Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
825–50K
1450–75K
975–100K
8100–150K
0150K+
54 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports3 fire reports3 injury reports
What owners actually said
63 reports
6,100 miles · Sep 1, 2006
SteeringSuspension
DT*: THE CONTACT STATED ON TWO OCCASIONS WHILE DRIVING 35-40 MPH THE FRONT END SHOOK VIOLENTLY CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND DRIFT INTO THE OTHER LANE. THE FIRST TIME THE VEHICLE WAS TRAVELING 55 MPH. IN ADDITION, THE STEERING WHEEL VIBRATED AT VARIOUS SPEEDS. THE DEALERSHIP WAS UNABLE TO DUPLICATE TH…
Read full complaint
DT*: THE CONTACT STATED ON TWO OCCASIONS WHILE DRIVING 35-40 MPH THE FRONT END SHOOK VIOLENTLY CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND DRIFT INTO THE OTHER LANE. THE FIRST TIME THE VEHICLE WAS TRAVELING 55 MPH. IN ADDITION, THE STEERING WHEEL VIBRATED AT VARIOUS SPEEDS. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM.
NHTSA ODI #10167209
7,000 miles · Aug 27, 2006
Electrical System
1. CAR HESITATES TO START IN THE MORNING AND STALLS 2. CAR DEALER STATES IT NEEDS A SOFTWARE PART. 3. PART INSTALLED AND NOTHING BUT PROBLEMS AFTER THAT AS WELL. CAR LEAKED GAS, ENGINE LIGHT WOULD COME ON, CAR AGAIN WOULD HESITATE TO START AND WOULD STALL. DEALER PUTS NEW COMPUTER IN THE NEW CAR AND THE CAR RUNS WORSE THAN IT …
Read full complaint
1. CAR HESITATES TO START IN THE MORNING AND STALLS 2. CAR DEALER STATES IT NEEDS A SOFTWARE PART. 3. PART INSTALLED AND NOTHING BUT PROBLEMS AFTER THAT AS WELL. CAR LEAKED GAS, ENGINE LIGHT WOULD COME ON, CAR AGAIN WOULD HESITATE TO START AND WOULD STALL. DEALER PUTS NEW COMPUTER IN THE NEW CAR AND THE CAR RUNS WORSE THAN IT DID BEFORE. ENGINE LIGHT COMES ON AND CAR WOULD STALL GOING DOWN THE ROAD AND CAR LOOSES STEERING WHEN IT STALLS. ALMOST IN A FEW ACCIDENTS DUE TO STALLING IN THE MIDDLE OF THE ROAD. THE KEEP RE-FLASHING THE COMPUTER AND IT'S NOT HELPING. *JB
NHTSA ODI #10166658
10,500 miles · Jul 20, 2006
Visibility
I HAVE OWNED THIS CAR FOR ABOUT 8 MONTHS AND THE WINDSHIELD HAS NOW CRACKED OR CHIPPED TWICE FROM SMALL STONES OFF THE ROAD. I HAVE SIGNIFICANT WORRIES ABOUT THE QUALITY OF THIS GLASS IF IT IS FAILING SO EASILY. I UNDERSTAND THE ISSUES COULD BE FLUKES, BUT I AM NOT SURE AFTER A SECOND FAILURE. THE STONE IN THIS INCIDENT WAS V…
Read full complaint
I HAVE OWNED THIS CAR FOR ABOUT 8 MONTHS AND THE WINDSHIELD HAS NOW CRACKED OR CHIPPED TWICE FROM SMALL STONES OFF THE ROAD. I HAVE SIGNIFICANT WORRIES ABOUT THE QUALITY OF THIS GLASS IF IT IS FAILING SO EASILY. I UNDERSTAND THE ISSUES COULD BE FLUKES, BUT I AM NOT SURE AFTER A SECOND FAILURE. THE STONE IN THIS INCIDENT WAS VERY SMALL AND SHOULD NOT, IN MY OPINION, CAUSED A CRACK SO EASILY. I AM VERY WORRIED IN REGARDS TO A LARGER FAILURE AND HOPE YOU CAN INVESTIGATE THE ISSUE. *NM
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.
Consequence & remedy
Consequence: THESE BUCKLE MALFUNCTIONS, WHICH COULD PREVENT A PERSON FROM USING THE SEAT BELT OR COULD CAUSE THE SEAT BELT TO FAIL TO FUNCTION AS DESIGNED, CAN INCREASE THE RISK OF INJURY IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES WITH THE IMPROVED PART FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Suzuki Reno Problems, Complaints & Recalls | Skip That Year
Illustration