2022 Subaru Outback

My front windshield has cracked twice in the span of 2 years. August 2023 and recently Feb 2025. Bought the car from a legitimate dealer in 2022. Both times there was no hard impact, no obvious damage (initially), the cracks also spread very quickly once the damage is obvious. The repairs each time is not covered, not covered by insurance, $1400+ each time.

Winsdshield cracking and breaking easily. Windshield was replaced in 2023 due to a crack that spread over the whole windshield after being hit with road debris Again this weekend the windshield was hit with road debris and has a size able crack which requires a full windshield replacement. 2 windshields in 3 years of owning the vehicle feels like a defect in the quality and safety of the glass Replacement windshield in 2023 was from the Subaru manufacturer and installed by the dealership

The Thermo control valve on the vehicle failed. This has been such a consistent problem, that Subaru has extended the warranty for this item to 150K miles. I realize that alone is not a safety problem, but the issue is that when there is a check engine light error, the system shuts down the cruise control, lane departure, collision avoidance (EyeSIGHT), and XMODE (all wheel drive). The safety issue is shutting down these unconnected safety features because of a check engine light. I will say that the dealer promptly fixed the problem at no charge under the extended warranty. my concern was the loss of the 4 wheel drive right as major snow was hitting the Mid Atlantic Area.

The touchscreen shuts down and makes the safety features shut off. This use to happen a few times per quarter, but now is happening a few times per month. Happens always while driving which causes the adaptive cruise to shut off, causing deceleration, the eyesight shuts off, the controls on the keyboard are not available. It takes a minute or two for the screen to reboot and safety features to re-engage, this causes distraction and possible safety hazard. Additionally, the speakers randomly will blast so loud it startles and distracts everyone in the car. This seems to happen randomly, can be at start up, or after sound system has been in use. Additionally, the power windows occasionally will not go back up. Thry reverse partway through raising. Then we have to wait a few seconds and try again. Please make Subaru issue a recall and remedy for-the control screen issue. It is the most dangerous problem we’ve listed here.

Automatic auto off-on began to fail and car didn't start well. I began to disable the automatic auto on off while driving because it began to sound like it would stall out while stopped at a traffic light . Then I forgot to disable the automatic auto off on and car stalled out while stopped at a traffic light. I took it to dealer, Rafferty Subaru, they couldn't find anything wrong with it. Then a few days later check engine light and other icons started flashing on dashboard. I took it to dealer, they said the gas cap was off. For the next week the automatic auto off on sounded like it would fail so I disabled it, the car didn't start normally every morning, and it began to feel like it didn't shift correctly as I accelerated or slowed down. About one day later it suddenly lurched to almost a stop while driving, check engine light was flashing, other icons on dashboard were flashing, the Park Brake icon started flashing. The engine continued to run but I couldn't go more than 2 mph. I put it in park and it started to smell like something was burning so I turned it off. I had to have it towed to the dealer, Rafferty Subaru.

My EyeSight device stopped working correctly when I had the interior cleaned and the front windshield was spray cleaned. "Obstacle Detected" warnings started popping up and slowing down the car. Per the dealership, this was caused by the backsplash from the cleaner and now the entire device has to be replaced at a cost of $3300. Subaru later offered to replace it for $1800. I wish I was told to only spray the cleaner on a cloth or this could happen. Now I have to replace it or it could suddenly stop the car on the highway.

Was just driving when I noticed my car was sounding louder than usual. Then when I stared it after running some errands it sounds like a bad engine nock. So I took it in for an oil change and they told me it was a cracked exhaust manifold. Also told me it fine to drive and shouldn’t cause further problems. Then I started to smell heavy exhaust smells inside the cab of the car. Now I have to drive it with windows down or risk passing out or dying

I live in New Jersey, I am leasing this vehicle and I have 9 more months to go for the 3 year lease to be over. I am planning to purchase the vehicle after the 3 years. On [XXX] my fiancé and I drove from New Jersey to Ohio and stood at my boyfriend's grandparent's home for 4 days. While being there we had not used the car for 2 days and it was parked at the family members drive way be we were using the grandfather's vehicle since he was showing us around. On [XXX], we were planning to go out and get some ice cream. As we walk to our car the windshield is cracked from the corner of the passenger side to almost the driver's side. We were not sure what to do, we call Subaru and the nearest Subaru was 1 1/2 away from where we were. We decided to go back home with the cracked glass and take it to a nearby dealer 9 hours away. We stood in a hotel half of the way and we didn't drive over 55 miles per hour because we were afraid to go any faster with a cracked windshield. We took our car dealer here in NJ on August 7th, they took at the vehicle, took pictures and they told us, they would probably get approval to replace it under warranty but that it would need approval. They informed us that the vehicle did not have any signs of being in an accidents or that the crack did not show any signs of the windshield being hit to by anything to cause the crack. As of now, August 19, 2024 we are still waiting for approval. I need my vehicle repaired by September, since I work as an elementary teacher. I also feel, this incidence should be placed under a recall for this vehicle. It is very dangerous and could have caused major injury or even death to ourselves. Based on research I have done this incidence has happen to many people owning the Subaru Outback. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had my car parked at my boyfriend's grandfather house in Ohio on Sunday, August 3 and 4 without using the car for 2 days. Today Sunday, August 4 at around 5PM, my boyfriend and I went to our car, because we were planning to go out for ice cream. When we notice a long crack on our windshield. The windshield is cracked and nothing hit it, the cracked extends from the passenger side of the of the corner side all the way to almost the side of the driver side. I read that this has been a problem with many Subarus. I would not have leased this vehicle if I knew this was an issue. It should be identified as a recall. Since I am away from home (New Jersey) and far away from a Subaru dealer, I have to get this windshield repair to get back home. I am going through my insurance to repair it. Please help me in getting to know what to do to get a refund of my deductible. Thank you.