. The contact took his foot off the accelerator pedal. No warning light was illuminated. The vehicle crashed into an embankment and then spun twice…
Read full complaint
The contact owned a 2020 Tesla Model Y. The contact stated that while driving at 60 MPH in rainy weather, the vehicle inadvertently spun in circles, and he lost control of the vehicle. The contact took his foot off the accelerator pedal. No warning light was illuminated. The vehicle crashed into an embankment and then spun twice before inadvertently driving into the forest and coming to a complete stop. The air bags did not deploy. A police report was filed. The contact and his father, who was a passenger, were uninjured. There was no medical attention received. The vehicle was first towed to the tow yard, and then the insurance company had it towed to the salvage yard, where it was deemed totaled. The manufacturer was made aware of the failure and advised the contact to contact the local dealer for the computer data. The failure mileage was approximately 68,000.
NHTSA ODI #11611115
14,000 miles · Feb 5, 2024
Vehicle Speed ControlCrashInjury
The contact owned a 2020 Tesla Model Y. The contact stated that while reversing at low speed from his driveway, the accelerator pedal inadvertently depressed into the floorboard, resulting in sudden unintended acceleration. The contact depressed the brake pedal, but the vehicle failed to stop immediately. The vehicle struck two …
Read full complaint
The contact owned a 2020 Tesla Model Y. The contact stated that while reversing at low speed from his driveway, the accelerator pedal inadvertently depressed into the floorboard, resulting in sudden unintended acceleration. The contact depressed the brake pedal, but the vehicle failed to stop immediately. The vehicle struck two other parked vehicles in another driveway before crashing into a residence. The residents were not injured. The contact sustained a fractured neck, and shoulder pain from his seat belt, and head pain from striking the steering wheel. The contact's front passenger sustained a bruised shoulder, and the rear passenger, who was laying down on the rear seats, rolled over during impact and hit the rear seats, sustaining back and leg pain. The contact and his passengers were transported by ambulance to the hospital. A police report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was made aware of the failure and informed the contact that after reviewing the event data recorder (EDR), the data showed that the contact had his foot depressed on the accelerator pedal during the failure. The failure mileage was approximately 14,000.
NHTSA ODI #11570095
Mileage unknown · Aug 30, 2023
Forward Collision AvoidanceService BrakesVehicle Speed Control
While driving in cruise control mode, not auto steer, and with no vehicle in or obvious obstruction in front, the brakes will be applied without warning (phantom braking). It has happened multiple time in the years of ownership. It has happened once or twice with a vehicle following resulting in near rear-end collision. In on…
Read full complaint
While driving in cruise control mode, not auto steer, and with no vehicle in or obvious obstruction in front, the brakes will be applied without warning (phantom braking). It has happened multiple time in the years of ownership. It has happened once or twice with a vehicle following resulting in near rear-end collision. In one case this resulted in the follower reacting with "road rage," passing with horns blaring and braking in front of my vehicle. I have this recent incident on video as it just requires me to honk the horn and the last 5-10 minutes of driving is recorded.
NHTSA ODI #11541770
23,000 miles · Aug 3, 2023
Vehicle Speed ControlCrash
The contact owns a 2020 Tesla Model Y. The contact was driving approximately 3 MPH as she was parking the vehicle, front end first, the vehicle independently accelerated as she removed her foot from the accelerator. The contact stated no warning light was illuminated. The contact's vehicle crashed into the vehicle's front end th…
Read full complaint
The contact owns a 2020 Tesla Model Y. The contact was driving approximately 3 MPH as she was parking the vehicle, front end first, the vehicle independently accelerated as she removed her foot from the accelerator. The contact stated no warning light was illuminated. The contact's vehicle crashed into the vehicle's front end that had already been parked, the vehicle was not occupied. The contact stated that she depressed the brake with force. The contact stated that the force of the crash had moved the other vehicle out of the parking spot and into the lot. The contact's vehicle had a crushed front bumper and the other vehicle also had damage to the front bumper. The contact's vehicle was drivable. There were no injuries and the police were not involved. The contact had not been taken to a local dealer or independent mechanic. The vehicle had not been diagnosed and had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 23,000.
NHTSA ODI #11536365
Mileage unknown · Jun 20, 2023
Forward Collision AvoidanceVehicle Speed Control
While driving at highway speeds (50mph-80mph), on 2 lane or 4 lane highways, in the day or night, in sunny conditions and overcast sky's, while using the cruise control (auto-pilot), the car will suddenly and unexpectedly apply the brakes. It happens between 8 and 10 times on every road trip, each way. Not only is it a shock t…
Read full complaint
While driving at highway speeds (50mph-80mph), on 2 lane or 4 lane highways, in the day or night, in sunny conditions and overcast sky's, while using the cruise control (auto-pilot), the car will suddenly and unexpectedly apply the brakes. It happens between 8 and 10 times on every road trip, each way. Not only is it a shock to me as there is never a visual obstacle that seems to be causing the hard braking, but it is a dangerous safety issue to other motorists too. This has caused cars behind me to take evasive maneuvers to avoid a collision. Other motorists have mistaken this hard braking as me "Brake-Checking" them and very nearly cause a road-rage incident. I've had the car for about a year and have opened several service appointments with Tesla. Each time they close the case before the service appointment with a version of the reply "this is normal" and "there is nothing to repair". They also claim that the car will learn how the react next time by my reaction to the incident this time. I have reacted the same way (by pushing the accelerator pedal until it regains forward motion) each time this has happened in the 8-10 times on each of the 6-8 road trips I've made in the last year. Clearly, the car isn't learning anything from my reaction to the sudden and unexpected braking. My safety is worth my time to make them take this seriously as they don't seem to be concerned with my safety!
