INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) WHEN HEADLIGHTS ARE ON AFTER A WHILE YOU SMELL ELECTRICAL BURNING THEN THE LIGHTS GO OUT. WAS TAKEN FOR REPAIR AT MILFORD SUZUKI ,P O BOX M RT 6 & 209, MILFORD, PA 18337. (570) 296-2636. TECH FOUND WIRES RUBBED THROUGH ON METAL BRACKET,…
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) WHEN HEADLIGHTS ARE ON AFTER A WHILE YOU SMELL ELECTRICAL BURNING THEN THE LIGHTS GO OUT. WAS TAKEN FOR REPAIR AT MILFORD SUZUKI ,P O BOX M RT 6 & 209, MILFORD, PA 18337. (570) 296-2636. TECH FOUND WIRES RUBBED THROUGH ON METAL BRACKET, TECH REPAIRED WIRE AND EVERYTHING WORKS AS DESIGNED. THE REPAIR BILL WAS TOTAL OF $94.77. I DID FILE CASE WITH SUZUKI. CASE NUMBER IS [XXX] MODEL 2006 RENO. *TR
NHTSA ODI #10315284
Mileage unknown · Jan 17, 2009
Exterior Lighting
MY HEADLIGHTS ARE SHORTING OUT. MAINLY THE DAYTIME AND LOW BEAMS. I ALSO HAVE A HIGHBEAM ASSEMBLY PART THAT HAS BROKEN. THE LIGHTS STARTED TO FLICKER A LITTLE NOW AND THEN. THEN IT GOT TO THE POINT THE LOW BEAMS JUST CUT OUT. I AM IN TOTAL DARKNESS. I RAN OFF THE ROAD. THE HIGHBEAMS ARE SOMETIMES AFFECTED BUT USUALLY REMAIN WOR…
Read full complaint
MY HEADLIGHTS ARE SHORTING OUT. MAINLY THE DAYTIME AND LOW BEAMS. I ALSO HAVE A HIGHBEAM ASSEMBLY PART THAT HAS BROKEN. THE LIGHTS STARTED TO FLICKER A LITTLE NOW AND THEN. THEN IT GOT TO THE POINT THE LOW BEAMS JUST CUT OUT. I AM IN TOTAL DARKNESS. I RAN OFF THE ROAD. THE HIGHBEAMS ARE SOMETIMES AFFECTED BUT USUALLY REMAIN WORKING. HOWEVER THE ONE HIGH BEAM DOES NOT WORK DUE TO THE FACT THE INTERNAL HOLDER CLIP FOR THE BULB JUST BROKE ONE DAY. THERE IS NO AFTER MARKET PART FOR THIS. IT IS A PROBLEM. I AM THE WORKING POOR. I CAN NOT AFFORD AN OTHER TICKET. I ALREADY HAVE ONE FOR THIS UNRESOLVED PROBLEM. *TR
NHTSA ODI #10255452
40,000 miles · Jul 18, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2006 SUZUKI RENO. THE CONTACT STATED THAT THE DAYTIME RUNNING LIGHTS WOULD REMAIN ILLUMINATED ALL DAY, BUT THE NIGHTTIME LIGHTS AND HIGH BEAMS WERE INOPERABLE. EVENTUALLY, THE VEHICLE WOULD NOT START. ON JULY 9, 2008, SHE DISCOVERED TWO RECALLS ON SAFERCAR.GOV FOR THE 2006 SUZUKI RENO MODELS, ONE OF WHIC…
Read full complaint
TL*THE CONTACT OWNS A 2006 SUZUKI RENO. THE CONTACT STATED THAT THE DAYTIME RUNNING LIGHTS WOULD REMAIN ILLUMINATED ALL DAY, BUT THE NIGHTTIME LIGHTS AND HIGH BEAMS WERE INOPERABLE. EVENTUALLY, THE VEHICLE WOULD NOT START. ON JULY 9, 2008, SHE DISCOVERED TWO RECALLS ON SAFERCAR.GOV FOR THE 2006 SUZUKI RENO MODELS, ONE OF WHICH CLEARLY STATED THAT THE DAYTIME RUNNING LIGHTS WERE CAUSING A MALFUNCTION (NHTSA CAMPAIGN ID NUMBER 07V452000: EXTERIOR LIGHTING). SHE TOOK THE VEHICLE TO THE SUZUKI DEALER AND WAS INFORMED THAT THE RECALL REPAIR WOULD BE COVERED BY THE MANUFACTURER, BUT IF NOT, SHE WOULD BE LIABLE. THE DEALER STATED THAT THE BATTERY NEEDED TO BE REPLACED AND WAS UNABLE TO DETERMINE WHY THE EXTERIOR LIGHTS WERE NOT OPERATING CORRECTLY. THE MANUFACTURER STATED THAT HER VIN WAS NOT INCLUDED IN THE RECALL AND SHE WOULD BE LIABLE FOR THE REPAIR COSTS. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 40,900.
NHTSA ODI #10234861
971 miles · Jan 3, 2007
Exterior LightingCrashInjury
TL* - THE CONTACT STATED THAT THE HEADLIGHTS TURNED OFF. THE VEHICLE CURRENTLY HAS 4000 MILES ON THE ODOMETER. THE DEALER REPLACED THE LEFT HEADLIGHT FUSE. THE CONTACT STATED THAT ON NOVEMBER 15, 2006 THE HEADLIGHTS TURNED OFF AGAIN ,AND THE CONTACT REPLACED THE FUSE. THE CONTACT WAS DRIVING THE VEHICLE ON NOV 27, 2006 W…
Read full complaint
TL* - THE CONTACT STATED THAT THE HEADLIGHTS TURNED OFF. THE VEHICLE CURRENTLY HAS 4000 MILES ON THE ODOMETER. THE DEALER REPLACED THE LEFT HEADLIGHT FUSE. THE CONTACT STATED THAT ON NOVEMBER 15, 2006 THE HEADLIGHTS TURNED OFF AGAIN ,AND THE CONTACT REPLACED THE FUSE. THE CONTACT WAS DRIVING THE VEHICLE ON NOV 27, 2006 WHEN THE SAME INCIDENT OCCURRED WHILE DRIVING 65 MPH. THE CONTACT REDUCED THE VEHICLE'S SPEED TO 25 MPH, AT WHICH POINT HE DROVE INTO A DITCH AND THE AIRBAG DEPLOYED. THE CONTACT WAS NOT WEARING HIS SEAT BELT. THE VEHICLE DID NOT STRIKE ANYTHING. THE CONTACT STATED SUSTAINED WHIPLASH. HE DID NOT SEEK MEDICAL ATTENTION. HE WAS ABLE TO DRIVE THE VEHICLE HOME. THERE WERE NO WARNING LIGHTS AND THE VEHICLE DID NOT LOSE POWER. THE CONTACT HAD A SCHEDULED APPOINTMENT, BUT HE DID NOT TAKE THE VEHICLE TO THE DEALER. THE CONTACT STATES HE REPLACED THE FUSE AND THE HEADLIGHTS WEREWORKING INTERMITTENTLY. *AK
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.
Consequence & remedy
Consequence: THESE BUCKLE MALFUNCTIONS, WHICH COULD PREVENT A PERSON FROM USING THE SEAT BELT OR COULD CAUSE THE SEAT BELT TO FAIL TO FUNCTION AS DESIGNED, CAN INCREASE THE RISK OF INJURY IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES WITH THE IMPROVED PART FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Suzuki Reno Problems, Complaints & Recalls | Skip That Year
Illustration