2007 Suzuki GSX-R600

I WAS RIDING MY BIKE AND MY BUDDIES BEHIND ME SMELLED A SULFUR SMELL RODE ABOUT 15 MORE MILES AND THE BIKE SHUT OFF PULLED IN TO PARK IT AND SEE WHAT HAPPENED AND THE SULFUR SMELL WAS 10X WORSE AND HAD TO TOW THE BIKE HOME. THE DASH WENT ALL CRAZY FLASHING AND SHUT ON AND OFF AND THEN AN F1 CODE POPPED UP. SO THE NEXT DAY I TOOK IT TO THE LOCAL MECHANIC AND MY BATTERY WAS BAD,HE SAID THE REGULATOR RECTIFIER WAS OVER CHARGING THE BATTERY. *TR

I OWN A 2007 SUZUKI GSX-R600. THE MOTORCYCLE STALLED WHILE TRAVELING AT ABOUT 65 MPH WITHOUT ANY WARNING. I HAD THE MOTORCYCLE TOWED HOME. THE MECHANIC STATED THE REGULATOR COULD HAVE CAUSED THE FAILURE TO OCCUR. I WAS TOLD THERE WAS ONLY A RECALL RELATED TO 2008/2009 MODEL VEHICLES. THE FAILURE AND CURRENT MILEAGE WAS 20,989. *KB

TL* THE CONTACT OWNS A 2007 SUZUKI GSX-R600 MOTORCYCLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED FLAMES NEAR THE HANDLE BAR AREA, CLOSE TO THE CONTACT'S HANDS. THE CONTACT WAS ABLE TO STOP THE VEHICLE AND EXTINGUISH THE FIRE USING WATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC ADVISED THAT THE RECTIFIER HAD TO BE REPLACED BECAUSE THERE WAS A HOLE WHICH HAD MELTED THE RECTIFIER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.

TL* THE CONTACT OWNS A 2007 SUZUKI GSX-R600. THE CONTACT STATED THE MOTORCYCLE STALLED WHILE TRAVELING 30 MPH WITHOUT ANY WARNING. THE CONTACT HAD THE MOTORCYCLE TOWED TO THE RESIDENCE. THE MECHANIC STATED THE REGULATOR COULD HAVE CAUSED THE FAILURE TO OCCUR. THE CONTACT WAS TOLD THERE WAS ONLY A RECALL RELATED TO 2008/2009 MODEL VEHICLES. THE FAILURE AND CURRENT MILEAGE WAS 6,914.

THE FACTORY SERVICE MANUAL LISTS THE TORQUE FOR THE REAR SPROCKET NUTS AS 67.5 FT-LBS. THE MOTORCYCLES WERE BUILD WITH THIS SPEC! THIS IS INCORRECT AND IS CORRECTED WITH A SUZUKI SERVICE BULLETIN(BUT NOT A RECALL TO CURRENT OWNERS!). DEPENDING ON THE LUCK, BUT PROBABLY YOU WILL JUST SHEAR THE THREADS AND END UP WITH A SPINNING LOOSE SPROCKET & NUT. A STUD CAN BREAK OFF THE SPROCKET UNDER PRESSURE AND CAUSE THE CHAIN TO BREAK FREE CAUSING A REAR WHEEL TO LOCK THUS RESULTING IN A SERIOUS ACCIDENT, OR TO CUT THE RIDER'S LET LEG WHILE DRIVING AT A HIGH SPEED. THE CORRECT TORQUE FOR THE REAR SPROCKET NUTS IS 43.5 FT-LBS. *TR

MY SON SUDDENLY LOST POWER ON HIS 2007 SUZUKI GSXR600 MOTORCYCLE WHILE OPERATING AT LOW SPEED. TECHNICIAN FOUND AND REPLACED A BLOWN FUSE. A FEW DAYS LATER, THE SAME THING OCCURRED. THE PROBLEM FUSE WAS THE ONE RELATED TO THE FUEL PUMP. TECHNICIAN THEN DISCOVERED THE WIRE HARNESS HAD SHORTED OUT DUE TO BEING ROUTED TOO CLOSE TO THE "TENSIONER". MY SON SAID THIS POWER LOSS COULD BE FATAL IF IT WERE TO OCCUR WHILE DRIVING AROUND A CURVE AT HIGHWAY SPEED. I SEE THAT SUZUKI HAD A RECALL FOR A SIMILAR PROBLEM IN A 2006 MODEL: NHTSA CAMPAIGN ID NUMBER: 05V566000. I STRONGLY RECOMMEND YOU CONSIDER AN INVESTIGATION / RECALL FOR THIS DEFECT IN THE 2007 GSXR600 BEFORE IT CAUSES ACCIDENTS OR DEATH. *TR

TL*THE CONTACT OWNS A 2007 SUZUKI GSX-R600 MOTORCYCLE. WHILE TRAVELING APPROXIMATELY 40 MPH OVER A SMALL BUMP IN THE ROAD, THE MOTORCYCLE FRAME FRACTURED AND CAUSED IT TO CRASH. THE VEHICLE WAS COMPLETELY DESTROYED AND THE CONTACT SUSTAINED SEVERE INJURIES. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 09V022000 (STRUCTURE: FRAME AND MEMBERS:UNDER BODY SHIELDS). SHE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 11,000.

TL*THE CONTACT OWNS A 2007 SUZUKI GSX-R600. WHEN THE VEHICLE CAME TO A COMPLETE STOP, THE CONTACT SMELLED AN ODOR AS IF THE ELECTRICAL WIRES WERE ON FIRE. SHORTLY AFTER, THE VEHICLE STALLED. HE NOTICED THAT THE MAIN FUSE HAD BURNED AND WAS LATER REPLACED. THE FAILURE RECURRED INTERMITTENTLY. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE CHARGING SYSTEM RECTIFIER. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 95,971.