NHTSA ODI #11527902
Mileage unknown · Jun 20, 2023
Electrical SystemVehicle Speed ControlVisibility/wiperCrash
During phone calls, the system would start making sparking noises and stall the calls. While navigation was input parts of the screen would disappear. While backing up, the rear cameras would freeze and stall. The rear camera freezing had caused us to get into an accident, and caused us to have 4 near misses. When I was tryi…
Read full complaint
During phone calls, the system would start making sparking noises and stall the calls. While navigation was input parts of the screen would disappear. While backing up, the rear cameras would freeze and stall. The rear camera freezing had caused us to get into an accident, and caused us to have 4 near misses. When I was trying to download the latest software release, the software download froze and never downloaded. I started to drive to the Tesla dealership and as I was doing so, the screen picture of my vehicle disappeared along with the gear shift indicator, the surrounding cameras failed. Then when I put on my turn signal, the sound disappeared. Then eventually the indicator disappeared. The entire screen froze with no information, and then went black while I was driving to the Tesla dealership. The system was black and finally did a reboot after 4 minutes, all while I had no display of my speed. I took it into the dealership, and the checkin girl was concerned about the safety and gave me a loaner. The technician was not really concerned and said it was not able to replicate the issue and said there was no safety issue as you can still drive the car. This is not correct as you do not have the speed indication when your screen freezes or goes black. I sent them pictures as the screen kept doing one thing after the other in a matter on one drive from my home to the dealership in 15 minutes. This is similar to the other recalls that Tesla had to make on the model S and the Model X and some model Y's. This should have been taken care of under the current recalls for the infotainment system that the other models years were facing as it is giving the same issues on my model.
NHTSA ODI #11527838
Mileage unknown · May 20, 2023
Vehicle Speed Control
Car accelerated on its own, with no pedal pressure. My right foot was on the mat
NHTSA ODI #11523021
Official recalls
24Aug 4, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
Remedy: The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
May 4, 2026
Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.
Dec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Driving with improperly inflated tires increases the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Jul 24, 2024
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Consequence & remedy
Consequence: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Additional source detail variants (2)
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Consequence: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Latches/locks/linkages:hood:latch
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Consequence: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
May 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Feb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence & remedy
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Additional source detail variants (2)
Forward Collision Avoidance: Warnings:external/pedestrian Alert
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Jan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Dec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequence & remedy
Consequence: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Feb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Consequence & remedy
Consequence: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Nov 15, 2022
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.
Consequence & remedy
Consequence: A taillight that fails to illuminate may reduce the visibility of the vehicle, increasing the risk of a crash.
Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed January 14, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-016.
Sep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Apr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence & remedy
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Additional source detail variants (2)
Forward Collision Avoidance: Warnings:external/pedestrian Alert
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Feb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence & remedy
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Additional source detail variants (2)
Forward Collision Avoidance: Warnings:external/pedestrian Alert
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Feb 2, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Additional source detail variants (2)
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence: Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Visibility:defroster/defogger/hvac System:air Handler/chamber, Ducts, And Valves
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence: Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Feb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Additional source detail variants (2)
Seat Belts:front
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Electrical System:software
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Jan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Consequence & remedy
Consequence: Failing to stop at a stop sign can increase the risk of a crash.
Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Nov 21, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y vehicles. The front and rear suspension knuckles may fracture, causing the suspension links to separate.
Consequence & remedy
Consequence: Suspension links that separate can reduce vehicle stability and control, increasing the risk of a crash.
Remedy: Tesla Service will inspect and replace the knuckles as necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-004.
Oct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence & remedy
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Additional source detail variants (4)
Forward Collision Avoidance: Sensing System: Camera
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Forward Collision Avoidance:software
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Forward Collision Avoidance: Automatic Emergency Braking
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Forward Collision Avoidance: Warnings
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Oct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence & remedy
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Additional source detail variants (2)
Suspension:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Suspension:front
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
May 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Consequence & remedy
Consequence: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Additional source detail variants (2)
Service Brakes, Hydraulic:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Consequence: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Service Brakes, Hydraulic:foundation Components:disc:caliper
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Consequence: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
May 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model Y vehicles. One or both fasteners that secure the left and right second row seat belt retractors may not be properly attached.
Consequence & remedy
Consequence: Improperly attached fasteners may prevent the seat belt retention system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and replace both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-002.
Additional source detail variants (2)
Seat Belts:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model Y vehicles. One or both fasteners that secure the left and right second row seat belt retractors may not be properly attached.
Consequence: Improperly attached fasteners may prevent the seat belt retention system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and replace both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-002.
Seat Belts:rear/other:retractor
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model Y vehicles. One or both fasteners that secure the left and right second row seat belt retractors may not be properly attached.
Consequence: Improperly attached fasteners may prevent the seat belt retention system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and replace both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-002.
May 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence & remedy
Consequence: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Additional source detail variants (2)
Seat Belts:critical Fasteners
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Seat Belts
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Nov 17, 2020
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles. The bolts connecting the front upper control arm and steering knuckle may have not been properly tightened, allowing the upper control arm to detach from the steering knuckle.
