SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2014 Suzuki DL1000

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
8Owner complaints

Model-year median: 1

3Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
0
20114
20128
20140
20150
2016
Compare all DL1000 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Fuel/propulsion System
4Engine
3Electrical System
2Power Train
2Unknown Or Other
2
All reported categories
Fuel System, Gasoline
1Vehicle Speed Control
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 7 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel/propulsion System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Fuel/propulsion System complaints

4 reports
Clear category filter
12,000 miles · Apr 2, 2017
Fuel/propulsion System

THE MOTORCYCLE WILL STALL AT ODD INTERVALS. IT WILL ALSO BACKFIRE THRU THE AIRBOX. AT LOW SPEED, IT IS DIFFICULT TO CONTROL THE THROTTLE. IT IS ESPECIALLY BAD WHEN THE ENGINE HASN'T WARMED UP FULLY AND ITS COLD OUTSIDE. I HAVE COME VERY CLOSE TO DROPPING THE BIKE WHEN IT STALLS UNEXPECTEDLY. IT HAS STALLED SEVERAL TIMES AFT…

Read full complaint

THE MOTORCYCLE WILL STALL AT ODD INTERVALS. IT WILL ALSO BACKFIRE THRU THE AIRBOX. AT LOW SPEED, IT IS DIFFICULT TO CONTROL THE THROTTLE. IT IS ESPECIALLY BAD WHEN THE ENGINE HASN'T WARMED UP FULLY AND ITS COLD OUTSIDE. I HAVE COME VERY CLOSE TO DROPPING THE BIKE WHEN IT STALLS UNEXPECTEDLY. IT HAS STALLED SEVERAL TIMES AFTER ACCELERATING FROM A STOP. IT HAS ALSO STALLED SEVERAL TIMES WHEN HOT AND SLOWING DOWN ON THE HIGHWAY.

NHTSA ODI #10970035

500 miles · Feb 1, 2017
Fuel/propulsion System

ENGINE WOULD CUT OFF RANDOMLY, APPROXIMATELY ONCE EVERY 300 OR 400 MILES OF RIDING. ALWAYS WOULD START RIGHT BACK UP. ONLY HAPPENED TO ME WHILE NOT MOVING, BUT PROBABLY WOULDN'T NOTICE PROBLEM IF MOVING, UNLESS UNDER LOW POWER OR SLIPPING THE CLUTCH, IE, LOW SPEED MANEUVERING. SOMETIMES COLD ENGINE, SOMETIMES FULLY WARMED UP.…

Read full complaint

ENGINE WOULD CUT OFF RANDOMLY, APPROXIMATELY ONCE EVERY 300 OR 400 MILES OF RIDING. ALWAYS WOULD START RIGHT BACK UP. ONLY HAPPENED TO ME WHILE NOT MOVING, BUT PROBABLY WOULDN'T NOTICE PROBLEM IF MOVING, UNLESS UNDER LOW POWER OR SLIPPING THE CLUTCH, IE, LOW SPEED MANEUVERING. SOMETIMES COLD ENGINE, SOMETIMES FULLY WARMED UP. SUZUKI REPLACED ECU (WITH PART # ENDING IN ...J12) UNDER WARRANTY TO CORRECT THE PROBLEM. HAVE NOT HAD THAT PROBLEM SINCE, BUT NOW WHEN ENGINE IS WARMING UP AND DRIVING AWAY, ENGINE WILL "PUFF" WITH A BRIEF LOSS OF POWER, USUALLY WHILE TURNING OUT ONTO THE STREET. DOES NOT HAPPEN IF FULLY WARMED UP. *TR

NHTSA ODI #10948972

600 miles · Jan 15, 2017
EngineFuel/propulsion System

EVER SINCE THIS VEHICLE WAS PURCHASED AND THEN AFTER THE FIRST OIL CHANGE THE MOTOR DEVELOPED A KNOCK. THE FUELING IS ERRATIC AT TIMES MEANING IT HICCUPS OR SURGES AND HAS STALLED WHILE IN MOTION. I BROUGHT THIS UP TO THE DEALER AND TO SUZUKI IN NOVEMBER OF 2015. I ALSO FOUND ON A SUZUKI FORUM DEDICATED TO THIS PARTICULAR MODEL …

