Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1225–50K
550–75K
175–100K
0100–150K
1150K+
28 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports3 fire reports3 injury reports
What owners actually said
47 reports
Mileage unknown · May 6, 2005
Vehicle Speed Control
THE VEHICLE INTERMITTENTLY BEGAN TO RAPIDLY ACCELERATE WHEN ENGAGED FROM NEUTRAL TO DRIVE. THE DEALERSHIP INSPECTED THE VEHICLE FOUR TIMES AND REPLACED THE CABLE ACCELERATOR. *AK THE FIRST OCCASION OCCURRED AS THE CONSUMER PLACED THE VEHICLE INTO DRIVE AND THE VEHICLE WENT FLYING INTO THE NEXT PARKING SPACE. THE CONSUME…
Read full complaint
THE VEHICLE INTERMITTENTLY BEGAN TO RAPIDLY ACCELERATE WHEN ENGAGED FROM NEUTRAL TO DRIVE. THE DEALERSHIP INSPECTED THE VEHICLE FOUR TIMES AND REPLACED THE CABLE ACCELERATOR. *AK THE FIRST OCCASION OCCURRED AS THE CONSUMER PLACED THE VEHICLE INTO DRIVE AND THE VEHICLE WENT FLYING INTO THE NEXT PARKING SPACE. THE CONSUMER PRESSED THE BRAKE TO THE FLOOR, BUT THE VEHICLE CONTINUED ON. THE VEHICLE WAS PLACED INTO NEUTRAL, BUT NOTHING CHANGED, THE ENGINE CONTINUED RACING. THE CONSUMER WAITED A FEW MINUTES AND THE VEHICLE WAS STARTED AGAIN AND WAS BACK TO NORMAL. ON THE SECOND OCCASION, THE VEHICLE WAS STARTED AND PLACED INTO DRIVE AND EXACT SAME THING OCCURRED, BUT ONLY THIS TIME, THE VEHICLE WAS SHUT OFF AND STARTED BACK AGAIN IN FULL THROTTLE. ON THE THIRD OCCASION, WHEN THE SHIFTER WAS PLACED INTO DRIVE, THE ENGINE BEGAN TO RACE. THE BRAKE WAS APPLIED AND THE SHIFTER WAS PLACED IN NEUTRAL BUT THE VEHICLE CONTINUED TO RACE. *SC *JB
NHTSA ODI #10090387
63,500 miles · Mar 29, 2005
Fuel System, Gasoline
FUEL DOOR FELL OFF AGAIN!!!!
NHTSA ODI #10116019
62,000 miles · Mar 28, 2005
Fuel System, Gasoline
GASOLINE FUEL DOOR FELL OFF FOR NO REASON, AS FAR I CAN TELL, ALL THE HARDWARE THAT WOULD SECURE FUEL DOOR IS STILL THERE. I HAVE SEEN OTHER SUZUKI'S WITH THE SAME THING. *JB
NHTSA ODI #10114846
47,000 miles · Jan 21, 2005
Service Brakes, Hydraulic
THE PEDALS ARE TO CLOSE, CAUSING THE CONSUMER TO SIMULTANEOUSLY DEPRESS THE BRAKE/ACCELERATOR PEDAL. THE DEALERSHIP WILL BE NOTIFIED. THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION. *NM
NHTSA ODI #10108544
Mileage unknown · Jan 5, 2005
Electrical SystemPower Train
SUZUKI TAKEN TO DEALER 3 TIMES FOR IGNITION LOCKED AND 2 TIMES FOR THE 4WD PROBLEM. *BF WHEN THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALER FOR THE SECOND TIME REGARDING THE 4-WHEEL IT WAS DETERMINED THAT THE FAILURE WAS INTERNAL LOCATED IN THE FRONT DIFFERENTIAL ASSEMBLY. *JB
NHTSA ODI #10109523
Mileage unknown · Jan 4, 2005
Vehicle Speed Control
CONSUMER APPLIED THE ACCELERATOR PEDAL AND VEHICLE FAILED TO MOVE. AFTERWARDS THE VEHICLE ACCELERATED HESITANTLY ON ITS OWN. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC INFORMED CONSUMER THAT THE PROBLEM COULD NOT BE DUPLICATED. CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM HAPPENED MORE THAN ONCE, …