Consequence & remedy
Consequence: A detached upper control arm can cause the wheels to lean in or out, decreasing the driver's ability to steer and increasing the risk of a crash.
Remedy: Tesla will notify owners, and dealers will inspect, and as necessary, tighten the bolts, free of charge. The recall began January 15, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-31-012.
Sep 30, 2020
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles equipped with a global rear lamp and tow package configuration. A software error prevents the illumination of trailer brake lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer brake lights that fail to illuminate during braking increase the risk of a crash.
Remedy: Tesla will notify owners, and has released the firmware update over-the-air (OTA) to vehicles as of September 23, 2020. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-00-002.
Additional source detail variants (2)
Exterior Lighting:brake Lights
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles equipped with a global rear lamp and tow package configuration. A software error prevents the illumination of trailer brake lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer brake lights that fail to illuminate during braking increase the risk of a crash.
Remedy: Tesla will notify owners, and has released the firmware update over-the-air (OTA) to vehicles as of September 23, 2020. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-00-002.
Exterior Lighting
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles equipped with a global rear lamp and tow package configuration. A software error prevents the illumination of trailer brake lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer brake lights that fail to illuminate during braking increase the risk of a crash.
Remedy: Tesla will notify owners, and has released the firmware update over-the-air (OTA) to vehicles as of September 23, 2020. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-00-002.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA26002 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Mar 18, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and capabilities of the updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI discussed individual incidents and its initial findings during the PE phase of its investigation with Tesla. As part of those discussions, Tesla’s post-incident analysis indicated that the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s degradation detection system, both as originally deployed and later updated, fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants. In the crashes that ODI has reviewed, the system did not detect common roadway conditions that impaired camera visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. In upgrading PE24031 to an Engineering Analysis (EA), ODI will gather further information on the updated degradation detection system, including the status of updating vehicles and scope of compatible vehicles, the system’s visibility degradation detection capability, and alerts or warnings to the driver. Lastly, ODI will conduct analysis on six recent potentially related incidents. These incidents can be found at NHTSA.gov under the following SGO report identification numbers: 13781-11937, 13781-13211, 13781-13569, 13781-13633, 13781-13693, 13781-13788. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
PE25012 · Traffic Safety Violations While Full Self Driving ("fsd") Is Engaged
Opened Oct 7, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects of the driving task, requiring a driver to supervise and intervene as necessary. The driver remains fully responsible at all times for driving the vehicle, including complying with applicable traffic laws. ODI’s investigation will therefore focus, in particular, on whether certain driving inputs within the control authority of FSD forestall the driver’s supervision when they are unexpectedly performed. ODI has identified a number of incidents in which the inputs to the dynamic driving task commanded by FSD induced vehicle behavior that violated traffic safety laws. Although reports of this nature span a variety of behaviors, the reports appear to most commonly involve two types of scenarios. The first type of scenario involves a vehicle operating with FSD proceeding into an intersection in violation of a red traffic signal. The second type of scenario involves FSD commanding a lane change into an opposing lane of traffic. With respect to the first type of scenario, ODI has identified 18 complaints and 1 media report alleging that a Tesla vehicle, operating at an intersection with FSD engaged, failed to remain stopped for the duration of a red traffic signal, failed to stop fully, or failed to accurately detect and display the correct traffic signal state in the vehicle interface. Some complainants also alleged that FSD did not provide warnings of the system's intended behavior as the vehicle was approaching a red traffic signal. ODI has identified six Standing General Order ("SGO") reports in which a Tesla vehicle, operating with FSD engaged, approached an intersection with a red traffic signal, continued to travel into the intersection against the red light and was subsequently involved in a crash with other motor vehicles in the intersection. Of these incidents, four crashes resulted in one or more reported injuries. At least some of the incidents appeared to involve FSD proceeding into the intersection after coming to a complete stop. ODI's pre-investigative work, including coordination with the Maryland Transportation Authority and State Police, indicated that the problem may be repeatable, given that multiple subject incidents occurred at the same intersection in Joppa, Maryland. NHTSA understands that Tesla has since taken action to address the issue at this intersection. With respect to the second type of scenario, ODI has identified 2 SGO reports, 18 complaints, and 2 media reports alleging that a Tesla vehicle, operating with FSD engaged, entered opposing lanes of travel during or following a turn, crossed double-yellow lane markings while proceeding straight, or attempted to turn onto a road in the wrong direction despite the presence of wrong-way road signs. Likewise, ODI has identified 4 SGO reports, 6 complaints, and 1 media report alleging that a Tesla vehicle, operating with FSD engaged, proceeded straight through an intersection in a turn-only lane or executed a turn at an intersection in a through lane despite the presence of lane markings or signals. Complaints also alleged that FSD did not provide warnings of the system's intended behavior. Some complaints alleged that more than one of these failures occurred and, as such, the numbers are not cumulative. Some of the reported incidents appeared to involve FSD executing a lane change into an opposing lane of travel with little notice to a driver or opportunity to intervene. ODI’s review will assess whether there was prior warning or adequate time for the driver to respond to the unexpected behavior or to safely supervise the automated driving task. This review will assess any warnings to the driver about the system's impending behavior; the time given to drivers to respond; the capability of FSD to detect, display to the driver, and respond appropriately to traffic signals; and the capability of FSD to detect and respond to lane markings and wrong-way signage. NHTSA's review will also consider any updates or modifications to the system(s) that may affect the performance of FSD with respect to obeying traffic safety laws and signals. This assessment will focus, in particular, on the types of traffic safety violations described above, as most reports identified thus far have centered around those behaviors. While the behaviors under investigation appear to occur most frequently at intersections, NHTSA’s investigation will encompass any other types of situations in which this behavior may arise, such as when traveling adjacent to a lane of opposing traffic or when approaching railroad crossings. If other evidence received during this investigation involve other types of traffic safety violations, those may be considered as part of this assessment as well. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov. The SGO reports cited in this Resume are listed below by report ID and are available for download at NHTSA.gov/laws-regulations/standing-general-order-crash-reporting. 13781-8739-1, 13781-8995-1, 13781-9623-1, 13781-10333-1, 13781-10872-1, 13781-10930-1, 13781-10939-1, 13781-10941-1, 13781-11069-1, 13781-11305-1, 13781-11579-1 Media reported allegations included as a separate attachment.
