2020 Subaru Outback

I noticed a crack in my front windshield for no reason, it looked like it had come up from under the hood on the drivers side and bent over to the passenger side. I had not hit any construction debris etc. within 4 days of a full replacement my front windshield was shattered again! When the car was just sitting in the driveway. This crack spread out into three “legs” and got large and I had barely driven the car. I’ve owned lots of cars and I’ve never ever had a cracked windshield before- let alone two within 8 days!

The moon roof glass exploded and shattered while driving the car on a highway under the speed limit. The car is available for inspection though a repair has been initiated. Multiple pictures and a video were taken. If the inside shade cover had not been closed, shattered glass fragments would have cut the driver and passengers possibly impeding the driver’s vision and causing a crash. The problem shattered moon roof was confirmed by the dealer and a repair shop. No one would confirm what caused the moon roof glass to explode.The dealer’s service department and the repair shop inspected the problem. There was no warning. The glass just exploded with a very loud bang like a gun went off inside or near the care.

A crack developed in the windshield spontaneously with no outside forces causing it. It is available for inspection. This is the SECOND time this has happened to this vehicle since we have purchased it. The windshield was replaced in May, 2021 because of the SAME ISSUE. These spontaneous cracks can put our safety and the safety of others at risk by obscuring vision. This just happened (May 1, 2022) and it has not been inspected yet by a dealer or insurance representative.

The contact owns a 2020 Subaru Outback. The contact stated that there was a crack on the windshield. There was no impact on the windshield that could have caused the crack. The contact took the vehicle to a windshield repair shop. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 37,000.

Car is 2 years old. Battery has died twice already. Dealership cannot find any issue other than dead battery. Dealer told me that dead batteries in short timeframes is a known issue with this car. Batteries draining for no apparent reason is a safety risk as it indicates a larger problem, namely a possible parasitic drain on the battery and/or faulty electrical components. Dealer cannot replicate the issue in the few days they have had the car for repair. There was no warning of a battery failure. Car was driven earlier in the day with no issue. Tried to start it about 4 hours later and it was dead. Jump started it to take it to dealer for repair a few days later. Opened an incident report with Subaru of America on 5/2/22.

On April 13th 2022, me and my wife were returning home. We were at a complete stop on a left only turn intersection red light (Spring-Cypress Rd & Telge Rd in Cypress, TX. Coordinates: 29.985660988461188, -95.65465736615674). There was a vehicle ahead of us and also behind us at the light. It was raining lightly and the roads were wet. When the light turned green we started slowly accelerating making our left turn and as we were doing so, the vehicle skid causing uncontrolled acceleration, non-responsive braking and non responsive steering. I tried my very best to save us from running over the curb into the ditch ahead and succeeded to do so resulting in the vehicle hitting the curb at probably 15-20 mph. The steering and brakes were non-responsive and it took a lot of effort on my part to save us from running over the curb into the ditch ahead. This accident resulted in the right front passenger wheel, suspension, axle etc. to break. No other vehicle was involved in the accident. No warning or safety lights were displayed to the best of my knowledge. The vehicle was disabled and could not run, it was blocking the intersection and traffic. I called the police who then arrived to redirect traffic and also help with the tow. Currently, my car is being repaired through my insurance. My vehicle was purchased in Jan 2020 and has approx. 9500 miles on it. The reason i brought a Subaru was because of its capability to handle most weather conditions and also its great safety ratings. This unfortunately wasn't the case for me and wife and we were left stranded in the road because of some safety feature/software/mechanical malfunction of the vehicle. I request the NHTSA administration to look into this issue with Subaru and help me reach closure on the safety of this vehicle. Thank you.

That main concern I have is the windshield. My windshield has been replaced once already and it seems no matter what speed or road we are traveling if anything hits the windshield it cracks. I am not talking a chip or little crack either I am talking tiny rock 45 mph crack halfway through the entire windshield. It can’t be that safe of safety glass if a pea gravel smashes it at 45mph. First time it happened we were traveling through a blizzard at 30 mph rock crack the entire windshield….. the Subaru windshield is super expensive and can only be put in at specific places.

On 3 separate occasions, my transmission has switched from automatic mode to manual “Auto-stick” mode on its own with no input from me. There were no warning lamps or error messages, and the gearshift was still firmly in Drive. This has resulted in 3 near-miss accidents because the car landed in 1st gear even though I was going about 30 mph each time. From my experience driving manual transmission vehicles, I know what happens when a moving vehicle is suddenly jammed into 1st gear—it comes to an immediate, violent stop. On all 3 occasions, I was lucky not to have other cars behind me. But I know I won’t be so lucky forever. Sooner or later, I will be rear-ended when this happens. I have taken the car to the dealership twice for inspection. They told me that they had never heard of nor seen any vehicle doing what I described. Technicians drove it 7 miles and reported no incidents. I knew it was unlikely to happen on command since it has occurred 3 times in 32,000 miles. They told me that Subaru requires dealerships to reproduce issues before undertaking any repairs. Therefore, they returned the vehicle and told me that it absolutely could NOT change modes unless I had bumped or moved the gearshift. Less than 2 weeks later, the defect happened for the third time. I returned to the dealership and insisted they look further into the problem. I involved the Service Dept manager so that my complaint might be taken more seriously. There is an open recall on the transmission for slipping but they said the 2 issues were unrelated. This time they kept the car for a week and drove it 46 miles. They connected a diagnostic computer to the transmission while driving it. But again, I was told since they witnessed no problems, they could do nothing more. I showed them a blog on Edmunds.com from Subaru owners reporting this exact issue beginning in 2011. Owners have taken this to Subaru many times but new cars still do this. Please help. I’m at my wit’s end. Thank you.