IllustrationLOW BEAM HEADLIGHT BURNED OUT. I'VE HAD TO REPLACE DRIVER AND PASSENGER SIDE HEADLIGHT BULBS 8 (DRIVER), 6 (PASSENGER). ALSO, CANNOT SEE FAR ENOUGH AHEAD WHEN ONLY USING LOW BEAM. THIS IS A HAZARD! TIRED OF REPLACING BULBS EVERY 6 MONTHS. THEY AREN'T CHEAP.
2008 Suzuki Grand Vitara
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Suzuki Grand Vitara do not stand out strongly from the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Vitara years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
625–50K
950–75K
275–100K
3100–150K
1150K+
35 reports with mileage · 7 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports3 injury reports
Exterior Lighting complaints
20 reportsI HAVE HAD A 2008 SUZUKI GRAND VITARA FOR THE PAST 5 YEARS IN THAT TIME I CAN NOT EVEN BEGIN TO TELL YOU THE COUNTLESS I'VE HAD TO REPLACE THE BULBS IN THE HEADLIGHTS. ITS OBVIOUS FROM WHAT I'VE READ THAT THIS IS ON GOING ISSUE WITH THIS TYPE OF MAKE AND MODEL CAR. ITS OBVIOUS THE PART IS DEFECTIVE AND THERE SHOULD BE A RECALL I…
Read full complaint
I HAVE HAD A 2008 SUZUKI GRAND VITARA FOR THE PAST 5 YEARS IN THAT TIME I CAN NOT EVEN BEGIN TO TELL YOU THE COUNTLESS I'VE HAD TO REPLACE THE BULBS IN THE HEADLIGHTS. ITS OBVIOUS FROM WHAT I'VE READ THAT THIS IS ON GOING ISSUE WITH THIS TYPE OF MAKE AND MODEL CAR. ITS OBVIOUS THE PART IS DEFECTIVE AND THERE SHOULD BE A RECALL ISSUED TO REPLACE THESE HEADLIGHTS ALL TOGETHER. *TR
I HAVE BEEN REPLACING THE HEADLIGHT BULBS IN MY VEHICLE NEARLY EVERY 6 MONTHS SINCE I PURCHASED IT. LAST YEAR I REPLACED THE RT HEADLAMP ASSEMBLY UNIT AT THE RECOMMENDATION OF THE SERVICE DEPARTMENT BECAUSE THE HOUSING UNIT WAS BURNED AND WOULD NOT SEAT PROPERLY INTO THE ADAPTER. REPLACING THE ADAPTER WAS NOT AN OPTION, SO I I…
Read full complaint
I HAVE BEEN REPLACING THE HEADLIGHT BULBS IN MY VEHICLE NEARLY EVERY 6 MONTHS SINCE I PURCHASED IT. LAST YEAR I REPLACED THE RT HEADLAMP ASSEMBLY UNIT AT THE RECOMMENDATION OF THE SERVICE DEPARTMENT BECAUSE THE HOUSING UNIT WAS BURNED AND WOULD NOT SEAT PROPERLY INTO THE ADAPTER. REPLACING THE ADAPTER WAS NOT AN OPTION, SO I INCURRED LABOR AND PARTS EXPENSES. NOW IN THE SHORTER DAYLIGHT FALL SEASON, THE LEFT BULB HAS BLOWN AND THE ADAPTER WAS BEGINNING TO BURN, SO I REPLACED IT. I INSPECTED IT TO CONFIRM THE STATE OF THE UNIT AND IT WAS INDEED, ON ITS WAY TO ELECTRICAL MALFUNCTION. THERE IS NO WAY, WHEN DRIVING NOR IDLE, TO KNOW THAT SUCH AN IMPORTANT COMPONENT OF THE VEHICLE IS DECAYING. I HAVE PURCHASED HL7 55WATT BULBS, WHICH ARE THE LOWEST WATTS AVAILABLE. I FEEL UNSAFE DURING INCLIMATE WEATHER, FALL AND WINTER SEASON DRIVING. THIS FREQUENT NEED FOR REPLACEMENT TO AVOID POTENTIAL CRASHES IS OF MAJOR CONCERN TO ME. *TR
