SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Suzuki VL1500

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
6Owner complaints

Model-year median: 2

1Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
3
20011
20021
20036
200413
20050
20069
2007
Compare all VL1500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Fuel System, Gasoline
3Engine
1Structure
1Vehicle Speed Control
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 3 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Vehicle Speed Control complaints

1 reports
Clear category filter
1 miles · Dec 2, 2005
Vehicle Speed Control

DT: THE CONTACT STATES WHEN THE HAND ACCELERATOR WAS DISENGAGED THE HANDLE BAR MOVED FROM LEFT TO RIGHT. THE MOTORCYCLE WAS SEEN BY THE DEALER THREE TIMES. THE FRONT TIRE WERE BALANCED AGAIN, AND THE TORQUE ON THE STEERING WAS READJUSTED. HOWEVER, THE PROBLEM RECURRED, AND NO FURTHER CORRECTIONS HAVE BEEN MADE. *AK ADDITION…

Read full complaint

DT: THE CONTACT STATES WHEN THE HAND ACCELERATOR WAS DISENGAGED THE HANDLE BAR MOVED FROM LEFT TO RIGHT. THE MOTORCYCLE WAS SEEN BY THE DEALER THREE TIMES. THE FRONT TIRE WERE BALANCED AGAIN, AND THE TORQUE ON THE STEERING WAS READJUSTED. HOWEVER, THE PROBLEM RECURRED, AND NO FURTHER CORRECTIONS HAVE BEEN MADE. *AK ADDITIONALLY, THE CONTACT FEELS THE RECOMMENDED TIRE PRESSURE IS INCORRECT IN THE OWNER'S MANUAL. THE OWNER'S MANUAL RECOMMENDS A TIRE PRESSURE OF 29 PSI FOR THE FRONT AND 36 PSI FOR THE REAR. THE MANUFACTURER OF THE TIRE RECOMMENDS 37 PSI FOR THE FRONT AND 47 FOR THE REAR.*AK UPDATED 1/4/2006 - *NM

NHTSA ODI #10144337

Official recalls

1

06V025000 · Fuel System, Gasoline:storage:tank Assembly

Jan 30, 2006

ON CERTAIN MOTORCYCLES, STRESS AROUND THE RIGHT FRONT FUEL TANK MOUNTING POINT CAN CAUSE HAIRLINE FATIGUE CRACKS TO FORM. THIS CAN RESULT IN A FUEL LEAK.

Consequence & remedy

Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL TANK AND INSTALL IMPROVED CUSHIONS THAT MOUNT AND SUPPORT THE FUEL TANK. ANY FUEL TANKS THAT ARE FOUND TO HAVE A CRACK WILL BE REPLACED. IF A TANK IS FOUND TO HAVE A CRACK AND A REPLACEMENT TANK IS NOT AVAILABLE, FUEL TANK SEALANT WILL BE APPLIED TO THE TANK AS AN INTERIM REPAIR. WHEN THE REPLACEMENT TANK BECOMES AVAILABLE, THE OWNER WILL BE CONTACTED AND A REPLACEMENT TANK WILL BE INSTALLED. THE RECALL BEGAN ON FEBRUARY 3, 2006. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE05031 · Fuel Leak

Opened Jun 15, 2005 · Closed Feb 1, 2006

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

ODI OPENED THIS PE AFTER RECEIVING FUEL TANK LEAK ALLEGATIONS FROM EIGHT OWNERS.SUBSEQUENTLY, WE MET WITH BOTH COMPLAINT MOTORCYCLE OWNERS AND OWNERS OF MOTORCYCLES WHICH HAD NOT LEAKED FUEL AND INSPECTED THEIR MOTORCYCLES. WE ALSO DISCUSSED THE MATTER WITH SUZUKI AUTHORIZED DEALERSHIP PERSONNEL, REQUESTED AND REVIEWED INFORMATION FROM SUZUKI, AND DISCUSSED THIS MATTER WITH COMPANY REPRESENTATIVES ON 11-3-05. SUZUKI HAS DECIDED TO RECALL THE SUBJECT MOTORCYCLES TO CORRECT THE FUEL LEAK ISSUE.WITH SUZUKI'S ACTION, THIS MATTER IS CONCLUDED AND THE INVESTIGATION CLOSED.A COPY OF SUZUKI'S RECALL IS ATTACHED.