NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
57 reportsClear category filterMileage unknown · Jul 22, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT STATED IT WOULD TAKE FIVE TO TEN MINUTES FOR THE VEHICLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS ADVISED TO CONTACT THE MANUFACTURER FOR…
Read full complaint
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT STATED IT WOULD TAKE FIVE TO TEN MINUTES FOR THE VEHICLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS ADVISED TO CONTACT THE MANUFACTURER FOR THE DIAGNOSTIC TESTING RESULTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10735795
121,000 miles · Jun 7, 2015
Electrical SystemEnginePower Train
BATTERY INDICATOR AND BRAKE INDICATOR ILLUMINATED ON THE CLUSTER PANEL. WHEN IN DRIVE, THE DISPLAY SHOWING WHAT GEAR YOU ARE IN FLASHES AN UNRECOGNIZABLE SIGNAL. SOME TROUBLE ACCELERATING.
NHTSA ODI #10723822
86,040 miles · Apr 1, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, WHICH RESUMED NORMAL OPERATION. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, WHICH RESUMED NORMAL OPERATION. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,040.
NHTSA ODI #10703214
130,000 miles · Feb 24, 2015
Air BagsElectrical SystemExterior Lighting
SLIPS OUT OF GEAR WHILE DRIVING, CAR STALLS AND CUTS OFF DURING DRIVING, ONLY CRANKS UP IN NEUTRAL,AIR BAG LIGHT STAYS ON, CHECK ENGINE LIGHT GO OFF AFTER A REPAIR THEN LIGHTS BACK UP. ITS FRUSTRATING TO HAVE TO CALL ROAD SIDE ASSISTANCE FOR A BATTERY CHARGE FREQUENTLY WHEN BATTERY LOSES CHARGE FOR NO APPARENT REASON. *JS
NHTSA ODI #10690216
90,500 miles · Oct 9, 2014
Electrical SystemPower Train
TRANSMISSION RANGE SENSOR IS FAILING AND CAUSED A LOSS OF POWER ALMOST CAUSING A MAJOR ACCIDENT. THIS IS A COMMON PROBLEM WITH THIS MODEL YEAR, AND NEEDS TO BE INVESTIGATED FOR A SAFETY RECALL. *TR
NHTSA ODI #10643476
130,000 miles · Aug 9, 2014
Electrical SystemExterior LightingSeat Belts
I WAS DRIVEN WHEN THE RIGHT SIDE HEADLIGHT WAS STOPPED. *TR
NHTSA ODI #10621065
89,000 miles · Aug 2, 2014
Electrical SystemEngine
MY ENGINE DIED WHILE DRIVING. MY BATTERY (WHICH WAS REPLACED 7 MONTHS PRIOR) ALSO DIED. WHEN I TRIED TO GET A JUMP START, THE ENGINE WOULD RUN FOR A FEW MOMENTS BEFORE DYING AGAIN. I HAD THE VEHICLE TOED TO A LOT AND HAVEN'T BEEN ABLE TO AFFORD REPAIRS, SO I HAD IT SCRAPPED. *TR
NHTSA ODI #10618361
71,000 miles · Jul 6, 2014
Electrical System
AIR CONDITIONING UNIT SHUT OFF, CAR RAN ERRACTICALLY AND ENGINE LIGHT CAME ON. AFTER SEVERAL MINUTES, CAR RAN NORMALLY AND AIR CONDITIONER CAME BACK ON. ENGINE LIGHT STAYED ON. SINCE THEN ENGINE LIGHT WILL GO OFF FOR SEVERAL DAYS AND COME BACK ON FOR SEVERAL DAYS. MECHANIC CHECKED ENGINE AND FOUND THAT THE PROBLEM WAS WITH TH…
Read full complaint
AIR CONDITIONING UNIT SHUT OFF, CAR RAN ERRACTICALLY AND ENGINE LIGHT CAME ON. AFTER SEVERAL MINUTES, CAR RAN NORMALLY AND AIR CONDITIONER CAME BACK ON. ENGINE LIGHT STAYED ON. SINCE THEN ENGINE LIGHT WILL GO OFF FOR SEVERAL DAYS AND COME BACK ON FOR SEVERAL DAYS. MECHANIC CHECKED ENGINE AND FOUND THAT THE PROBLEM WAS WITH THE THROTTLE SENSOR. *JS
NHTSA ODI #10608418
145,000 miles · Jul 1, 2014
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE INSTRUMENT PANEL CAUGHT ON FIRE. THE CONTACT MENTIONED THAT THE VEHICLE SOUND ALARM ACTIVATED. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THERE WAS A FIRE REPORT FILED AND NO INJURIES WERE REPORTED. THE FIRE DEPA…
Read full complaint
TL* THE CONTACT OWNS A 2006 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE INSTRUMENT PANEL CAUGHT ON FIRE. THE CONTACT MENTIONED THAT THE VEHICLE SOUND ALARM ACTIVATED. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THERE WAS A FIRE REPORT FILED AND NO INJURIES WERE REPORTED. THE FIRE DEPARTMENT DETERMINED THAT THE ELECTRICAL INSTRUMENT PANEL FAILED AND CAUSED THE FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 145,000.
NHTSA ODI #10607301
Mileage unknown · Jun 11, 2014
Electrical SystemFire
MY CAR HAD A FIRE ON 5/29/2014. I DROVE IN LOW SPEED 30 MPH IN TEMPE CITY, BUT I SMELLED LITTLE SMOKE COMING OUT. I PARKED THE CAR. THE FIRE STARTED FROM SOME CABLES AT THE LEFT SIDE COLUMN UNDER STEERING WHEEL IN FRONT OF DRIVER'S SEAT. THERE WAS NO COLLISION. SOME WIRES, PARTS AND THE PLASTIC COVER UNDER THE STEERING WHE…
Read full complaint
MY CAR HAD A FIRE ON 5/29/2014. I DROVE IN LOW SPEED 30 MPH IN TEMPE CITY, BUT I SMELLED LITTLE SMOKE COMING OUT. I PARKED THE CAR. THE FIRE STARTED FROM SOME CABLES AT THE LEFT SIDE COLUMN UNDER STEERING WHEEL IN FRONT OF DRIVER'S SEAT. THERE WAS NO COLLISION. SOME WIRES, PARTS AND THE PLASTIC COVER UNDER THE STEERING WHEEL HAVE BEEN BURNT DOWN. THE CAR WAS TOWED TO BILL LUKE SUZUKI IN TEMPE, AZ AT THE SAME DATE 5/29/2014. THE DEALER BILL LUKE ASKED ME TO REPORT THIS ISSUE TO SUZUKI. I CALLED SUZUKI CUSTOMER SERVICE IN CA ON 5/30/2014. ALREADY 2 WEEKS PAST, I HAVE NOT RECEIVED A RESPONSE FROM SUZUKI. SUZUKI HAS NOT TAKEN ANY ACTION. NOW THE CAR IS STILL IN BILL LUKE IN TEMPE. WOULD YOU PLEASE HELP ME? I APPRECIATE YOU VERY MUCH IF YOU CAN HELP. *TR
NHTSA ODI #10597730
Official recalls
4May 19, 2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
Aug 14, 2012
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Sep 25, 2007
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Jul 24, 2007
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE RELEASE BUTTON.
Consequence & remedy
Consequence: THESE BUCKLE MALFUNCTIONS, WHICH COULD PREVENT A PERSON FROM USING THE SEAT BELT OR COULD CAUSE THE SEAT BELT TO FAIL TO FUNCTION AS DESIGNED, CAN INCREASE THE RISK OF INJURY IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES WITH THE IMPROVED PART FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration