2020 Subaru Outback

02/08/2022, at 8:20am, I noticed a crack on the windshield on the passenger side. No explanation how it got there and there is NO chip. The crack comes from the edge of the windshield, out about 5 inches then curves up another 2-3 inches and then curves again towards the driver side another 3-4 inches. Within 12 hours it has grown. This crack will eventually impact my ability to fully see ahead while driving ( light glare and disruptive to the driver). Bob Rhorman Subaru (my local Subaru dealership) will be inspecting the windshield on 02/14/2022. There was no warning signs to this happening. I know Subaru of America has a history of defective windshields and my 2020 Subaru Outback does follow under the windshield lawsuit against Subaru of America.

Within 2 months of purchase 2020 Outback the car's Infotainment center has continually malfunctioned including times when the car's backup camera is displayed while the car is in drive and moving forward. Eye-sight constantly disabled as well is infotainment center constantly blacking out and then resetting itself while car is in motion. Constant beepind telling driver to look at road - all especially in inclement weather. Car is unsafe. I have multiple videos showing this but they are too big to upload here.

The windshield on my 2020 Subaru Outback spontaneously cracked while I was driving the vehicle on a cold morning (01/20/2021). This crack is the second such spontaneous crack that has occurred with this same vehicle. The first crack occurred in the original windshield in June 2021, after which the original windshield was replaced with an OEM windshield. This second cracking event occurred with the OEM replacement windshield. About 30 minutes into driving the vehicle at freeway speeds (65 mph), a crack with a total length of about 10 inches (5 inches vertical, 5 inches horizontal) formed spontaneously mid-length on the windshield beginning from the bottom edge of the glass. The formation of the crack occurred quickly and was associated with a loud snapping sound. The path of the crack traveled through the location of a small (2mm x 2mm) chip in the glass located approximately 2 inches from the bottom edge of the glass. This chip in the glass occurred at least 2 months prior to the cracking event and was the result of an impact from a small rock (about 1cm x 1cm). No additional damage or impact force had occurred on the chipped location between the creation of the chip and the cracking event. If the crack had been larger and the associated snapping sound louder, the startling nature of the event and loud volume of the snapping sound would likely put someone driving the vehicle at risk of reacting in a hazardous fashion and result in a crash. Furthermore, since the Subaru Outback's forward collision warning, automatic emergency braking, adaptive cruise control, lane departure warning, and lane keeping assistance all operate through a camera-based system that requires a clear view through the windshield, the crack posed a risk of impacting these systems.

The windshield on my 2020 Subaru Outback spontaneously cracked shortly after I started the car on a hot summer day (06/28/2021). Roughly a minute after starting the vehicle and turning on the air conditioning, I drove a distance of about 100 ft and heard a really loud snap, but initially didn't see the cause of the sound. About 2 seconds later, a crack quickly spread horizontally from the driver's side edge at mid height of the windshield until reaching the center of the windshield. After continuing to drive the vehicle, the crack began to spread vertically for about 6 inches, and then spread further horizontally to the right by another 6 inches, forming an S-shape. No damage or chips were known to have been previously inflicted on the windshield and the glass was visibly intact prior the cracking event. Because the crack was positioned almost exactly at eye level, visibility was noticeably distorted. If the crack and associated snapping sound had occurred while the car was being driven in actual traffic on a road or freeway, the startling nature of the event and loud volume of the snapping sound would likely put someone driving the vehicle at risk of reacting in a hazardous fashion and result in a crash. Furthermore, since the Subaru Outback's forward collision warning, automatic emergency braking, adaptive cruise control, lane departure warning, and lane keeping assistance all operate through a camera-based system that requires a clear view through the windshield, the crack posed a risk of malfunction of these systems. The windshield was inspected by a professional automotive glass installation shop and was determined to have been damaged beyond repair, requiring total replacement.

Purchased my outback in January of 2020, Sometime in that same month I noticed a small crack in the windshield, down at the bottom on the passenger side. No idea how it cracked. by the next day the crack had grown to over 8 inches. I called subaru dealership and they stated that wasnt covered under warrantee and that they didnt deal with insurance companies directly so I would have to get it fixed by them, pay up front and get my insurance company to reimburse me directly. Called my insurance company and they said to just go to safelight. I explained it was a brand new car and I wanted original factory glass and they said ok. work was done, safety eyesight recalibrated and car was brand new again. Fast forward to today (jan 5 2022), about exactly 2 years from the first time. Driving down the road, heard a pop, didnt see a rock or debris hit me, look at the windshield and see a small crack in the uper driverside windshield. Knowing how fast the last crack grew I immediately headed to safelight. By the time I arrived there, the small crack (about 1/4 inch) had grown to over 12".

1.) Headlights. They are extremely bright to oncoming traffic and oncoming traffic is always flashing or beaming you with their high beams as they think your brights are on when they are not. This is dangerous. Also LED lights do not put off enough heat and the headlamp body itself freezes over in cold rain or snowy conditions severely reducing your ability to see during low light situations. Wipers. The windshield wipers do not last. They should be silicone and they are rubber which is terrible for longevity.

Windshield developed spontaneous crack on bottom edge of driver side extending 12-18” in line of sight of driver. There was no impact or stone hitting the windshield. Drove car for 30 minutes and parked car to go shopping. 5 minutes later the crack developed while still parked. Vehicle to be inspected by local dealer on December 29, 2021.