WITHIN A FEW MONTHS OF PURCHASING THE VEHICLE, I HAD TO BEGIN REPLACING LOW BEAM HEAD LAMPS, SEEMINGLY DURING RANDOM STARTS THE BULB WOULD BLOW OUT ON EITHER THE PASSENGER OR DRIVERS SIDE, WITH VERY LITTLE USE BEHIND IT. SOME LAMPS LASTED AS LITTLE AS A FEW WEEKS, OTHERS LASTED MORE THAN A YEAR, BUT THE BULBS NEEDED A SIGNIFICAN…
Read full complaint
WITHIN A FEW MONTHS OF PURCHASING THE VEHICLE, I HAD TO BEGIN REPLACING LOW BEAM HEAD LAMPS, SEEMINGLY DURING RANDOM STARTS THE BULB WOULD BLOW OUT ON EITHER THE PASSENGER OR DRIVERS SIDE, WITH VERY LITTLE USE BEHIND IT. SOME LAMPS LASTED AS LITTLE AS A FEW WEEKS, OTHERS LASTED MORE THAN A YEAR, BUT THE BULBS NEEDED A SIGNIFICANTLY HIGHER RATE OF REPLACEMENT THAN ANY OTHER VEHICLE I'VE EVER DRIVEN. I HAVE REPLACED MULTIPLE LOW BEAM LAMPS - 6 DRIVER SIDE LAMPS, AND 8 PASSENGER SIDE IN ONLY 5 YEARS OF OWNING THE VEHICLE AND LESS THAN 20K MILES DRIVER PER YEAR. NO HELP FROM SUZUKI ON THE MATTER. AND I ONLY BUY QUALITY BULBS FROM BRAND NAME MANUFACTURERS AT REPUTABLE PARTS STORES. *TR
HAD TO CONSTANTLY REPLACE DRIVERS SIDE LOW BEAM HEADLIGHT 6 TIMES SINCE I HAVE OWNED THIS VEHICLE. NOW BOTH DRIVER AND PASSENGER SIDE DO NOT WORK, BULBS ARE NOT BLOWN, AND FUSES ARE FINE. MY MECHANIC SAYS THAT IT IS A KNOWN PROBLEM THAT SUZUKI REFUSES TO ACKNOWLEDGE. I SHOULD NOT HAVE UPWARDS OF $1200.00 OUT OF POCKET FOR A K…
Read full complaint
HAD TO CONSTANTLY REPLACE DRIVERS SIDE LOW BEAM HEADLIGHT 6 TIMES SINCE I HAVE OWNED THIS VEHICLE. NOW BOTH DRIVER AND PASSENGER SIDE DO NOT WORK, BULBS ARE NOT BLOWN, AND FUSES ARE FINE. MY MECHANIC SAYS THAT IT IS A KNOWN PROBLEM THAT SUZUKI REFUSES TO ACKNOWLEDGE. I SHOULD NOT HAVE UPWARDS OF $1200.00 OUT OF POCKET FOR A KNOWN PROBLEM. I STILL HAVE 2 PAYMENTS TO GO AND I BOUGHT THIS BRAND NEW. SOMETHING NEEDS TO BE DONE NOW BEFORE SOMEONE GETS KILLED BECAUSE OF THIS. THAT'S IF IT HASN'T HAPPENED ALREADY. *TR
THE LOW BEAM HEADLIGHTS BOTH DRIVER AND PASSENGER KEEP BLOWING HAVE HAD TO REPLACE ATLEAST 10 TIMES NOW. I CARRY EXTRA TO BE SAFE AND THIS IS GETTING VERY EXPENSIVE. *TR
HEADLIGHTS KEEP BURNING OUT. IN 2 YEARS OF OWNERSHIP, WE HAVE REPLACED THE BULBS AT LEAST 6 TIMES. THIS IS DANGEROUS, IN ADDITION TO BEING EXPENSIVE. *TR
WHEN I FIRST BOUGHT THE 2008 SUZUKI GRAND VITARA, I NOTICED THAT THE LOW BEAM HEADLIGHTS WERE SO LOW THAT I COULD NOT SEE THE ROAD. I LITERALLY CANNOT SEE THE ROAD BECAUSE THEY ARE SO DIM-THEY KEEP BLOWING OUT AND NEEDING TO BE REPLACED AS WELL. I HAVE TO DRIVE WITH MY HIGH BEAM LIGHTS ON AT NIGHT BECAUSE I AM AFRAID I WILL HI…
Read full complaint
