NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
427 reports45,000 miles · Feb 13, 2007
Fuel System, Gasoline
2002 SUBARU WRX SPORT WAGON (1) IN VERY COLD WEATHER, (2) SMELL OF RAW GAS FUMES ENTERS PASSENGER COMPARTMENT, CAUSING POTENTIAL ENVIRONMENTAL, SAFETY AND HEALTH HAZARD. (3) SITUATION IS COVERED BY 2003 SUBARU TECHNICAL SERVICE BULLETIN 09-36-03. DEALERS REFUSE TO COVER COST OF THIS SAFETY-RELATED PRE-EXISTING DEFECT. NOT …
Read full complaint
2002 SUBARU WRX SPORT WAGON (1) IN VERY COLD WEATHER, (2) SMELL OF RAW GAS FUMES ENTERS PASSENGER COMPARTMENT, CAUSING POTENTIAL ENVIRONMENTAL, SAFETY AND HEALTH HAZARD. (3) SITUATION IS COVERED BY 2003 SUBARU TECHNICAL SERVICE BULLETIN 09-36-03. DEALERS REFUSE TO COVER COST OF THIS SAFETY-RELATED PRE-EXISTING DEFECT. NOT YET REPAIRED. *JB
NHTSA ODI #10182449
Mileage unknown · Feb 12, 2007
Fuel System, Gasoline
DURING THE COLD PERIOD LAST WEEK, MY 2002 SUBARU IMPREZA WRX HAD A VERY STRONG SMELL OF RAW GAS. SUBARU HAS ISSUED A TSB # 09-36-03 DATED 4/01/03 ACKNOWLEDGING THE PROBLEM AND HAS A REPAIR KIT SPECIFICALLY DESIGNED TO FIX THE PROBLEM. THIS PROBLEM SHOULD RESULT IN A RECALL BY SUBARU AND BE REPAIRED AT SUBARU'S EXPENSE. IT IS A …
Read full complaint
DURING THE COLD PERIOD LAST WEEK, MY 2002 SUBARU IMPREZA WRX HAD A VERY STRONG SMELL OF RAW GAS. SUBARU HAS ISSUED A TSB # 09-36-03 DATED 4/01/03 ACKNOWLEDGING THE PROBLEM AND HAS A REPAIR KIT SPECIFICALLY DESIGNED TO FIX THE PROBLEM. THIS PROBLEM SHOULD RESULT IN A RECALL BY SUBARU AND BE REPAIRED AT SUBARU'S EXPENSE. IT IS A POTENTIAL EXPLOSIVE/FIRE EVENT AND IS A FAULT IN THE ORIGINAL DESIGN. THE DEALERS WILL NOT FIX THIS PROBLEM WITHOUT CHARGING THE CUSTOMERS. THE REPAIR KIT IS ABOUT $60 BUT LABOR IS $700-800. ITS A SAFETY ISSUE AND I'M AFRAID TO DRIVE IT LIKE IT IS. *JB
NHTSA ODI #10182414
118,900 miles · Feb 12, 2007
Fuel System, Gasoline
FAILURE: GASOLINE LEAK ONTO HOT ENGINE, STRONG SMELL OF RAW FUEL IN CABIN. THIS FAILURE, THE EVENTS LEADING TO IT (COLD WEATHER), AND THE CONSEQUENCES ARE DESCRIBED IN SUBARU'S TSB #09-36-03 FROM 04-01-03. IN MY CASE, MY WIFE AND I WERE DRIVING AROUND LAST MONDAY, 2-5-07, WHEN IT WAS VERY COLD -- MAYBE 6 OR 7 DEGREES WITH A ST…
Read full complaint
FAILURE: GASOLINE LEAK ONTO HOT ENGINE, STRONG SMELL OF RAW FUEL IN CABIN. THIS FAILURE, THE EVENTS LEADING TO IT (COLD WEATHER), AND THE CONSEQUENCES ARE DESCRIBED IN SUBARU'S TSB #09-36-03 FROM 04-01-03. IN MY CASE, MY WIFE AND I WERE DRIVING AROUND LAST MONDAY, 2-5-07, WHEN IT WAS VERY COLD -- MAYBE 6 OR 7 DEGREES WITH A STRONG WIND. WE BEGAN TO SMELL RAW FUEL IN THE CAR AFTER LEAVING A RESTAURANT. THE SMELL GOT WORSE AS WE DROVE TO A GROCERY STORE. WHEN I OPENED THE HOOD I COULD HEAR A HISSING SOUND AND SEE FUEL VAPOR (LIKE STEAM) COMING FROM UNDER THE INTAKE