AQ25002 · Compliance With Standing General Order 2021-01 Reporting Requirements
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas
The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a single batch, while others were submitted on a rolling basis. Preliminary engagement between ODI and Tesla on the issue indicates that the timing of the reports was due to an issue with Tesla’s data collection, which, according to Tesla, has now been fixed. NHTSA is opening this Audit Query, a standard process for reviewing compliance with legal requirements, to evaluate the cause of the potential delays in reporting, the scope of any such delays, and the mitigations that Tesla has developed to address them. As part of this review, NHTSA will assess whether any reports of prior incidents remain outstanding and whether the reports that were submitted include all of the required and available data. The SGO reports cited in the Opening Resume, can be found at NHTSA.gov/SGOCrashReporting under the following SGO 2021-01 report IDs: 13781-11020-1 13781-10844-1 13781-10843-1 13781-10530-1 13781-10160-1 13781-10159-1 13781-10157-1 13781-10146-1 13781-10122-1 13781-10098-1 13781-10097-1 13781-10096-1 13781-10095-1 13781-10094-1 13781-10093-1 13781-10023-1 13781-10022-1 13781-10021-1 13781-10020-1 13781-10017-1 13781-10016-1 13781-10015-1 13781-10014-1 13781-10013-1 13781-10012-1 13781-6047-1 13781-9930-1 13781-9917-1 13781-9928-1 13781-9925-1 13781-9924-1 13781-9923-1 13781-9922-1 13781-9835-1 13781-9834-1 13781-9833-1 13781-9832-1 13781-9831-1 13781-9830-1 13781-9829-1 13781-9827-1 13781-9818-1 13781-9780-1 13781-9779-1 13781-9778-1 13781-9777-1 13781-9775-1 13781-9774-1 13781-9773-1 13781-9772-1 13781-9771-1 13781-9770-1 13781-9728-1 13781-9688-1 13781-9715-1 13781-9714-1 13781-9713-1 13781-9712-1 13781-9711-1 13781-9710-1 13781-9709-1 13781-9696-1 13781-9695-1 13781-9694-1 13781-9693-1 13781-9692-1 13781-9691-1 13781-9690-1 13781-9687-1 13781-9686-1 13781-9342-1 13781-9319-1 13781-9019-1 13781-8910-1 13781-8732-1 13781-8712-1 13781-8310-1 13781-7897-1 13781-7895-1 13781-7835-1 13781-7798-1 13781-7797-1 13781-7758-1 13781-7757-1 13781-7756-1 13781-7755-1 13781-7667-1 13781-7399-1 13781-7398-1 13781-7397-1 13781-7396-1 13781-7395-1 13781-7394-1 13781-7393-1 13781-7389-1 13781-7388-1 13781-7387-1 13781-7386-1 13781-7385-1 13781-7383-1 13781-7187-1 13781-7186-1 13781-7185-1 13781-7184-1 13781-7181-1 13781-7023-1 13781-6399-1 13781-6389-1 13781-6388-1 13781-6387-1 13781-6386-1 13781-6379-1 13781-6378-1 13781-6377-1 13781-6375-1 13781-6214-1 13781-6172-1 13781-6155-1 13781-6154-1 13781-6122-1 13781-6120-1 13781-6118-1 13781-5800-1
PE24033 · Actually Smart Summon Sessions Resulting In low-speed Impacts.
