2025 Subaru Outback

NHTSA Complaint Narrative — Draft On July 9, 2026, in the evening, my leased 2026 Subaru Outback Touring caught fire while we were driving home. We were stopped in a left-turn lane waiting on a left-turn signal. When the light turned, the vehicle in front of us moved forward — which, in hindsight, was fortunate, because molten metal was sprayed across that exact spot moments later. The engine effectively exploded, throwing molten metal from the melted hood and engine components into the air around the car. We exited the vehicle immediately, leaving it burning in the left-turn lane. The fire department, based only about half a mile away, arrived within approximately 4 minutes, but it still took them roughly 35 minutes to fully extinguish the fire given its intensity. The vehicle had just been returned that day (or very recently) from a 3.5-week internal engine repair at the dealership. This was the third time I had reported the same underlying engine problem to Subaru — the recent lengthy repair was the first real attempt by the dealer to address it, and it failed within days of the vehicle being returned to me. My spouse and I were in the car moments before the explosion. Had we been delayed even briefly — for example, had the car ahead of us not moved forward when it did — we believe we could have been seriously injured or killed by the explosion and flying molten debris. The vehicle was a total loss. I am filing this complaint because: This was the third report of the same engine issue prior to the fire, indicating a recurring, unresolved defect rather than an isolated incident. The failure occurred immediately after a dealership repair specifically intended to fix this problem, suggesting the underlying defect was not — or could not be — properly corrected. The nature of the failure (explosive engine fire while driving, throwing molten metal across an active traffic lane) presents a serious risk of injury or death to occupants, other drivers, and bystanders

I just bought my Subaru outback brand new in October 2025. I’ve maintained my oil changes at the dealership. I bought it from in the last one was last may 26. I filled up my tank with a full tank of gas June 1. On June 2 when I was driving home from work on the I 94 Highway in Detroit Michigan I was going about 50 mph when my check engine light went on and within seconds the engine failed. The car was still on, but the gas pedal wouldn’t work and I was in the far left-hand side lane of the highway. I was able to slowly pull over to the fire right hand shoulder, even though it was during peak traffic time. As I pulled over, I started seeing smoke come from under the hood. I then seen a big flame which made me quickly get out of the vehicle and then seconds two minutes later the entire vehicle was in golf in flames and had many explosions throughout. I had no prior indications notifying me that there was something wrong with my vehicle. I had no problems with it. There was only 12,500 miles on the vehicle. There was no obvious cause to this happening. It was only me in the car however if there were small children in car seats or less mobile elderly people in the car, I don’t think that they would have made it out safely. The fire department came and put out the fire. A police report was made with the Michigan State troopers. My insurance is progressing. They are working on a claim. I also contacted Subaru of America and opened up a case with them. I notified the Subaru of Troy dealership that this happened.