2025 Subaru Outback

The contact owns a 2025 Subaru Outback. The contact stated that the vehicle failed to start while attempting to start it. There were no warning lights illuminated. A tow truck company successfully jump-started the vehicle, and the vehicle was towed to the local dealer. The dealer was unable to duplicate the failure. The contact returned to retrieve the vehicle, and the key fob failed to operate, and the vehicle failed to start. The dealer provided a loaner vehicle. There was no indication that the battery had failed; however, the dealer replaced the battery. The dealer had not yet determined the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 10,000.

I just bought my Subaru outback brand new in October 2025. I’ve maintained my oil changes at the dealership. I bought it from in the last one was last may 26. I filled up my tank with a full tank of gas June 1. On June 2 when I was driving home from work on the I 94 Highway in Detroit Michigan I was going about 50 mph when my check engine light went on and within seconds the engine failed. The car was still on, but the gas pedal wouldn’t work and I was in the far left-hand side lane of the highway. I was able to slowly pull over to the fire right hand shoulder, even though it was during peak traffic time. As I pulled over, I started seeing smoke come from under the hood. I then seen a big flame which made me quickly get out of the vehicle and then seconds two minutes later the entire vehicle was in golf in flames and had many explosions throughout. I had no prior indications notifying me that there was something wrong with my vehicle. I had no problems with it. There was only 12,500 miles on the vehicle. There was no obvious cause to this happening. It was only me in the car however if there were small children in car seats or less mobile elderly people in the car, I don’t think that they would have made it out safely. The fire department came and put out the fire. A police report was made with the Michigan State troopers. My insurance is progressing. They are working on a claim. I also contacted Subaru of America and opened up a case with them. I notified the Subaru of Troy dealership that this happened.

April 3, 2026: my 2025 Subaru Outback Premium (VIN [XXX] , 2,052 miles) suffered simultaneous failure of multiple safety-critical systems due to corrosion on a CAN bus pin in the driver door wiring harness (Subaru part #XXX) at its dash harness connection, caused by water intrusion into the cabin. Trip start: EyeSight, collision avoidance, blind spot, and lane assist all offline; BRAKE indicator illuminated with no brake engagement. Minutes later, airbag warning activated. Dealer service advisor described the dash as "lit up like a Christmas tree." While reversing through a 3-point turn on a commercial drive used by heavy trucks, I LOST STEERING at single-digit speed. 60 seconds further would have placed me on an inclined high-traffic road near a freeway interchange. Vehicle was towed by Subaru from the failure location. Confirmed by authorized dealer Driveway Subaru of Moon Township (Invoice #680646, warranty claim). Subaru SSM4 scan recorded 17 unique DTCs across 10 control systems, including C1460 Brake Booster Abnormality; U1131 Lost Comm Power Steering Control Module; U0151 Restraints Control Module; U0122/U1122 VDC; U0126 Steering Angle Sensor; plus multiple EyeSight faults. Dealer documented moisture on both A-pillars, driver kick panel, standing water in cupholders and center console. Prior intermittent symptom: passenger seatbelt alarm on empty seat, two occasions in prior months, consistent with past-status U0151 on scan. Dealer cleaned the corroded pin but did NOT identify or seal the original water ingress point. Vehicle remains in dealer possession. Subaru of America Customer Advocacy Case #XXX-XXXhas declined repurchase/replacement, stating vehicle is "operating safely as designed." I dispute this conclusion: the ingress source is unremediated and recurrence risk has not been addressed. Repair invoice, full DTC scan, SOA correspondence, and owner statement available on request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2025 Subaru Outback onyx edition purchased 3/2025. Approximate mileage at time of incident 7000. On 2/10/25 around 6am car is remotely started with Subaru app from iPhone on flat gravel surface. Car was in park. Go out car not there moved almost a car length down a hill left turn then over an embankment into a ditch where it finally rested still running in park when found it. Why or how is this possible when done this before no issues. Took to dealership checked visible damage snapped bumper back in get hood and grill shutters checked by body shop. Stating no malfunction and said safe to drive until we did that. One week later the car is started and all sorts of lights appear on dash took back to dealer additional problems found in front end and underneath. Told us we could still continue to drive it with lower core support damaged. Why did lights come on week later no airbags deployed when hit ditch. No notification or contact on app when crash happened and how was the steering affected when vehicle was in park. So many questions no definite answers yet? Definitely a major safety concern. Left with new vehicle damage at this mileage and we feel we are not at fault

While driving, the head unit, which gives you access to many of the safety features like auto braking etc, blanks out and goes completely dark. It happens without notice and is random in nature. On this particular vehicle it has happened at least four times. It does come back on but it is not immediate and the amount of time that it is out is variable. This can happen regardless of where you are driving and is very concerning because when the head unit is dark and not working you lose control over a lot of the important functions in the vehicle and it makes you doubt whether those systems are working properly.

I am submitting a safety complaint regarding my Subaru vehicle’s infotainment system. The system displays unsolicited, full-screen SiriusXM promotional pop-ups while the vehicle is in motion. These ads override the current display without warning. Most recently, a SiriusXM trial offer appeared and took over my entire screen while I was driving over 60 mph on the highway at night. The sudden change in brightness and the complete obstruction of the display were extremely distracting. It required my attention to dismiss, creating a dangerous situation at high speed. This is not a one-time occurrence. These ads have appeared multiple times, and I have no option to permanently disable them. I did not consent to advertising in my vehicle, much less advertising that interrupts the display while driving. A vehicle’s infotainment system should never display promotional content that interferes with safe operation, especially while in motion. This behavior poses a clear distraction risk and compromises driver safety. I am requesting that the NHTSA investigate this issue, as manufacturers should not be pushing advertisements that override critical vehicle interfaces during active driving. Thank you for your attention to this matter.