Opened Jan 6, 2025 · Closed Apr 3, 2026
Status: closed (inferred from source dates) · Electrical System:adas:autonomous/self Driving
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Summon reported crashes involved minor property damage claims with no reported incidents involving a vulnerable road user, injury, fatality, or major property damage as indicated by an air bag deployment or vehicle tow away. Out of millions of Summon sessions, a fraction of 1% resulted in an incident. Almost all those incidents took place where, typically early in a Summon session, the system or person using the app failed to fully detect or respond appropriately to vehicle surroundings resulting in minor impacts. Incidents took place when app users did not have a complete 360-degree view of the surroundings in the app to assess situational awareness. This limited the app user’s ability to determine whether an impact was imminent during initial vehicle maneuvers such as reversing in close proximity to an obstacle or a curb. ODI found that the impacts most often occurred with parking gates, adjacently parked vehicles, and short parking bollards. During this investigation, ODI identified two Summon crashes related to camera blockages. In both crashes, Summon attempted to navigate a snowy parking lot with snow partially or fully obstructing the forward-facing cameras. Summon did not detect the camera blockage and the vehicles collided with unoccupied parked vehicles while navigating the parking lot. App users in both instances did not command a vehicle stop or pause despite the obstructed camera visible in the camera stream in the app. On January 15, 2025, Tesla released Over-the-Air (OTA) Software (SW) Update Action numbers 578998 and 579185 for vehicles in service to implement a camera blockage detection condition. Both OTAs improve camera blockage detection mechanisms. Additionally, on January 20, 2025, and January 30, 2025, Tesla identified additional system requirements associated with camera visibility checks and released OTA SW-578752 and SW-580322, respectively. These firmware updates reduce false negative camera blockage detections due to snow or condensation. In its investigation, ODI identified one Summon incident where the vehicle did not yield for a gate arm blocking a garage exit lane and the app user did not command a vehicle stop or pause, resulting in an impact. On February 6, 2025, Tesla deployed OTA SW-578839 to improve vehicle reaction to dynamic gates. This OTA update upgraded vehicle perception systems through a high-fidelity occupancy determination network, which uses data from vehicle sensory systems to improve reconstruction of field objects with high accuracy. On November 20, 2025, Tesla further improved vehicle performance by adding object detections from a separate neural network through OTA SW-580514. Owners of the affected vehicles received all six OTA SW updates. Tesla also released these SW updates to production vehicles. See online public file for detailed descriptions of all six OTA SW updates. Due to low incident occurrence and low incident severity, this preliminary evaluation is closed. The closing of this investigation does not constitute a finding that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by future circumstances. For additional information regarding this investigation, see the complete online public file.
PE24031 · Fsd Collisions In Reduced Roadway Visibility Conditions
Opened Oct 17, 2024 · Closed Mar 18, 2026
Status: closed (inferred from source dates) · Electrical System:adas
On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or modifications by Tesla to the FSD system that may affect the performance of FSD in degraded roadway visibility conditions, including the timing, purpose, and capabilities of any such updates, and Tesla’s assessment of their safety impact. Tesla’s FSD is an advanced driver assistance system (ADAS) that relies exclusively on vision-based cameras and the related FSD software to detect and respond to the roadway ahead, projecting a path forward based on traffic control devices, vehicles, pedestrians, and the roadway itself. During this phase of the investigation, ODI reviewed the materials provided by Tesla detailing any actions taken, or changes, modifications, and updates made that may relate to the alleged defect. ODI reviewed information related to Tesla’s transition to a vision-only perception system, and its deployment of the strategy in vehicles. ODI’s findings include information on limitations of the vision-only perception system and updates made in response to known subject crashes. When Tesla began transitioning away from using both cameras and radars to an exclusively camera-based approach, known as Tesla Vision, in mid-2021, it developed and implemented a degradation detection system that it deployed by a software update to existing and new Tesla vehicles. On June 28, 2024, the day after Tesla submitted the SGO report of the November 28, 2023 fatal crash listed in this document, Tesla began developing an update to the degradation detection system. ODI reviewed certain public statements, including those made during an April 2025 earnings call, in which Tesla stated that it had developed a breakthrough “direct photon-counting” capability that eliminates the degradation that the camera-based system experiences when glare is encountered. At this time, ODI does not have information on when the update was deployed and which vehicles have the updated system. ODI has discussed individual incidents and its initial findings with Tesla. Based on Tesla’s post-incident analysis, the update to the degradation detection system, had it been installed on the vehicles at the time, may have affected 3 of the 9 incidents identified by ODI. Review of Tesla’s responses revealed additional crashes that occurred in similar environments and where the system either did not detect a degraded state, and/or it did not present the driver with an alert with adequate time for the driver to react. In each of these crashes, FSD also lost track of or never detected a lead vehicle in its path. Tesla also described internal data and labeling limitations that prevented a uniform identification and analysis of crash events with the subject system engaged. ODI believes this limitation could have led to under-reporting of subject crashes over portions of the defined time-period. Available incident data raise concerns that Tesla’s FSD system fails to detect and/or warn the driver appropriately under degraded visibility conditions such as glare and airborne obscurants where the camera-based system performance degrades significantly. In the crashes that ODI has reviewed, the FSD system did not detect common roadway conditions that impaired its visibility and/or provide alerts when camera performance had deteriorated until immediately before the crash occurred. ODI is upgrading this investigation (PE24031) to Engineering Analysis (EA) 26002 to further evaluate this matter. The crashes included in the failure report summary can be found at NHTSA.gov under the following SGO report identification numbers: 13781-8004, 13781-7181, 13781-7381, 13781-7767, 13781-7964, 13781-8977, 13781-9267.
RQ24009 · Recall 23V838 Remedy Effectiveness
Opened Apr 25, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:adas:driver Monitoring:software
The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the system’s controls may be insufficient to prevent driver misuse,” and Tesla committed to the deployment of a multipart remedy aimed at improving system and engagement controls and reducing mode confusion. EA22002 (upgraded from PE21020) was opened to investigate whether Tesla’s Autopilot contained a defect that created an unreasonable risk to motor vehicle safety and involved extensive crash analysis, human factors analysis, vehicle evaluations, and assessment of vehicle control authority and driver engagement technologies. The work conducted in these investigations aligns with Tesla’s conclusion in its 23V838 recall filing. During EA22002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries in which foreseeable driver misuse of the system played an apparent role. Tesla filed Recall 23V838 to address concerns regarding the Autopilot system investigated in EA22002. Following deployment of the remedy in Recall 23V838, ODI identified concerns due to post-remedy crash events and results from preliminary NHTSA tests of remedied vehicles. Also, Tesla has stated that a portion of the remedy both requires the owner to opt in and allows a driver to readily reverse it. Tesla has also deployed non-remedy updates to address issues that appear related to ODI’s concerns under EA22002. This investigation will consider why these updates were not a part of the recall or otherwise determined to remedy a defect that poses an unreasonable safety risk. ODI is therefore opening this Recall Query investigation to further evaluate the adequacy of the remedy for recall 23V838.