MANIFOLD ON THE PASSENGER SIDE. SINCE THE WEATHER HAS GOTTEN A BIT WARMER IT DOESN'T SEEM TO BE A PROBLEM. THE CAR IS A 2002 WRX SEDAN. AT THIS TIME, IT IS SITTING AT SHARRETT SUBARU IN HAGERSTOWN, MD. NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM BECAUSE SUBARU OF AMERICA (SOA) IS REFUSING TO COVER 100% OF THE REPAIR COST (WHICH THEY HAVE, RECENTLY, FOR OTHER PEOPLE WITH THE SAME VEHICLE AND SIMILAR MILEAGE). THIS IS A KNOWN PROBLEM. IT SHOULD CLEARLY BE THE SUBJECT OF A RECALL. *NM
NHTSA ODI #10182330
63,000 miles · Feb 10, 2007
Fuel System, Gasoline
1) STRONG ODOR OF GASOLINE NOTICED IN ENGINE COMPARTMENT AND INTERIOR. 2) SUBARU DEALER DETERMINED FUEL LINES WERE LEAKING UNDER INTAKE MANIFOLD. LEAKING FUEL IN AN ENGINE COMPARTMENT IS ALWAYS AN EXTREME FIRE RISK. THE WRX HAS THREE POSSIBLE IGNITION SOURCES UNDERHOOD, TURBOCHARGER HOUSING, EXHAUST MANIFOLD AND CATALYTIC CON…
Read full complaint
1) STRONG ODOR OF GASOLINE NOTICED IN ENGINE COMPARTMENT AND INTERIOR. 2) SUBARU DEALER DETERMINED FUEL LINES WERE LEAKING UNDER INTAKE MANIFOLD. LEAKING FUEL IN AN ENGINE COMPARTMENT IS ALWAYS AN EXTREME FIRE RISK. THE WRX HAS THREE POSSIBLE IGNITION SOURCES UNDERHOOD, TURBOCHARGER HOUSING, EXHAUST MANIFOLD AND CATALYTIC CONVERTER, ALL OF WHICH ARE IN CLOSE PROXIMITY TO THE LEAK LOCATION. 3) FUEL LINES REPAIRED PER SUBARU TSB 09-36-03 AT CUSTOMER EXPENSE. *NM
NHTSA ODI #10182192
59,000 miles · Feb 8, 2007
Fuel System, Gasoline
MY 2002 SUBARU WRX SUFFERED THE COLD START FUEL LEAK PROBLEM DESCRIBED IN THE TSB (FUEL RAILS). VEHICLE WAS PURCHASED USED FROM DEALERSHIP, BUT DEALER DID NOT ADDRESS THE PROBLEM WHILE VEHICLE WAS STILL UNDER WARRANTY. *NM
NHTSA ODI #10181956
62,367 miles · Feb 5, 2007
Fuel System, Gasoline
SEVERE FUEL SMELL IN AND AROUND VEHICLE WHEN TEMPERATURE IS BELOW 30 DEGREES FAHRENHEIT. NOT A SAFE SITUATION AS I NEED TO HEAT THE CAR UP TO BRING MY INFANT TO DAYCARE. POSSIBLE DETRIMENTAL EFFECTS TO INFANT'S RESPIRATORY SYSTEM AS WELL. THIS OF COURSE DOES NOT EXCLUDE THE POSSIBILITY OF FIRE OR EXPLOSION. *JB
NHTSA ODI #10181582
99,000 miles · Jan 26, 2007
Fuel System, Gasoline
I LIVE IN MAINE AND IN COLD WEATHER MY MY 2002 SUBARU IMPREZA WRX LEAKS FUEL FROM A FUEL LINE ON THE PASSENGER SIDE OF THE VEHICLE. SUBARU OF AMERICA HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THIS PROBLEM. *JB
NHTSA ODI #10180797
25,000 miles · Jan 26, 2007
Fuel System, Gasoline
TL* - THE CONTACT STATED THAT THERE WAS SERVICE BULLETIN 09-36-03 ON THE 2002 SUBARU WRX REGARDING A FUEL SMELL IN COLD WEATHER. THE FAILURE, WHICH WAS ACTUALLY A LEAK IN COLD WEATHER APPEARED WHEN THE TEMPERATURE GOT TO BE 10 DEGREES OR LESS. THERE WAS A STRONG SMELL OF FUEL IN THE PASSENGER COMPARTMENT, AND THE CONTAC…
Read full complaint