Read full complaint
CONSUMER APPLIED THE ACCELERATOR PEDAL AND VEHICLE FAILED TO MOVE. AFTERWARDS THE VEHICLE ACCELERATED HESITANTLY ON ITS OWN. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC INFORMED CONSUMER THAT THE PROBLEM COULD NOT BE DUPLICATED. CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM HAPPENED MORE THAN ONCE, AND HAD NOT BEEN RESOLVED. *AK
NHTSA ODI #10106775
Mileage unknown · Nov 23, 2004
Service Brakes, Hydraulic
THERE WAS A VIBRATION COMING FROM THE BRAKES. THE ROTORS HAD COMPLETELY WARPED. *JB
NHTSA ODI #10101553
Mileage unknown · Oct 19, 2004
Vehicle Speed Control
REPLACEMENT PARTS WERE NOT AVAILABLE TO PERFROM RECALL REPAIRS.*MR *JB *NM
NHTSA ODI #10081844
Mileage unknown · Oct 14, 2004
Fuel System, Gasoline
CONSUMER RECEIVED A RECALL NOTICE(04V427000) FOR THE FUEL PRESSURE REGULATOR. NO PARTS WERE AVAILABLE. *JB
NHTSA ODI #10096864
Mileage unknown · Oct 12, 2004
Fuel System, Gasoline
CONSUMER STATED SHE RECEIVED A RECALL NOTICE (CAMPAIGN #0442700), BUT WHEN SHE TOOK HER VEHICLE TO THE DEALER FOR THE REPAIR SHE WAS TOLD THAT THEY ARE BACK LOGGED. THEY ALSO TOLD HER THAT THEY DO NOT KNOW WHEN THEY WILL RECEIVE THE PARTS TO DO THE RECALL. THE DEALER ALSO TOLD HER THAT THEY HAVE CALLED THE MANUFACTURER AND WAS…
Read full complaint
CONSUMER STATED SHE RECEIVED A RECALL NOTICE (CAMPAIGN #0442700), BUT WHEN SHE TOOK HER VEHICLE TO THE DEALER FOR THE REPAIR SHE WAS TOLD THAT THEY ARE BACK LOGGED. THEY ALSO TOLD HER THAT THEY DO NOT KNOW WHEN THEY WILL RECEIVE THE PARTS TO DO THE RECALL. THE DEALER ALSO TOLD HER THAT THEY HAVE CALLED THE MANUFACTURER AND WAS TOLD THAT THEY DO NOT KNOW WHEN THEY WILL SENT THE PART. THE DEALERSHIP NAME IS BELL ROAD SUZUKI 999 W BELL RD PHOENIX, AZ 85023 602 993 3322. PLEASE HELP. *JB
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
CERTAIN PASSENGER (111 MY 2002 ESTEEM, 777 MY 2002 AERIO, 2,368 MY 2003 AERIO) AND SPORT UTILITY (324 MY 2002 GRAND VITARA, 274 MY 2003 GRAND VITARA, 684 MY 2002 GRAND VITARA XL-7, AND 781 MY 2003 GRAND VITARA XL-7) VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING." THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY DUE TO INSUFFICIENT ADHESION BETWEEN THE PAINT APPLIED DURING THE SECOND-STAGE PAINTING PROCESS AND THE PAINT APPLIED DURING FINAL-STAGE PAINTING.
Consequence & remedy
Consequence: IF THE WINDSHIELD IS NOT PROPERLY SECURED, IT MAY SEPARATE FROM THE VEHICLE DURING A CRASH WHICH COULD RESULT IN THE EJECTION OF UNBELTED OCCUPANTS, INCREASING THE RISK OF SEVERE INJURY OR DEATH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES. VEHICLES THAT ARE FOUND TO HAVE INSUFFICIENT PAINT ADHESION WILL EITHER HAVE THE PROBLEM REMEDIED BY REPAINTING, OR WILL BE REPLACED, OR REPURCHASED AND DESTROYED. OWNER NOTIFICATION BEGAN ON JULY 8, 2003. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Suzuki Grand Vitara Problems, Complaints & Recalls | Skip That Year
Illustration