Read full complaint

EVER SINCE THIS VEHICLE WAS PURCHASED AND THEN AFTER THE FIRST OIL CHANGE THE MOTOR DEVELOPED A KNOCK. THE FUELING IS ERRATIC AT TIMES MEANING IT HICCUPS OR SURGES AND HAS STALLED WHILE IN MOTION. I BROUGHT THIS UP TO THE DEALER AND TO SUZUKI IN NOVEMBER OF 2015. I ALSO FOUND ON A SUZUKI FORUM DEDICATED TO THIS PARTICULAR MODEL THAT OTHERS WERE EXPERIENCING THE SAME ISSUES. I TOOK THE BIKE TO THE DEALER AND NOTHING WAS REMEDIED. I SPOKE WITH SUZUKI CORPORATE AND THEY ACKNOWLEDGED THAT SOME MODELS WERE EXPERIENCING A KNOCK DUE TO AN INTOLERANCE BUT THAT IT WOULDN'T AFFECT RELIABILITY. WHEN ASKED TO PUT IT IN WRITING THEY ACTUALLY SAID YES BUT THEN NEVER FOLLOWED THROUGH AND WOULDN'T RETURN ANY FURTHER CALLS FROM ME. I FOUND OUT IN EUROPE SUZUKI WAS REPLACING THE ECU ON ALL BIKES THAT WERE EXPERIENCING THIS. THEY HAVE DONE NOTHING TO FIX THIS VEHICLE. I GOT TO A POINT WHERE I HIRED A LAWYER TO TRY TO GET THE DEALER TO REPLACE BIKE AND THEIR RESPONSE WAS SUZUKI SAYS THERE IS NOTHING WRONG. NOW BECAUSE OF THAT I HAVE BEEN BLACKLISTED FROM OTHER DEALERS AND THEY WON'T WORK ON UNIT. I HAVE LOTS OF CORRESPONDENCE OVER THE LAST 14 MONTHS TRYING TO GET THIS RIGHTED AND NOW I AM LEFT TO TRY TO FIX THIS MYSELF. THERE ARE A PLETHORA OF OTHERS EXPERIENCING THESE SAME ISSUES AND GETTING THE SAME RESPONSE FROM SUZUKI, WHICH IS TO NOT DO ANYTHING TO HELP. WWW.STROMTROOPER.COM IS FULL OF FOLKS TALKING ABOUT THIS ECU ISSUE AND THE KNOCKING ISSUE. WHEN SUZUKI DID HAVE THE BIKE AND SAID THEY DID AN UPGRADE FIX THE BIKE WAS WORSE. THEY HAVE ALSO DELETED THE ECU REPLACEMENT PART TWICE SINCE 2014. IT HAS ONLY STALLED ON ME THREE TIMES IN 15 MONTHS BUT IT ONLY TAKES ONCE AT THE WRONG TIME AND SOMEONE MIGHT BE INJURED OR WORSE. I AM GOING TO TRY TO FIX THIS ON MY OWN BUT I SHOULDN'T HAVE TO. I THINK THEY HAVE THE BIKE SET TOO LEAN TO MEET US REQUIREMENTS AND IT IS A SAFETY ISSUE.

NHTSA ODI #10945402

2,000 miles · Nov 7, 2016
Fuel/propulsion SystemUnknown Or Other

MOTORCYCLE STALLS WHEN ENGAGING THROTTLE. THE MOTORCYCLE CAN BE IN NEUTRAL AND IT STILL STALLS ENGAGING THROTTLE. HAPPENED ~ 5 TIME WITHINT 2000 MILES. ITS A SAFETY CONCERN BECAUSE CARS BEHIND ME HAVE TO WAIT UNTIL I RESTART THE MOTORCYCLE. IT IS NOT A CLUTCH PROBLEM BECAUSE IT HAPPENS IN NEUTRAL ALSO.

NHTSA ODI #10924660

Official recalls

3

15V851000 · Electrical System:wiring

Dec 18, 2015

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL 1000 motorcycles manufactured January 17, 2014, to June 5, 2014, 2015 Suzuki DL1000 motorcycles manufactured November 4, 2014, to February 6, 2015 and 2016 Suzuki DL1000 motorcycles manufactured June 11, 2015, to July 15, 2015. The affected motorcycles have a wiring harness that may rub against the bottom of the fuel tank. Vibration from riding may cause the wiring insulation to wear off, allowing a bare wire to short circuit against the fuel tank.