TL* - THE CONTACT STATED THAT THERE WAS SERVICE BULLETIN 09-36-03 ON THE 2002 SUBARU WRX REGARDING A FUEL SMELL IN COLD WEATHER. THE FAILURE, WHICH WAS ACTUALLY A LEAK IN COLD WEATHER APPEARED WHEN THE TEMPERATURE GOT TO BE 10 DEGREES OR LESS. THERE WAS A STRONG SMELL OF FUEL IN THE PASSENGER COMPARTMENT, AND THE CONTACT FOUND A FUEL LEAK WHICH DRIPPED ONCE A SECOND ON 1/24/07. THE FAILURE WAS CAUSED BY A MISALIGNMENT BETWEEN TWO FUEL HOSES NEAR THE MANIFOLD. THE CONTACT WILL HAVE PICTURES AVAILABLE. THE FAILURE MILEAGE WAS 25000 AND THE CURRENT MILEAGE WAS 50000.*AK
NHTSA ODI #10180778
Mileage unknown · Jan 24, 2007
Fuel System, Gasoline
RECENTLY LOW TEMPERATURES IN MY AREA DROPPED TO 32 DEGREES BELOW ZERO AND LOWER. WHEN STARTING MY VEHICLE IN THE MORNING, I SMELLED A STRONG FUEL ODOR THAT CAME FROM THE ENGINE COMPARTMENT AS IF THERE WAS A FUEL LEAK. AFTER RUNNING THE VEHICLE FOR A PERIOD, THE GAS SMELL WENT AWAY. THIS HAPPENED ON THREE SEPARATE OCCASIONS. …
Read full complaint
RECENTLY LOW TEMPERATURES IN MY AREA DROPPED TO 32 DEGREES BELOW ZERO AND LOWER. WHEN STARTING MY VEHICLE IN THE MORNING, I SMELLED A STRONG FUEL ODOR THAT CAME FROM THE ENGINE COMPARTMENT AS IF THERE WAS A FUEL LEAK. AFTER RUNNING THE VEHICLE FOR A PERIOD, THE GAS SMELL WENT AWAY. THIS HAPPENED ON THREE SEPARATE OCCASIONS. I TOOK THE VEHICLE INTO THE LOCAL SUBARU DEALERSHIP FOR REPAIRS. REPAIRS ARE EXPECTED TO BE COMPLETED BY JANUARY 26, 2007. *NM
NHTSA ODI #10180663
92,500 miles · Jan 20, 2007
Fuel System, Gasoline
SUBARU 2002 IMPREZA WRX WAGON RAW FUEL SMELL IN CABIN ON COLD DAYS BELOW 0 DEG F. TSB # 09-36-03 ISSUED ON THIS 4/1/03 FOR ALL ENGINE #'S PRIOR TO 673467 WHEN THEY CHANGED FUEL PIPE AND HOSE SIZES UNDER THE INTAKE MANIFOLD FOR THE 03 WRX'S. POOLING FUEL ON THE ENGINE BLOCK IS A SAFETY HAZARD AND THIS SHOULD BE CONSIDERED A RE…
Read full complaint
SUBARU 2002 IMPREZA WRX WAGON RAW FUEL SMELL IN CABIN ON COLD DAYS BELOW 0 DEG F. TSB # 09-36-03 ISSUED ON THIS 4/1/03 FOR ALL ENGINE #'S PRIOR TO 673467 WHEN THEY CHANGED FUEL PIPE AND HOSE SIZES UNDER THE INTAKE MANIFOLD FOR THE 03 WRX'S. POOLING FUEL ON THE ENGINE BLOCK IS A SAFETY HAZARD AND THIS SHOULD BE CONSIDERED A RECALL. DEALER COST TO GET THIS FIXED IS ANYWHERE BETWEEN $350 -$500. SOA SHOULD BE HELD ACCOUNTABLE FOR THIS FIX BEFORE ENGINE FIRE OCCURS. *JB
NHTSA ODI #10179217
Official recalls
1Dec 4, 2009
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002 AND 2003 IMPREZA WRX VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF SOUTH DAKOTA, NEBRASKA, NORTH DAKOTA, MINNESOTA, IDAHO, IOWA, MONTANA, COLORADO, WISCONSIN, NEW YORK, WYOMING, MICHIGAN, ALASKA, NEW HAMPSHIRE, VERMONT, AND MAINE. DURING COLD STARTS, TYPICALLY UNDER EXTREMELY COLD TEMPERATURES, FUEL LEAKS IN THE FUEL DELIVERY LINE COULD OCCUR WHERE THE LINE CONNECTS WITH A RUBBER HOSE.