WHEN I FIRST BOUGHT THE 2008 SUZUKI GRAND VITARA, I NOTICED THAT THE LOW BEAM HEADLIGHTS WERE SO LOW THAT I COULD NOT SEE THE ROAD. I LITERALLY CANNOT SEE THE ROAD BECAUSE THEY ARE SO DIM-THEY KEEP BLOWING OUT AND NEEDING TO BE REPLACED AS WELL. I HAVE TO DRIVE WITH MY HIGH BEAM LIGHTS ON AT NIGHT BECAUSE I AM AFRAID I WILL HIT SOMEONE OR SOMETHING. I AM BLINDED BY ON COMING TRAFFIC IF I DRIVE WITH THESE ON. THIS IS A GREAT SAFETY HAZARD-THESE LIGHTS SHOULD BE RECALLED BEFORE SOMEONE GETS KILLED. I GOT MY SIXTEEN Y/O DAUGHTER THIS CAR AND I REFUSE TO LET HER DRIVE IT- I DRIVE IT. BEEN TO DEALERSHIP MANY TIMES-STILL NOT ANY BETTER. PLEASE HELP. *TT
I HAVE JUST ENTERED THE MILEAGE OF THE LAST TIME THIS PROBLEM HAPPENED. MY 2008 SUZUKI GRAND VITARA KEEPS BLOWING THE HEADLAMP BULBS. I HAVE REPLACED IT MORE THAN 10 TIMES WHICH IS OBVIOUSLY ABNORMAL SINCE MOST OF THE CARS USES THE SAME BULB EVEN FOR YEARS. AS I CAN SEE IN INTERNET FORUMS THIS IS A COMMON PROBLEM BETWEEN SUZUKI …
Read full complaint
I HAVE JUST ENTERED THE MILEAGE OF THE LAST TIME THIS PROBLEM HAPPENED. MY 2008 SUZUKI GRAND VITARA KEEPS BLOWING THE HEADLAMP BULBS. I HAVE REPLACED IT MORE THAN 10 TIMES WHICH IS OBVIOUSLY ABNORMAL SINCE MOST OF THE CARS USES THE SAME BULB EVEN FOR YEARS. AS I CAN SEE IN INTERNET FORUMS THIS IS A COMMON PROBLEM BETWEEN SUZUKI OWNERS AND SUZUKI HAS DONE NOTHING TO CORRECT THIS PROBLEM. I CONSIDER THIS A SAFETY ISSUE. PLEASE HELP. *JB
TL*THE CONTACT OWNS A 2008 SUZUKI GRAND VITARA. WHILE DRIVING APPROXIMATELY 55 MPH AT NIGHT HE COULD NOT SEE BEYOND APPROXIMATELY 50 FEET WITH THE LOW BEAM HEADLIGHTS ON. THE FAILURE RECURRED WHENEVER HE DROVE AT NIGHT WITH THE LOW BEAMS ON. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO OCCASIONS WHERE HE WAS TOLD THAT TH…
Read full complaint
TL*THE CONTACT OWNS A 2008 SUZUKI GRAND VITARA. WHILE DRIVING APPROXIMATELY 55 MPH AT NIGHT HE COULD NOT SEE BEYOND APPROXIMATELY 50 FEET WITH THE LOW BEAM HEADLIGHTS ON. THE FAILURE RECURRED WHENEVER HE DROVE AT NIGHT WITH THE LOW BEAMS ON. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO OCCASIONS WHERE HE WAS TOLD THAT THE HEADLIGHTS MET FEDERAL STANDARDS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 31,000. UPDATED 02/08/11*LJ
Official recalls
219V187000 · Air Bags:sensor:occupant Classification; Seats
Mar 7, 2019
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence & remedy
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
Additional source detail variants (2)
Air Bags:sensor:occupant Classification
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
Seats
Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.
Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.
Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.
13V405000 · Air Bags
Sep 6, 2013
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2006-2011 Grand Vitara and 2007-2011 SX4 vehicles. In the affected vehicles, over time, the OCS sensor mat installed in the front passenger seat may fail due to repeated flexing of the mat from use of the seat. As a result, during a crash necessitating deployment, the air bag will deploy regardless of whether the front seat occupant is an adult or a child.
Consequence & remedy
Consequence: Air bag deployment with a child in the front passenger side seat increases the risk of injury to that child.
Remedy: Suzuki will notify owners and dealers will replace the front passenger seat cushion assembly (which includes the OCS sensor mat) free of charge. Sufficient quantities of parts are not currently available to fix all of the affected vehicles. Owners will be notified of the recall in October 2013 and will receive a second notification when parts are available to have their vehicle repaired. The recall began on May 23, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's recall campaign number is VD.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE13021 · Occupant Classification System Failure
Opened Jun 14, 2013 · Closed Sep 30, 2013
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Air Bags:frontal
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.
Air Bags
Suzuki Motor of America is conducting a safety recall to remedy the occupant classification system's (OCS) sensor mats in approximately 193,936 model year 2006-2011 Suzuki Grand Vitara and 2007-2011 Suzuki SX4 vehicles (see NHTSA recall 13V-405 for more details).The sensor mat installed in the front passenger seat can develop an electrical circuit disconnection as a result of repeated flexing of the seat from use of the seat.According to Suzuki, when the failure occurs, the OCS system, by design, will not suppress the frontal passenger air bag for a seated child or small-stature adult.A deploying passenger air bag can cause serious injury to such an occupant.The recall population excludes those vehicles that previously had proper remedies under the special coverage campaign for this issue (~11,600) that began in July 2012.The recall remedy will be to install a new front passenger seat cushion assembly that includes an improved OCS sensor mat and an OCS control module with updated algorithms designed to properly identify the type/size of the seated occupant.Consequently, this recall action will address various OCS related problems, including a programming error (associated with diagnostic trouble code B1318) related to detecting a change or shifting in load on the front passenger seat in the model year 2009 Grand Vitara and SX4 vehicles.This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10178750, 10185778, 10200217, 10200123, 10206368, 10217021, 10250561, 10254251, 10263756, 10283309, 10285166, 10294320, 10316125, 10323718, 10324530, 10326910, 10332645, 10347204, 10348957, 10349038, 10350237, 10353604, 10354901, 10355400, 10364190, 10367631, 10369777, 10371056, 10373558, 10375165, 10375789, 10376071, 10376621, 10378154, 10380794, 10382860, 10392447, 10392434, 10392599, 10393975, 10395430, 10395602, 10395821, 10395983, 10398172, 10400092, 10400035, 10401106, 10401424, 10404772, 10405359, 10406459, 10407500, 10409412, 10409993, 10413235, 10418162, 10419237, 10419578, 10425035, 10425212, 10426703, 10434905, 10435090, 10435091, 10437600, 10437892, 10437994, 10438100, 10438501, 10438613, 10439357, 10439979, 10440088, 10442968, 10442759, 10442883, 10443173, 10443592, 10443594, 10444434, 10445034, 10445447, 10446215, 10446580, 10447689, 10448161, 10448446, 10448499, 10448554, 10449238, 10450746, 10451260, 10452961, 10453168, 10453403, 10453376, 10454445, 10454978, 10455231, 10455529, 10456043, 10456367, 10456407, 10459063, 10460417, 10460510, 10462016, 10463337, 10464941, 10464693, 10467988, 10468641, 10479583, 10479929, 10481120, 10484053, 10484863, 10486369, 10486729, 10487379, 10491755, 10499622, 10506034, 10508282, 10511057, 10511439, 10512962, 10521656, 10521779, 10523512, 10523931, 10524266, 10526435, 10533196, 10535513, 10537314, 10537619, 10543672, 10544287.