DP23002 · Sudden Unintended Acceleration
Opened Jun 29, 2023 · No close date supplied
Status: open (inferred from source dates) · Vehicle Speed Control
The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA.gov under the following ODI number: 11528471.
DP23001 · Defect Petition Interlock Request
Opened Apr 7, 2023 · Closed Mar 18, 2026
Status: closed (inferred from source dates) · Unknown Or Other
On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal combustion engine powered vehicles promote driver pedal misapplication, leading to sudden unintended acceleration (SUA) incidents. To fix this alleged defect, Petitioner argues that the subject vehicles should be equipped with measures that require: (i) occasional removal of the driver’s foot from the pedals; and (ii) application of the brake pedal before fully stopping the vehicle. ODI evaluated the allegations by, among other things, reviewing the Petition and supporting technical paper, and analyzing Tesla’s response to ODI’s Information Request. ODI is denying this Petition. ODI has not found evidence that warrants the opening of a safety defect investigation into the Tesla vehicles as described in the Petition. The use of regenerative braking controlled by the accelerator pedal, or one-pedal driving, is common across most light vehicle manufacturers of electric vehicles and Tesla vehicles are not unique in this respect. Further, ODI identified only a handful of collisions potentially within the scope of the alleged defect; and corresponding vehicle data demonstrated that the subject vehicles responded appropriately to control inputs by their drivers. Moreover, ODI is unaware of any evidence to suggest that Petitioner’s proposed interlock would have prevented alleged SUA events as apparently described in the Petition and supporting materials. Accordingly, the Agency is denying the petition. As with all potential motor vehicle safety risks, NHTSA will continue to review any new information or incidents as they are submitted to the Agency.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
EA22002 · Autopilot System Driver Controls
Opened Jun 8, 2022 · Closed Apr 25, 2024
Status: closed (inferred from source dates) · Electrical System
The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation via analysis of peer vehicle data and hands-on vehicle evaluation, assessments from NHTSA human factors subject matter experts, and reviews of related publications dedicated to partial driving automation. Autopilot is the simultaneous use of the features that Tesla calls Traffic-Aware Cruise Control (TACC) and Autosteer. TACC is a type of adaptive cruise control that, like traditional cruise control, maintains a set speed but also slows or accelerates as necessary to maintain the vehicle’s following distance from a vehicle in front. As designed, Autosteer detects lane markings and the presence of other nearby vehicles and objects to keep the vehicle in its driving lane. Autopilot is characterized by Tesla as an SAE Level 2 (“L2 system”) partial driving automation system that provides driver assistance through steering, propulsion, and braking within a specified driving environment under direct supervision of the driver. L2 systems should be designed to support the driver’s need to monitor the system in response to the constantly changing driving environment and, if necessary, take over the dynamic driving task. To ensure sufficient driver engagement, vehicles with L2 systems should employ driver engagement systems and usage controls that are appropriate and sufficient for the L2 system design and driver expectations. ODI completed an analysis of 956 crashes reported up to August 30, 2023. In approximately half (489) of those crashes, ODI found: 1.) that there was insufficient data to make an assessment; 2.) the other vehicle was at fault; 3.) Autopilot was found to not be in use; or 4.) the crash was otherwise unrelated to EA22002. Of the remaining 467 crashes, ODI identified trends resulting in three categories: collisions in which the frontal plane of the Tesla struck another vehicle or obstacle with adequate time for an attentive driver to respond to avoid or mitigate the crash (211), roadway departures where Autosteerwas inadvertently disengaged by the driver’s inputs (111), and roadway departures in low traction conditions such as wet roadways (145). ODI observed this pattern across all Tesla models and hardware versions. Crash and human factors assessment showed that Autopilot controls did not sufficiently ensure driver attention and appropriate use. At the same time, peer analysis and vehicle evaluations established that Autopilot invited greater driver confidence via its higher control authority and ease of engagement. This mismatch of weak usage controls and high control authority was evident in these crash categories, which included indications of driver disengagement from the driving task. This mismatch was also evident in roadway departures when the system was engaged in low traction conditions outside of Tesla’s recommendations.Additional information regarding NHTSA’s crash analysis is available in the EA22002 file. ODI reviewed these findings with Tesla during several conversations in Quarter 4 of 2023. On December 12, 2023, Tesla filed a Defect Information Report (DIR) (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system. Tesla’s DIR described the functionality of this system, stated that the prominence and scope of the system’s controls may be insufficient to prevent driver misuse, and described a remedy to improve the effectiveness of driver warnings and to reduce mode confusion. ODI completed an extensive body of work via PE21020 and EA22002, which showed evidence that Tesla’s weak driver engagement system was not appropriate for Autopilot’s permissive operating capabilities. This mismatch resulted in a critical safety gap between drivers’ expectations of the L2 system’s operating capabilities and the system’s true capabilities. This gap led to foreseeable misuse and avoidable crashes. During EA220002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries, in which foreseeable driver misuse of the system played an apparent role. ODI’s analysis conducted during this investigation, which aligns with Tesla’s conclusion in its Defect Information Report, indicated that in certain circumstances, Autopilot’s system controls and warnings were insufficient for a driver assistance system that requires constant supervision by a human driver. Given Tesla’s recall (23V838) of all vehicles equipped with Autopilot for insufficient controls to prevent misuse, ODI is closing EA22002. Concurrent with that closing, ODI has opened a Recall Query (RQ24009) to assess the effectiveness of the 23V838 remedy. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation via analysis of peer vehicle data and hands-on vehicle evaluation, assessments from NHTSA human factors subject matter experts, and reviews of related publications dedicated to partial driving automation. Autopilot is the simultaneous use of the features that Tesla calls Traffic-Aware Cruise Control (TACC) and Autosteer. TACC is a type of adaptive cruise control that, like traditional cruise control, maintains a set speed but also slows or accelerates as necessary to maintain the vehicle’s following distance from a vehicle in front. As designed, Autosteer detects lane markings and the presence of other nearby vehicles and objects to keep the vehicle in its driving lane. Autopilot is characterized by Tesla as an SAE Level 2 (“L2 system”) partial driving automation system that provides driver assistance through steering, propulsion, and braking within a specified driving environment under direct supervision of the driver. L2 systems should be designed to support the driver’s need to monitor the system in response to the constantly changing driving environment and, if necessary, take over the dynamic driving task. To ensure sufficient driver engagement, vehicles with L2 systems should employ driver engagement systems and usage controls that are appropriate and sufficient for the L2 system design and driver expectations. ODI completed an analysis of 956 crashes reported up to August 30, 2023. In approximately half (489) of those crashes, ODI found: 1.) that there was insufficient data to make an assessment; 2.) the other vehicle was at fault; 3.) Autopilot was found to not be in use; or 4.) the crash was otherwise unrelated to EA22002. Of the remaining 467 crashes, ODI identified trends resulting in three categories: collisions in which the frontal plane of the Tesla struck another vehicle or obstacle with adequate time for an attentive driver to respond to avoid or mitigate the crash (211), roadway departures where Autosteerwas inadvertently disengaged by the driver’s inputs (111), and roadway departures in low traction conditions such as wet roadways (145). ODI observed this pattern across all Tesla models and hardware versions. Crash and human factors assessment showed that Autopilot controls did not sufficiently ensure driver attention and appropriate use. At the same time, peer analysis and vehicle evaluations established that Autopilot invited greater driver confidence via its higher control authority and ease of engagement. This mismatch of weak usage controls and high control authority was evident in these crash categories, which included indications of driver disengagement from the driving task. This mismatch was also evident in roadway departures when the system was engaged in low traction conditions outside of Tesla’s recommendations.Additional information regarding NHTSA’s crash analysis is available in the EA22002 file. ODI reviewed these findings with Tesla during several conversations in Quarter 4 of 2023. On December 12, 2023, Tesla filed a Defect Information Report (DIR) (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system. Tesla’s DIR described the functionality of this system, stated that the prominence and scope of the system’s controls may be insufficient to prevent driver misuse, and described a remedy to improve the effectiveness of driver warnings and to reduce mode confusion. ODI completed an extensive body of work via PE21020 and EA22002, which showed evidence that Tesla’s weak driver engagement system was not appropriate for Autopilot’s permissive operating capabilities. This mismatch resulted in a critical safety gap between drivers’ expectations of the L2 system’s operating capabilities and the system’s true capabilities. This gap led to foreseeable misuse and avoidable crashes. During EA220002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries, in which foreseeable driver misuse of the system played an apparent role. ODI’s analysis conducted during this investigation, which aligns with Tesla’s conclusion in its Defect Information Report, indicated that in certain circumstances, Autopilot’s system controls and warnings were insufficient for a driver assistance system that requires constant supervision by a human driver. Given Tesla’s recall (23V838) of all vehicles equipped with Autopilot for insufficient controls to prevent misuse, ODI is closing EA22002. Concurrent with that closing, ODI has opened a Recall Query (RQ24009) to assess the effectiveness of the 23V838 remedy. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System
The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation via analysis of peer vehicle data and hands-on vehicle evaluation, assessments from NHTSA human factors subject matter experts, and reviews of related publications dedicated to partial driving automation. Autopilot is the simultaneous use of the features that Tesla calls Traffic-Aware Cruise Control (TACC) and Autosteer. TACC is a type of adaptive cruise control that, like traditional cruise control, maintains a set speed but also slows or accelerates as necessary to maintain the vehicle’s following distance from a vehicle in front. As designed, Autosteer detects lane markings and the presence of other nearby vehicles and objects to keep the vehicle in its driving lane. Autopilot is characterized by Tesla as an SAE Level 2 (“L2 system”) partial driving automation system that provides driver assistance through steering, propulsion, and braking within a specified driving environment under direct supervision of the driver. L2 systems should be designed to support the driver’s need to monitor the system in response to the constantly changing driving environment and, if necessary, take over the dynamic driving task. To ensure sufficient driver engagement, vehicles with L2 systems should employ driver engagement systems and usage controls that are appropriate and sufficient for the L2 system design and driver expectations. ODI completed an analysis of 956 crashes reported up to August 30, 2023. In approximately half (489) of those crashes, ODI found: 1.) that there was insufficient data to make an assessment; 2.) the other vehicle was at fault; 3.) Autopilot was found to not be in use; or 4.) the crash was otherwise unrelated to EA22002. Of the