Consequence & remedy
Consequence: FUEL LEAKS, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL LINE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 31, 2009. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA09011 · Fuel Line Leak
Opened Jul 2, 2009 · Closed Dec 14, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE DESIGN OF THE FUEL LINE (METAL RAIL/RUBBER HOSE INTERFACE) IS SUSCEPTIBLE TO FUEL ODOR AND/OR SEEPAGE IN EXTREME COLD TEMPERATURE CONDITIONS.OWNERS MOST OFTEN NOTICED FUEL ODOR IN THE OCCUPANT COMPARTMENT AREA DURING INITIAL COLD ENGINE START-UP.ONCE THE ENGINE IS WARMED, THE ODOR/SEEPAGE ISSUE DISSIPATES.FROM SUBARU'S DATA, ODI NOTES THAT THE INCIDENT RATES ARE HIGHER IN STATES WITH COLDER TEMPERATURES.THERE WAS ONE ALLEGATION OF A FIRE INCIDENT IN WHICH THE OWNER HAD REPORTED THAT HE NOTICED FUEL ODOR A FEW DAYS EARLIER, BUT ODI COULD NOT CONFIRM THE ORIGIN OF THE FIRE. TO ADDRESS THIS ISSUE, SUBARU WILL REPLACE THE FUEL LINE WITH A LONGER RUBBER HOSE SEGMENT VERSION/DESIGN ON 5,724 MY 2002-2003 VEHICLES BUILT THROUGH SEPTEMBER 12, 2002 IN 16 STATES (AK, CO, IA, ID, ME, MI, MN, MT, ND, NE, NH, NY, SD, VT, WI & WY).IN ADDITION, SUBARU WILL EXTEND THE WARRANTY COVERAGE TO 12 YEARS/UNLIMITED MILEAGE ON VEHICLES IN THE REMAINING 34 STATES.THIS ENGINEERING ANALYSIS IS CLOSED (SEE RECALL CAMPAIGN 09V-468)
PE09017 · Fuel Line Leak
Opened Mar 10, 2009 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:carburetor System; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Other; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Additional source detail variants (11)
Fuel System, Gasoline:carburetor System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery:fuel Pump
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:delivery
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:injectors
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Gasoline
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other:fuel Injection System
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
Fuel System, Other
COMPLAINANTS REPORT FUEL LEAKAGE MOST FREQUENTLY IN WINTER DURING INITIAL COLD ENGINE STARTUP.OWNERS WILL EITHER NOTICE A FUEL ODOR INSIDE THE OCCUPANT COMPARTMENT OR FUEL ODOR/LEAKAGE AT THE FUEL LINES ON THE RIGHT SIDE ATOP THE ENGINE. ONCE THE ENGINE HAS WARMED, THE ODOR/LEAKAGE MAY CEASE.SUBARU REVISED THE FUEL PIPE/HOSE DESIGN FOR MODEL YEAR (MY) 2003-04 WRX VEHICLES PRODUCED AFTER AUGUST 2003.SUBARU ALSO INTRODUCED A MY 2004 IMPREZA STI VEHICLE WITH A DIFFERENT ENGINE AND FUEL PIPE/HOSE LAYOUT.OUT OF THE TOTAL OF 994 COMPLAINTS, 944 CONCERN MY 2002-03 WRX VEHICLES BUILT THROUGH AUGUST 2003.SUBARU ALSO REPORTS ONE FIRE ON A MY 2002 WRX VEHICLE THAT OCCURRED IN FEBRUARY 2006.IN MARCH 2009, ODI INSPECTED AND VIDEO TAPED A MY 2002 WRX VEHICLE WITH A FUEL LEAK DURING COLD ENGINE START UP.THE VIDEO WAS PROVIDED TO SUBARU AND IS IN THE INVESTIGATION FILE. THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA09-011) TO FURTHER STUDY THIS ISSUE.