Consequence & remedy

Consequence: A short circuit may cause the engine to stall, increasing the risk of a crash.

Remedy: Suzuki will notify owners, and dealers will inspect the motorcycles and reroute the wiring harnesses as necessary. Any damaged harnesses will be repaired or replaced. This work will be performed free of charge. The recall began on January 29, 2016. Owners may contact Suzuki customer service number at 1-714-572-1490. Suzuki's number for this recall is 2A53.

15V853000 · Electrical SYSTEM:12V/24V/48V Battery:cables

Dec 18, 2015

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL1000 motorcycles manufactured January 17, 2014 to June 5, 2014, and 2015 Suzuki DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. Due to corrosion or being attached to the painted engine case, the battery ground connection may have poor electrical conductivity.

Consequence & remedy

Consequence: As a result of the poor conductivity, the engine may stall and be unable to be restarted, increasing the risk of a crash.

Remedy: Suzuki will notify owners, and dealers will relocate the battery ground connection to an unpainted surface and replace the ground wire protector with a high-heat resistance tube, free of charge. The recall began on January 29, 2016. Owners may contact Suzuki customer service number at 1-714-996-7040. Suzuki's number for this recall is 2A53.

15V854000 · Electrical System:ignition

Dec 18, 2015

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 DL1000 motorcycles manufactured January 17, 2014, to June 5, 2014, and 2015 DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. The ignition switch terminals of the affected vehicles may corrode if they come into contact with liquid such as salt water. As a result, the motorcycle's electrical power may be disconnected or the switch may be bypassed, preventing the engine from being shut off with the ignition key.

Consequence & remedy

Consequence: If electrical power is lost, the engine would stall, increasing the risk of a crash.

Remedy: Suzuki will notify owners, and dealers will install a cover for the ignition switch connector, and any corroded ignition lead wire and wire harnesses will be replaced. These repairs will be performed free of charge. The recall began January 19, 2016. Owners may contact Suzuki customer service at 1-714-996-7040. Suzuki's number for this recall is 2A53.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE17001 · Motorcycle Stalling

Opened Mar 7, 2017 · Closed Nov 13, 2017

Status: closed (inferred from source dates) · Electrical System:ignition; Engine; Fuel System, Gasoline:delivery; Fuel System, Other:delivery; Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Additional source detail variants (7)

Electrical System:ignition

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Engine

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Fuel System, Gasoline:delivery

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Fuel System, Other:delivery

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Vehicle Speed Control:cables

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Vehicle Speed Control:linkages

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.

Vehicle Speed Control

On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority alleged a misfire or a loss in power at cruising speeds or going around a turn.These allegations were not consistent with the alleged defect of this investigation.Furthermore, ODI learned from 2 of the 3 complainants alleging a crash (dropped bike) that they had installed after market equipment on the motorcycle altering its performance and/or fueling strategy.On July 27th, 2017 Suzuki and ODI participated in a joint ride-evaluation of the subject motorcycles.Suzuki supplied ODI with a 2014 and 2015 D1000 motorcycle with original factory settings.ODI solicited assistance from the Virginia State Police (VSP) Division 7 Motor Squad to evaluate and ride the subject motorcycles at the Dulles Airport training grounds.VSP supplied ODI with 4 professional and experienced motorcycle riders.At the Dulles location, ODI created a repeatable test program that would best elicit the alleged defect.The test was a series of accelerating patterns through first gear into second at different distances.After a total of 5 hours of riding the VSP riders were unable to induce or duplicate the stalling condition (alleged defect).On August 9th 2017 Suzuki met with ODI to discuss the investigation, the merits of the complainants, and give a presentation concerning the chronology of design changes associated with the subject vehicles.As a result of the July 27th ride evaluation, the August 9th joint meeting, and investigative interviews, ODI has concluded the alleged defect of this investigation does not present an unreasonable risk to motor vehicle safety at this time.In addition, Suzuki has agreed to provide its customers with an updated engine control module (ECM) via a service campaign TLSVDL 066 (ODI 10119582) incorporating the latest engine software.ODI is closing this PE as further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency reserves the right to take further action if warranted by the circumstances.