TL* THE CONTACT OWNS A 2006 SUZUKI GSX-R1000. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, HE ATTEMPTED TO SWITCH LANES WHILE DECELERATING. THE BRAKES MALFUNCTIONED AND CAUSED THE CONTACT TO CRASH INTO THE CONCRETE DIVIDER. THE CONTACT WAS TRANSPORTED FROM THE CRASH SITE AND SUFFERED HEAD TRAUMA, A BROKEN LEFT F…
Read full complaint
TL* THE CONTACT OWNS A 2006 SUZUKI GSX-R1000. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, HE ATTEMPTED TO SWITCH LANES WHILE DECELERATING. THE BRAKES MALFUNCTIONED AND CAUSED THE CONTACT TO CRASH INTO THE CONCRETE DIVIDER. THE CONTACT WAS TRANSPORTED FROM THE CRASH SITE AND SUFFERED HEAD TRAUMA, A BROKEN LEFT FEMUR, AND NERVE DAMAGE TO THE LEFT LEG. THE VEHICLE WAS REPAIRED BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 7,500.
NHTSA ODI #10559700
23,300 miles · Oct 28, 2013
Service BrakesCrashInjury
FRONT BRAKES LOCKED UP ON 2006 GSXR 1000, CAUSING FRONT END OF MOTORCYCLE TO SLIDE OUT. FRONT BRAKE PISTONS AND PADS DID NOT RETRACT AS SUPPOSED TO PRIOR TO CRASH, CAUSING MORE DRAG AND HEAT BUILD UP. WITH MORE HEAT BUILT UP, THE BRAKE FLUID AND ANY TRAPPED AIR, EXPANDED AND CAUSED THE CALIPER PISTONS AND PADS TO ENGAGE THE RO…
Read full complaint
FRONT BRAKES LOCKED UP ON 2006 GSXR 1000, CAUSING FRONT END OF MOTORCYCLE TO SLIDE OUT. FRONT BRAKE PISTONS AND PADS DID NOT RETRACT AS SUPPOSED TO PRIOR TO CRASH, CAUSING MORE DRAG AND HEAT BUILD UP. WITH MORE HEAT BUILT UP, THE BRAKE FLUID AND ANY TRAPPED AIR, EXPANDED AND CAUSED THE CALIPER PISTONS AND PADS TO ENGAGE THE ROTOR SUDDENLY AND CAUSED BRAKE LOCK UP. RIDER WAS EJECTED FROM THE MOTORCYCLE AT AROUND 30 MPH AND ROLLED FOR AROUND 50 FEET. BIKE SLID ON ITS SIDE AND HAD EXTENSIVE BODY AND CONTROLS DAMAGE. RIDER WAS TAKEN TO ER AND UNDERWENT SEVERAL HOURS OF TESTS, XRAYS, CTSCANS, ETC. RIDER SUFFERED DEEPLY BRUISED/HAIR-LINE CRACKED RIBS AND SEVERE ROAD RASH ON KNEES. RIDER WAS WEARING ALL APPROPRIATE PROTECTIVE RIDING GEAR INCLUDING FULL FACE HELMET, RIDING BOOTS, RIDING JACKET, GLOVES, AND JEANS. *TR
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2013 GSX-R600 and GSX-R750, and model year 2005-2013 GSX-R1000 motorcycles. In combination with older brake fluid, corrosion of the brake piston inside of the front brake master cylinder generates gas that may result in a reduction of fluid pressure transmission to the front brake.
Consequence & remedy
Consequence: As a result, front braking power may be reduced increasing the risk of a crash.
Remedy: Suzuki will notify owners, and dealers will replace the front brake master cylinder, free of charge. The recall began on November 18, 2013. Owners may contact Suzuki at 1-800-572-1490. Suzuki's campaign numbers for this recall are: 2A (31, 32, 33, 34, 35, and 36).
AMERICAN SUZUKI (SUZUKI) IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 26,082 MY 2005-2006 GSX-R1000 MOTORCYCLES. CRACKING OR BREAKAGE OF THE MOTORCYCLE FRAME CAN OCCUR IN CERTAIN EXTREME SITUATIONS WHERE UNUSUALLY HIGH STRESS IS PLACED ON THE FRAME. REPEATED HARD LANDINGS FROM HAZARDOUS MANEUVERS SUCH AS EXTREME OR EXTENDED WHEELIES OR OTHER STUNTS MAY GENERATE SUFFICIENT STRESS TO CAUSE THIS PROBLEM.
Consequence & remedy
Consequence: IF THE FRAME BECOMES BROKEN DURING EXTREME USE, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FRAME FOR CRACKS. IF NO CRACKS ARE FOUND, A FRAME REINFORCEMENT BRACE WILL BE ATTACHED TO THE FRAME USING BOLTS AND EPOXY ADHESIVE. SHOULD CRACKS BE FOUND DURING THE INSPECTION, THE FRAME WILL BE REPLACED WITH A NEW FRAME THAT HAS THE REINFORCEMENT BRACE INSTALLED. THE CAMPAIGN BEGAN ON JANUARY 21, 2009. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Suzuki GSX-R1000 Problems, Complaints & Recalls | Skip That Year
Illustration