remaining 467 crashes, ODI identified trends resulting in three categories: collisions in which the frontal plane of the Tesla struck another vehicle or obstacle with adequate time for an attentive driver to respond to avoid or mitigate the crash (211), roadway departures where Autosteerwas inadvertently disengaged by the driver’s inputs (111), and roadway departures in low traction conditions such as wet roadways (145). ODI observed this pattern across all Tesla models and hardware versions. Crash and human factors assessment showed that Autopilot controls did not sufficiently ensure driver attention and appropriate use. At the same time, peer analysis and vehicle evaluations established that Autopilot invited greater driver confidence via its higher control authority and ease of engagement. This mismatch of weak usage controls and high control authority was evident in these crash categories, which included indications of driver disengagement from the driving task. This mismatch was also evident in roadway departures when the system was engaged in low traction conditions outside of Tesla’s recommendations.Additional information regarding NHTSA’s crash analysis is available in the EA22002 file. ODI reviewed these findings with Tesla during several conversations in Quarter 4 of 2023. On December 12, 2023, Tesla filed a Defect Information Report (DIR) (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system. Tesla’s DIR described the functionality of this system, stated that the prominence and scope of the system’s controls may be insufficient to prevent driver misuse, and described a remedy to improve the effectiveness of driver warnings and to reduce mode confusion. ODI completed an extensive body of work via PE21020 and EA22002, which showed evidence that Tesla’s weak driver engagement system was not appropriate for Autopilot’s permissive operating capabilities. This mismatch resulted in a critical safety gap between drivers’ expectations of the L2 system’s operating capabilities and the system’s true capabilities. This gap led to foreseeable misuse and avoidable crashes. During EA220002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries, in which foreseeable driver misuse of the system played an apparent role. ODI’s analysis conducted during this investigation, which aligns with Tesla’s conclusion in its Defect Information Report, indicated that in certain circumstances, Autopilot’s system controls and warnings were insufficient for a driver assistance system that requires constant supervision by a human driver. Given Tesla’s recall (23V838) of all vehicles equipped with Autopilot for insufficient controls to prevent misuse, ODI is closing EA22002. Concurrent with that closing, ODI has opened a Recall Query (RQ24009) to assess the effectiveness of the 23V838 remedy. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE21023 · Tesla Passenger Play
Opened Dec 21, 2021 · Closed May 26, 2023
Status: closed (inferred from source dates) · Equipment:recreational VEHICLE/TRAILER:120/240 Vac Electrical System:receptacle
The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE21-023) on December 21, 2021, to evaluate the driver distraction potential and use frequency / circumstances of in-vehicle game-play functionality referred to as ?Passenger Play? in certain model year (MY) 2017-2022 Tesla Model 3, S, X, and Y vehicles. Distracted driving can result in an increased risk of a crash. PE21-023 was prompted by the receipt of Vehicle Owners Questionnaire (VOQ) 11439598 from the owner of a 2021 Model 3 on November 6, 2021. ODI sent an Information Request (IR) letter to Tesla on January 20, 2022 and received Tesla?s response on March 4, 2022.On December 24, 2020, Tesla introduced Passenger Play to vehicles equipped with the Intel Atom processor (receiving an aftersale software update) via its 2020 holiday release. Passenger Play permitted occupants to play specific games selected by Tesla for primarily turn-based play style and limited gameplay motion with the transmission in Drive and the vehicle in motion. Under these conditions, a notification would display on the screen and the screen area devoted to the game would reduce from 100% to accommodate vehicle controls and driving task data readout. Specific changes varied among models. On December 21, 2022, Tesla voluntarily disabled Passenger Play capability with Firmware Release 2021.44.25.1 in response to NHTSA?s request. Tesla reported a month later that a 97% completion rate was achieved though Tesla?s Over the Air (OTA) update. ODI opened PE 21-023 to evaluate the driver distraction potential of Tesla Passenger Play while the vehicle is being driven including aspects of the feature, frequency, and use scenarios.Based on the analysis conducted, PE21-023 has been closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. Furthermore, it does not foreclose the Agency from taking further action, if warranted, or the potential for a future finding that a safety-related defect exists through additional information the Agency may receive.See attached Closing Report for a detailed summary of the investigation findings.
PE21020 · Autopilot & First Responder Scenes
Opened Aug 13, 2021 · Closed Jun 8, 2022
Status: closed (inferred from source dates) · Electrical System:adas
On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the driving task) available in Tesla vehicles. The investigation opening was motivated by an accumulation of crashes in which Tesla vehicles, operating with Autopilot engaged, struck stationary in-road or roadside first responder vehicles tending to pre-existing collision scenes. Upon opening the investigation, NHTSA indicated that the PE would also evaluate additional similar circumstance crashes of Tesla vehicles operating with Autopilot engaged, as well as assess the technologies and methods used to monitor, assist, and enforce the driver?s engagement with the dynamic driving task during Autopilot operation.PE21-020 is upgraded to an Engineering Analysis (EA) to extend the existing crash analysis, evaluate additional data sets, perform vehicle evaluations, and to explore the degree to which Autopilot and associated Tesla systems may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver?s supervision. In doing so, NHTSA plans to continue its assessment of vehicle control authority, driver engagement technologies, and related human factors considerations.The attached Detailed Summary further describes NHTSA?s review to date and the basis for upgrade to an EA.
Illustration