PE04002 · Fuel Line Leakage In Engine Compartment
Opened Jan 7, 2004 · Closed May 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Gasoline
SUBARU REPORTS THAT THE FUEL ODOR IS CAUSED BY FUEL SEEPAGE DURING COLD START OF THE ENGINE UNDER EXTREMELY COLD TEMPERATURES. THE LEAK OCCURS IN A FUEL LINE IN THE ENGINE COMPARTMENT.IT REPORTS THAT THE FAILURE IS DUE TO THE MISALIGNED ANGLE BETWEEN TWO FUEL DELIVERY LINES WHICH RESULTED IN SUCH FUEL SEEPAGE DURING THE FIRST FEW SECONDS OF COLD ENGINE START DURING THESE COLD TEMPERATURES.SUBARU REPORTS THAT THE TWO FUEL LINES ARE CONNECTED WITH A HOSE THAT BECOMES TOO STIFF IN VERY COLD TEMPERATURES TO CONFORM TO THE MISALIGNMENT. SUBARU HAS ISSUED A TECHNICAL SERVICE BULLETIN (SUBARU SERVICE BULLETIN NUMBER 09-36-03) TO REPLACE THE FUEL LINES WITH NEW LINES THAT ARE PROPERLY ALIGNED AND THAT HAVE A LONGER CONNECTING HOSE.ODI PHONE CALLS TO MANY OF THE COMPLAINANTS CONFIRM THAT FUEL ODOR IS NOTICABLE DURING VERY COLD TEMPERATURES AND COLD START BUT GOES AWAY AS THE ENGINE WARMS UP, AND THE ODOR IS NOT PRESENT IN WARMER TEMPERATURES. A FEW OWNERS REPORT THAT ATTEMPTS TO ELIMINATE THE LEAKAGE BY TIGHTENING THE CONNECTING HOSE CLAMPS IS NOT EFFECTIVE IN ELIMINATING THE FUEL ODOR.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03024 · Extended Stopping Distances
Opened Nov 19, 2003 · Closed Jul 12, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
DURING THE EA, ODI AND VRTC PERFORMED THE FOLLOWING ACTIVITIES:1.CONDUCTED A MAIL SURVEY OF 246 SUBJECT VEHICLE OWNERS TODETERMINE THE ROADWAY SURFACE THAT CAUSED OWNERS' CONCERN;2.INTERVIEWED COMPLAINING OWNERS;3.CONDUCTED FIELD INSPECTIONS OF SEVEN (7) COMPLAINT VEHICLES;4.INSTRUMENTED TESTING AT VRTC OF COMPLAINT AND PEER VEHICLES;5.REVIEWED SUBARU'S RESPONSE TO OUR INFORMATION REQUEST;6.MET WITH SUBARU FOR TECHNICAL REVIEW OF TESTINGAS A RESULT OF THE WORK CONDUCTED BY VRTC AND ODI DURING THIS INVESTIGAITON, A CONSISTENT OR CHRONIC PATTERN OF POOR BRAKE PERFORMANCE HAS NOT BEEN IDENTIFIED.VRTC CONDUCTED OVER 11,500 BRAKE TESTS.THEY DID NOT OBSERVE ANY LONG-DURATION, LOW DECELERATION EVENTS (SOME OWNERS REPORTED DELAYS OF 4 TO 10 SECONDS) IN THE TEST VEHICLES.SEE ODI'S CLOSING REPORT AND VRTC'S TEST REPORT FOR FULL DETAILS
PE03029 · Braking System/abs
Opened Jul 8, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
SUBARU'S SUPPLEMENTAL RESPONSE OF SEPTEMBER 29, 2003, IDENTIFIED THAT THE 2002, 2003 SUBARU WRX MODELS AREEQUIPPED WITH THE BOSCH 5.3 ABS SYSTEM, AND IDENTIFIED THAT OTHER MODEL SUBARU VEHICLES ARE ALSO EQUIPPED WITH THE BOSCH 5.3 ABS SYSTEM, BUT HAVE DIFFERENT CALIBRATIONS THAN THE WRX MODEL VEHICLES.SUBARU IDENTIFIED THAT CHANGES WERE MADE IN THE ABS ECU TO ADDRESS A CALIBRATION LOGIC ISSUE WHEN DRIVING THE VEHICLE WITH THE SPARE TIRE MOUNTED.SUBARU REPORTED THAT BOTH THE ABS HYDRAULIC UNIT AND THE ABS ECU WERE MODIFIED, AND GAVE VIN NUMBERS TO IDENTIFY THE IMPLEMENTATION OF THE MODIFIED UNITS IN PRODUCTION. TESTING IS UNDERWAY TO GAIN AN UNDERSTANDING OF THE WRX VEHICLE PERFORMANCE DURING AN ABS ACTIVATION.FUTHER, ANALYSIS OFTHE DIFFERENCES IN VEHICLE PERFORMANCE RESULTING FROM ABS SOFTWARE CHANGES WILL BE EXAMINED.
Illustration